Documentos de Académico
Documentos de Profesional
Documentos de Cultura
ENSAYO DE TORSION
Abstract
We can say that a body is subject to a simple torsion section, when the reduction of the
forces acting on it, on one side of the section, results in a coupling that is contained in the
plane of the same. In other words, many materials when in service are subject to forces or
loads. In such conditions, it is necessary to know the characteristics of the material to
design the instrument where it is to be used in such a way that the stresses to which it will
be subjected are not excessive and the material does not fracture. The mechanical behavior
of a material is the reflection of the relationship between its response or deformation to an
applied force or load. Torsion testing is applied in industry to determine elastic constants
and material properties. This test can also be applied to measure the strength of welds,
joints, adhesives, etc. Torsion itself refers to a circular displacement of a certain cross
section of an element when a torque or a force that produces a torque around the axis is
applied to it. Torsion can be measured by observing the deformation that a given torque
produces in an object. For example, a cylindrical object of a certain length is fixed at one
end, and a couple of forces are applied to the other end; the number of turns one end makes
relative to the other is a measure of torque.
II
Contenido
1 Introducción.....................................................................................................................1
2 Objetivos..........................................................................................................................2
2.1 Objetivo general.......................................................................................................2
2.2 Objetivos específicos................................................................................................2
3 Marco teórico...................................................................................................................3
4 Resultados y análisis........................................................................................................4
5 Conclusiones....................................................................................................................5
6 Referencias......................................................................................................................6
III
1 Introducción
1
2 Objetivos
2
3 Marco teórico
El ensayo de torsión consiste en aplicar un par torsor a una probeta por medio de un
dispositivo de carga y medir el ángulo de torsión resultante en el extremo de la probeta.
Este ensayo se realiza en el rango de comportamiento linealmente elástico del material.
Las probetas utilizadas para este ensayo suelen ser de sección circular. La relación entre
momento torsor y deformación angular para los materiales ensayos están determinados por
ecuaciones matemáticas partiendo de que el material es elástico lineal y aplicando la ley de
Hooke donde la variación lineal en la deformación cortante conducirá a una
correspondiente variación lineal en el esfuerzo cortante lo largo de cualquier lineal radial
ubicada en la sección transversal. Para deducir las formulas de la torsión se deben
establecer una serie de hipótesis que pueden demostrarse matemáticamente y algunas de
ellas comprobarse experimentalmente.
El ensayo de torsión sirve para evaluar las propiedades mecánicas de materiales cuando se
someten a esfuerzos ocasionados por desplazamientos angulares.
3.1 ECUACIONES
Tr
τ máx= [ Pa , psi ]
J
π D2 [ 4 4 ]
J= m ,¿
32
D= Diámetro del eje
3
Angulo de Torsión
TL
θ= [rad ]
GJ
L=Longitud de la probeta
G= Modulo de rigidez [N/m2]
4
4 Resultados y análisis
5 Conclusiones
5
6 Referencias