Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Ada Abrsh2
Ada Abrsh2
NAME ID/NO
Objectives
It used to drive large loads with in short distances.
General objective
The general objective of this project is to improve the performance of Mechanical
scissor car jack to minimize the rotating force of the crank, to reduce time
consumations and to reduce the costs scissor jacks. And also to design Mechanical
scissor car jack that has the capacity to increase or decrease load of vehicle based on
the given specification.
Specific objectives
In our project the specific objectives are listed below;-
Design of power screw
Design of links
Design of driving handle
Design of connecting member
Design of base plate
Design of cup
Design of nut
Design of Bolt
Design of washer
Design of pin
Geometric and force analysis of the jack
Careful selection of appropriate material for each component crease load of
vehicle based on the given specification.
Design Requirements and proposed methodology
Material selection for parts single mechanical scissor jack
The material selection is done by first taking less expensive steel material, which is to
be changed depending upon the various outcomes of the design procedure (Strength
analysis).
We select steel, an AISI 1020 grade carbon steel material to design bolts because
of
Good heat treatment
High strength
Wear resistance
Ease of producing component parts
Given specification
Max height = 350mm
Min height = 150mm
Capacity load =1500kg
The whole dimension of the machine t the minimum and maximum height
Should be calculated first before we began force and strength analysis of
The machine.
Methodology
Conceptual sketch