Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Revisión: 0
DOCUMENTO TÉCNICO
CSL-192400-06-DO-002 Páginas: 12
Especialidad: Electromecánica
CONTROL DE REVISIONES
1. GENERAL ........................................................................................................... 2
1.1. Objetivo .............................................................................................................. 2
1.2. Alcances ............................................................................................................. 2
2. DESCRIPCIÓN DE LA ABRAZADERA .............................................................. 2
3. REFERENCIAS: DOCUMENTOS Y ESPECIFICACIONES ................................ 3
4. CÓDIGOS Y ESTÁNDARES DE DISEÑO ........................................................... 3
5. PROPIEDADES DE LOS MATERIALES ............................................................. 4
6. MÉTODO DE CÁLCULO ..................................................................................... 4
7. CONSIDERACIONES DE DISEÑO Y CÁLCULO ................................................ 4
7.1. Cargas Aplicadas ............................................................................................... 4
7.2. Combinaciones de carga................................................................................... 5
8. GEOMETRIA Y MODELO MATEMÁTICO .......................................................... 6
9. ENMALLADO CON ELEMENTOS SOLIDOS TETRAEDRICOS ........................ 7
10. CARGAS APLICADAS AL MODELO ................................................................. 8
11. ESFUERZOS DE VON MISES ............................................................................ 9
12. DEFLEXION DEL SOPORTE BAJO CARGAS DE SERVICIO ......................... 10
13. FACTOR DE SEGURIDAD DEL SOPORTE ..................................................... 11
14. CONCLUSIONES .............................................................................................. 11
CALCULO ESTRUCTURAL ABRAZADERA
1. GENERAL
1.1. Objetivo
1.2. Alcances
2. DESCRIPCIÓN DE LA ABRAZADERA
La abrazadera doble está conformada por dos (02) abrazaderas simples, dichas
abrazaderas simples están conformadas por dos (02) planchas metálicas que abrazan las
crucetas de madera existente. Las planchas que conforman la abrazadera simple tiene una
de ellas la forma plana y la otra en forma de C, para más detalle ver figuras 2-1 y 2-2.
Para el diseño de las estructuras de acero se han tomado en cuenta los siguientes códigos
y estándares:
ASCE 7-16 Minimum design loads for buildings and other structures.
TIA-EIA-222-F Structural Standards for Steel Antenna Tower and Antenna Supporting
Structures.
ASTM A325 Specification for Structures Bolts, Steel and Heat Treated.
ASTM A490 Specification for Heat Treated Alloy Steel Structural Bolts.
ASTM A5.1 Specifications for Covered Carbon Steel Arc Welding Electrodes.
AWS A5.1 Specifications for Carbon Steel Electrodes for Shielded Metal Arc
Welding.
AWS A5.17 Specification for Carbon Steel Electrodes and Fluxes for Submerged
Arc Welding.
AWS A5.18 Specification for Carbon Steel Electrodes and Rods for Gas Shielded
Arc Welding.
AWS A5.36 Specification for Carbon and Low-Alloy Steel Flux Cored Electrodes for
Flux Cored Arc Welding and Metal Cored Electrodes for Gas Metal Arc
Welding.
6. MÉTODO DE CÁLCULO
v1 t1 l1
V1 T1 L1
Dónde:
14. CONCLUSIONES