Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Edge flange brida arista Bent sheet metal wall created at an angle on the
edge of an existing base flante or an existing flange.
ESQUINAS
en brida arista al realizar dobleces hacia el al activarlo * se crea un desahogo para poder doblar las pestañas
interior(sin aumentar material) se puede
producir –si no está activado “recortar pliegue de
lados-
Si en esquina cerrada (3) he dejado sin activar open bend región **,y/o en brida arista no he
indicado “recortar pliegues de lados” (*) se habrá cerrado el hueco de la cara inclinada con más
radio de doblado y tengo que hacerlo después en 3d mediante este procedimiento (para que el
Ver archivo “tratamiento de esquinas” desahogo se cree automático he
de activar (*) y (**)) [en este
procedimiento controlamos los
desahogos de forma manual más
personalizado]
Romper esquinas/recortar esquinas
Matar aristas vivas mediante chaflán o redondeo
Hems Nota: if you select more than and edge to create the hem, the miter gap (hueco de inglete)
rollout will be displayed.
Material inside, outside
Aditional options:
- Link to thinkness
- Flip side to cut
extrude cuts
- Normal cut: if the profile of the
cut i son a different plane the cut
feature will be normal to the
sheet metal component. If you
clear this check box, resulting cut
feature will be created normal to v.18.44 tickoo
the sketching plane.
FORMADO- v. últimos dos dibujos-: (creado por un
utillaje) no crea líneas de plegado si no se cumplen unos
requisitos:
- Croquis formados en planos paralelos
pliegue - redondear las esquinas de croquis
recubierto - Deben contener el mismo núm. de entidades
PLEGADO: el software crea pliegues para poder formar la
pieza
3.-
elemento importado con 1.- design the entire part in the part
pliegues pero que no es mode/coger un elemento importado
chapa (sería igual que el 2.-convert it into a sheet metal
anterior pero como ya component mediante insert bends.
tengo los pliegues no
necesito crearlos y me insert bends: select the face to be
sobraría 3 y 4 ) fixed and the sheet metal parameters
CASO B.2-CONVERTING A
SOLID BODY INTO A SHEET
METAL
pieza sólida no es chapa select the face of the body that
will remain fixed(2)
Set the sheet thickness and the radius of
bend (puedo controlar ambos)
Select the edges that are on the selected
face (can be changed individually) (1)
REALIZAR CORTES QUE AFECTEN A LOS DOBLECES
CREATING CUTS IN A SHEET 1.- situarnos en el arbol de operaciones
METAL COMPONENT (subir persiana)justo por encima de
CREATED FROM A SOLID process bends (se aplanará)
MODEL 2.- realizo el sketch , y el corte en chapa
vinculado al espesor
3.-vuelvo a “roll back” en el árbol de
operaciones