Documentos de Académico
Documentos de Profesional
Documentos de Cultura
RESUMEN
En el presente informe de laboratorio se muestran los resultados de la práctica de parámetros químicos del
agua II, realizado en el laboratorio de química ambiental. Para la identificación de parámetros químicos del
agua se realizaron los métodos para la determinación de cloruros y sulfatos en una muestra de agua, la cual
se utilizaron diversos reactivos para determinación de estos, y los método de Morh y fotómetro para determinar
los cloruros y sulfatos presentas en la muestra problema, Teniendo en cuenta que el sulfato en el agua se
encuentra a diferentes concentraciones; el estándar en el agua potable del servicio de salud pública tiene un
límite máximo de 250 mg/L de sulfatos, ya que en valores superiores tiene una acción “purgante”; los
resultados obtenidos de la muestra tomada dieron 59mg/L de sulfato; y la máxima concentración permisible
de cloruros en el agua potable es de 250 mg/L, y en la práctica de laboratorio el resultado de cloruros nos dio
el dato de 229,928 mg/l , teniendo en cuenta estos resultados obtenidos y las concentraciones permisibles se
dice que esta muestra está dentro del rango permisible de agua potable, sin embargo para poder asegurar lo
dicho anteriormente se deben de realizar otras series de parámetros tanto químicos como físicos.
ABSTRACT
in the present laboratory report, the results of the practice of water parameters II, carried out in the
environmental chemistry laboratory, are shown. For the identification of the chemical parameters of the water
the methods of the determination of the chlorides and the sulphates in a water sample are used, which are used
various reagents for the determination of these, and the method of the photometers to determine the chlorides
and sulfates present in the problem sample, taking into account that the sulphate in the water is in different
configurations; The standard in drinking water The public health service has a maximum limit of 250 mg / L
of sulphates, and in the higher values it has a "purgative" action; The results of the sample taken gave 59mg /
L of sulphate; and the maximum permissible concentration of chlorides in drinking water is 250 mg / L, and in
laboratory practice the result of chlorides gave us the time of 229,928 mg / l, taking into account these results
and the permissible parameters if the given that this sample is within the permissible range of drinking water,
however, so we can be assured.
I. INTRODUCCIÓN
2
UNIVERSIDAD DE LA COSTA, CUC
DEPARTAMENTO DE CIVIL Y AMBIENTAL
PROGRAMA DE INGENIERÍA AMBIENTAL
3
UNIVERSIDAD DE LA COSTA, CUC
DEPARTAMENTO DE CIVIL Y AMBIENTAL
PROGRAMA DE INGENIERÍA AMBIENTAL
5
UNIVERSIDAD DE LA COSTA, CUC
DEPARTAMENTO DE CIVIL Y AMBIENTAL
PROGRAMA DE INGENIERÍA AMBIENTAL
ANEXOS
Fuente 1 : Autor
Fuente 2 : Autor
6
UNIVERSIDAD DE LA COSTA, CUC
DEPARTAMENTO DE CIVIL Y AMBIENTAL
PROGRAMA DE INGENIERÍA AMBIENTAL
Fuente 3 : Autor
Fuente 4 : Autor