Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Cerrar SIS
Pantalla anterior
Pruebas y Ajustes
3054 and 3056 Industrial and Generator Set Engines
Número de medio -SENR5542-05 Fecha de publicación -01/01/2002 Fecha de actualización -21/03/2002
i01462660
Table 1
Required Tools
Part Number Part Description Qty
8T-0455 Liner Projection Tool Group 1
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb... 01/06/2023
3056 Generator Set Engine 3GW00001-UP(SEBP2727 - 36) - Documentación Página 2 de 4
Illustration 1 g00323908
1. Ensure that the face of the valves are clean. Ensure that the bottom face of the cylinder head is
clean. Ensure that the cylinder head is not distorted. Refer to Testing and Adjusting, "Cylinder
Head - Inspect" for the procedure to measure flatness of the cylinder head.
2. Use the 8T-0455 Liner Projection Tool Group in order to check the depths of the inlet valve
and the exhaust valve below the face of the cylinder head. Use the gauge block (3) in order to
set the dial indicator (1) to zero.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb... 01/06/2023
3056 Generator Set Engine 3GW00001-UP(SEBP2727 - 36) - Documentación Página 3 de 4
Illustration 2 g00323909
Valve Depth
3. Measure the depth of the inlet valve and the exhaust valve below the cylinder head face. Use
the gauge body (2) and the dial indicator (1) in order to measure the depth. The minimum and
maximum limits for a new engine follow:
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb... 01/06/2023
3056 Generator Set Engine 3GW00001-UP(SEBP2727 - 36) - Documentación Página 4 de 4
4. Service wear occurs on an engine which has been in operation. If the valve depth below the
cylinder head face on a used engine exceeds the specification for service wear, the following
items must be replaced:
◦ Valves
◦ Valve inserts
◦ Cylinder head
5. Check each valve for cracks. Check the stems of the valves for wear. Ensure that the valves fit
in the valve guides. Refer to Testing and Adjusting, "Valve Guides - Test" for the procedure to
test the valve guides.
6. Check the load on the valve springs. Refer to Specifications, "Cylinder Head Valves" for the
proper lengths and specifications for the valve springs.
Copyright 1993 - 2023 Caterpillar Inc. Thu Jun 1 13:17:02 UTC-0430 2023
Todos los derechos reservados.
Red privada para licenciados del SIS.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb... 01/06/2023