Está en la página 1de 17

EXAMEN 2

EJERCICIO 2
Daniel González Puntos.

The following figure shows an L-shaped bracket made of structural steel with
Young’s modulus E = 200 GPa and Poisson’s ratio ν = 0.3. The 4 cm thick L-shape
with the cross-sectional profile shown in the figure is rigidly connected to a
rectangular base of size 3 cm × 8 cm × 1 cm. The bracket is fixed on the right end
at the base. A surface pressure of 10 MPa is exerted on the left end as shown below.
(1) Determine if static failure or buckling failure occurs in the bracket.
(2) Find the life of the bracket if it is subjected to a fully reversed cyclic pressure of
magnitude 10 MPa on the left end.

La siguiente figura muestra un soporte en forma de L de acero estructural con


Módulo de Young E = 200 GPa y razón de Poisson ν = 0.3. La forma de L de 4 cm
de grosor con el perfil de la sección transversal que se muestra en la figura está
rígidamente conectado a una base rectangular de tamaño 3 cm x 8 cm x 1 cm. El
soporte se fija en el extremo derecho en la base. Se ejerce una presión superficial
de 10 MPa en el extremo izquierdo, como se muestra a continuación.
(1) Determine si ocurre falla estática o falla de pandeo en el soporte.
(2) Encuentre la vida útil del soporte si está sujeto a una presión cíclica de magnitud
completamente invertida 10 MPa en el extremo izquierdo.
EXAMEN 2
EJERCICIO 2
Daniel González Puntos.
EXAMEN 2
EJERCICIO 2
Daniel González Puntos.
EXAMEN 2
EJERCICIO 2
Daniel González Puntos.
EXAMEN 2
EJERCICIO 2
Daniel González Puntos.
EXAMEN 2
EJERCICIO 2
Daniel González Puntos.
EXAMEN 2
EJERCICIO 2
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.

4.- Determine the pressure and velocity distributions of the flow of water inside the
following circular chamber. The chamber has a depth of 2 m. Assume nonslip
boundary conditions at the walls. The velocity of water at the inlets is 10 cm/s, and
the outlets are at atmospheric pressure.
4.- Determine las distribuciones de presión y velocidad del flujo de agua dentro del
siguiente cámara circular. La cámara tiene una profundidad de 2 m. Suponga
antideslizante condiciones de contorno en las paredes. La velocidad del agua en
las entradas es de 10 cm / s, y las salidas están a presión atmosférica
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.
EXAMEN 2
EJERCICIO 4
Daniel González Puntos.

También podría gustarte