Documentos de Académico
Documentos de Profesional
Documentos de Cultura
1
Escuela de Bioanálisis. Facultad de Medicina. Universidad del Zulia
(LUZ).
2
Escuela de Nutrición y Dietética. Facultad de Medicina. LUZ.
3
Facultad de Ciencias Veterinarias. LUZ.
Resumen
260
Rev. Fac. Agron. (LUZ). 2011, 28: 260-272
Abstract
Introducción Introduction
261
Benítez et al.
262
Rev. Fac. Agron. (LUZ). 2011, 28: 260-272
263
Benítez et al.
264
Rev. Fac. Agron. (LUZ). 2011, 28: 260-272
265
Benítez et al.
266
Rev. Fac. Agron. (LUZ). 2011, 28: 260-272
En lo que respecta a esta investi- Such findings agree with the obtained
gación, una vez sometido el plasma de in this investigation.
bovino a un tratamiento térmico a 90ºC In table 2, are observed the ave-
de temperatura interna de cocción, la rage values of RTA in the cookie
carga bacteriana se vio disminuida en formulated with cassava flour and
comparación con la carga inicial; ya bovine plasma. The results point that
que éstos microorganismos son sensi- the product stored the day zero (0) of
bles a las temperaturas empleadas. the study, exhibited a microbial
Cabe destacar, que Pérez et al, growth of 2.04 UFC/g, results that are
1997 obtuvieron valores similares al within the allowed limits according to
evaluar el efecto de la temperatura en the Venezuela Commission for Indus-
la calidad bacteriológica del plasma trial Norms (COVENIN 1483-2001).
sanguíneo de bovino; para lograr tal Likewise, throughout the days, the
propósito realizaron análisis microbio- microbial growth kept increasing
lógico de la muestra cruda y después progressively until reaching on day 15
de distintos tratamientos, incluyendo a count of 3.84 UFC/g, value that
congelación y calentamiento. Sus re- almost reaches the maximum allowed
sultados mostraron que hay un alto by this norm, consequently, fr day 20,
contaje de RTA y colifomes totales en the growth was of 4.29 UFC/g, which
la muestra cruda; mientras que des- exceeds the norms, indicating that the
pués del tratamiento térmico, dismi- elaborated cookie, for this date does not
nuyó la cantidad de estos fulfill the requirements from the
microorganismos. Tales hallazgos con- microbiological point of view.
cuerdan con los obtenidos en esta in- Likewise, the low levels of
vestigación. microbiological growth that the cookie
En el cuadro 2 se observan los presented in this study, are explained
valores promedios del RTA en la galle- due to the thermal treatment received
ta formulada a base de harina de yuca during its elaboration. At the same
y plasma de bovino. Los resultados time, this type of food is keeps in better
267
Benítez et al.
268
Rev. Fac. Agron. (LUZ). 2011, 28: 260-272
senta la galleta, lo que favorece su the days that passed during the study,
durabilidad, representando una venta- which indicates, that there are
ja de almacenamiento, favoreciendo así satisfactory hygienic conditions in the
su vida útil. elaboration of the product, being apt
Al comparar estas evidencias, for the human consumption, because
Fernández et al., 2006, evaluaron la it follows the COVENIN 1483-01
adición de suero porcino sobre la cali- norms, when having values lower than
dad y aceptación de un panqué de cho- 1 UFC/g.
colate; el análisis microbiológico lo lle- Chisté, 2006, performed a
varon a cabo 24 horas después de su microbiological study of cassava flour
elaboración y luego de 15 días de al- with the aim of verifying possible
macenamiento en condiciones de des- irregularities in the processing of the
pensa (25-28ºC); observaron el desarro- flour, as well as in the quality of the
llo de aerobios mesófilos (100 UFC/g). product; his results reflected that the
Sus hallazgos fueron similares a los final product fulfilled the patterns of
de este estudio, en cuanto al crecimien- microbiological quality demanded by
to en éste parámetro después de los 15 the National Agency of Sanitary
días de almacenamiento. Surveillance (ANVS). Likewise, in this
En los alimentos el nivel de con- investigation the counts of coliforms
taminación inicial constituye por lo ge- and E.coli were lower than 1 UFC/g,
neral el factor más importante y deter- which indicates and absence of these
minante en la extensión de la vida útil. microorganisms in the analyzed
Como puede apreciarse en el cuadro 3 samples, showing the adequate
una vez reflejados los resultados obte- hygienic conditions that were taking
nidos a partir del análisis microbiológi- into consideration at the time of
co realizado, se observa que no hubo elaborating, manipulating and
crecimiento microbiano de Mohos y packing the product.
Levaduras, E. coli y Coliformes totales Regarding the determination of
en ninguno de los días transcurridos del mold and yeast, the obtained findings
estudio, lo cual indica que existen con- in this research differ to those reported
diciones higiénicas satisfactorias en la by Fernández et al., 2006, when
elaboración del producto; demostrándo- finding after 15 days of storing, groth
se como apto para el consumo humano, of mold (10 UFC/g), indicating a
porque se mantiene dentro de la norma significant count, but inside the
COVENIN 1483-01 al arrojar valores acceptable values reported in the
menores a 1 UFC/g. literature.
Chisté, 2006, realizó un estudio Based on the explained before,
microbiológico de harina de yuca con la the more relevant practical implication
finalidad de verificar posibles irregula- of this cookie formulated with bovine
ridades en el procesamiento de la hari- plasma and cassava flour, had its
na así como en la calidad del producto; foundation in the knowledge of its
sus resultados reflejaron que el producto microbiological useful life, which
final se encontró dentro de los patrones allows establishing the time where its
de calidad microbiológica exigidos por microbiological deterioration started.
269
Benítez et al.
270
Rev. Fac. Agron. (LUZ). 2011, 28: 260-272
271
Benítez et al.
272