Documentos de Académico
Documentos de Profesional
Documentos de Cultura
0$18$/'(,16758d®(6 37
,16758&7,210$18$/ (1
MW 200 G
Horno Microondas
MANUAL DE INSTRUCCIONES
MODELO: MW 200 G BLANCO
Antes de utilizar su horno microondas lea estas instrucciones
detalladamente, y consérvelas para futuras consultas.
1
PRECAUCIONES PARA EVITAR LA POSIBLE EXPOSICIÓN A UNA
EXCESIVA ENERGÍA DE MICROONDAS
(a) No intente hacer funcionar este horno con la puerta abierta, ya que puede
producirse una exposición peligrosa a las microondas. Es importante no
forzar o manipular los cierres de seguridad.
(b) No coloque ningún objeto entre el frente del horno y la puerta ni deje que se acumulen
suciedad o restos de limpiador en las superficies de sellado.
IMPORTANTE
Si el aparato no se limpia adecuadamente, su superficie puede degradarse
acortando el tiempo de vida útil del mismo y puede crearse una situación de peligrosidad.
Especificaciones
2
,QVWUXFFLRQHV LPSRUWDQWHV GH VHJXULGDG
$'9(57(1&,$ 0ARA REDUCIR EL RIESGO DE INCENDIO DESCARGAS EL£CTRICAS
LESIONES A LAS PERSONAS O EXPOSICIN EXCESIVA A LAS
MICROONDAS CUANDO SE UTILICE EL APARATO SIGA LAS SIGUIENTES
PRECAUCIONES BÖSICAS
£$WHQFLyQ ,OS L¤QUIDOS U OTROS 5TILICE ESTE ELECTRODOM£STICO SLO PARA LOS
ALIMENTOS NO DEBEN SER CALENTADOS JAMÖS USOS DESCRITOS EN ESTE MANUAL .O UTILICE
EN AGENTES O VAPORES CORROSIVOS EN ESTE
RECIPIENTES SELLADOS YA QUE PODR¤AN ESTALLAR ELECTRODOM£STICO %STE HORNO HA SIDO
£$WHQFLyQ
%S PELIGROSO PARA QUIEN NO DISE®ADO PARA CALENTAR NO PARA SER USADO EN
SEA UN T£CNICO AUTORIZADO QUITAR LA INDUSTRIAS O EN LABORATORIOS
COBERTURA DE PROTECCIN QUE GARANTIZA LA 3I EL CABLE ORIGINAL DEL APARATO SE HA DA®ADO
PROTECCIN DE LA EXPOSICIN A LA ENERG¤A DE DEBE SER SUSTITU¤DO POR EL FABRICANTE POR EL
MICROONDAS SERVICIO DE MANTENIMIENTO O POR PERSONAL
£$WHQFLyQ 0ERMITA EL USO DEL HORNO CUALIFICADO PARA PREVENIR CUALQUIER SITUACIN
MICROONDAS A LOS MENORES SLO DESPU£S DE DE PELIGRO
HABERLES IMPARTIDO LAS INSTRUCCIONES QUE LES .O GUARDE Y NO UTILICE ESTE ELECTRODOM£STICO AL
PERMITAN USAR EL HORNO DE FORMA SEGURA AIRE LIBRE
Y CUANDO HAYAN COMPRENDIDO LOS PELIGROS .O UTILICE ESTE HORNO CERCA DEL AGUA DEL
QUE CORREN USÖNDOLO DE MANERA INCORRECTA FREGADERO MOJADO O CERCA DE UNA PISCINA
£$WHQFLyQ 3I UTILIZA EL HORNO DE FORMA ,A TEMPERATURA DE LAS SUPERFICIES ACCESIBLES
COMBINADA LOS MENORES DEBER¤AN USARLO SLO PODR¤A SER ELEVADA DURANTE EL FUNCIONAMIENTO DEL
BAJO LA SUPERVISIN DE UN ADULTO DEBIDO A LA ELECTRODOM£STICO -ANTENGA EL CABLE DE
TEMPERATURA QUE SE GENERA SLO PARA ALIMENTACIN LEJOS DE SUPERFICIES
LA SERIE CON GRILL CALIENTES Y NO CUBRA EL HORNO POR NINGUNA
5TILICE SOLAMENTE UTENSILIOS ADECUADOS PARA RAZN
SER USADOS CON HORNOS MICROONDAS .O DEJE QUE EL CABLE DE ALIMENTACIN QUEDE
%L HORNO DEBE LIMPIARSE CON REGULARIDAD Y COLGANDO SOBRE EL BORDE DE LA MESA O DE LA
SE DEBE QUITAR CUALQUIER TIPO DE RESTO DE SUPERFICIE DE TRABAJO
ALIMENTO 3I NO SE SIGUEN LAS INDICACIONES DE LIMPIEZA SE
,EA Y RESPETE LAS 02%#!5#)/.%3
PODR¤AN DA®AR LAS SUPERFICIES Y ELLO PODR¤A
0!2! %6)4!2 0/3)",%3 %80/3)#)/.%3 ACORTAR LA VIDA DEL ELECTRODOM£STICO ADEMÖS DE
%8#%3)6!3 ! ,! %.%2'Ù! $% PROVOCAR SITUACIONES PELIGROSAS
-)#2//.$!3v -EZCLE O AGITE SIEMPRE EL CONTENIDO DE
#UANDO CALIENTE ALIMENTOS EN RECIPIENTES BIBERONES Y RECIPIENTES PARA ALIMENTOS DE LOS
DE PLÖSTICO O DE PAPEL VIGILE EL HORNO YA BEB£S Y CONTROLE LA TEMPERATURA DE LOS
QUE SE PODR¤A INCENDIAR MISMOS PARA EVITAR QUEMADURAS
3I VE QUE HAY HUMO APAGUE Y DESCONECTE %L CALENTAMIENTO DE BEBIDAS EN EL MICROONDAS
EL HORNO DE LA TOMA DE CORRIENTE Y MANTENGA PODR¤A PROVOCAR UN PROCESO DE EBULLICIN
LA PUERTA CERRADA PARA APAGAR UNA POSIBLE RETARDADA POR LO TANTO TENGA CUIDADO CUANDO
LLAMA MUEVA EL RECIPIENTE
.O CUEZA EXCESIVAMENTE LOS ALIMENTOS .O UTILIZAR LIMPIADORES A VAPOR
.O UTILICE EL INTERIOR DEL HORNO COMO $URANTE EL USO EL APARATO SE CALIENTA 4ENGA
RECIPIENTE .O DEJE PRODUCTOS COMO PAN CUIDADO DE NO TOCAR ELEMENTOS CALIENTES DENTRO
BIZCOCHOS ETC EN EL INTERIOR DEL HORNO DEL HORNO
1UITE LOS CIERRES METÖLICOS Y LAS ASAS DE ,AS PARTES ACCESIBLES PODR¤AN CALENTARSE
METAL DE LOS RECIPIENTESBOLSAS DE PAPEL O DE DURANTE EL USO -ANTENER LEJOS DEL ALCANCE DE
PLÖSTICO ANTES DE COLOCARLOS EN EL HORNO LOS NI®OS PEQUE®OS
)NSTALE O COLOQUE EL HORNO SIGUIENDO LAS
.O UTILICE LIMPIADORES ABRASIVOS O ÖSPEROS NI
INTRUCCIONES PARA LA INSTALACIN
RASPADORES METÖLICOS PARA LIMPIAR EL CRISTAL
SUMINISTRADAS
DE LA PUERTA DEL HORNO YA QUE PODR¤AN RAYAR LA
,OS HUEVOS CON CÖSCARA Y LOS HUEVOS DUROS
SUPERFICIE QUE SE PODR¤A ROMPER
NO DEBEN CALENTARSE EN EL HORNO MICROONDAS
PORQUE PODR¤AN ESTALLAR INCLUSO DESPU£S DE
HABER TERMINADO EL CALENTAMIENTO EN EL
MICROONDAS
3
Para reducir el riesgo de daños a las personas
Puesta a tierra
Este electrodoméstico debe instalarse con
PELIGRO toma de tierra. En el caso de que se
Peligro de descargas eléctricas El produzca un cortocircuito, la toma de tierra
contacto con ciertos componentes reduce el riesgo de descarga eléctrica por la
internos puede producir lesiones graves existencia de un cable por el que puede
o incluso la muerte. No desmonte el escaparse la corriente eléctrica. Este
electrodoméstico. electrodoméstico está equipado con un cable
que tiene un conductor de tierra y un enchufe
con toma de tierra. El enchufe debe
ADVERTENCIA introducirse en una toma que esté
Peligro de descargas eléctricas. adecuadamente instalada y puesta a tierra.
El uso inadecuado de la puesta a tierra
puede producir descargas eléctricas. No Consulte a un electricista cualificado o a un
enchufe el aparato hasta que esté técnico de mantenimiento si no comprende
correctamente instalado y puesto a tierra. totalmente las instrucciones sobre la puesta a
tierra o si tiene alguna duda sobre la forma
en que el electrodoméstico queda
LIMPIEZA correctamente conectado a tierra. Si fuera
necesario un cable alargador, use solamente
Cerciórese de que el horno esté
un alargador de tres hilos.
desconectado de la red.
1. Limpie el interior del horno con
un paño ligeramente húmedo tras
utilizarlo.
2. Limpie los accesorios como 1. Se facilita un cable de alimentación corto
para reducir el riesgo de que se enrede o
hace habitualmente en agua con
enganche si fuera más largo.
detergente.
2. Si se usa un conector múltiple o un cable
3. El marco de la puerta, la junta y
alargador:
las piezas cercanas han de
1) Las características eléctricas nominales
limpiarse cuidadosamente con un
paño húmedo cuando estén sucias. del conector o cable alargador deben ser
iguales a las características eléctricas
nominales del electrodoméstico.
Enchufe de dos polos redondos
2) El cable alargador debe ser del tipo de
3 hilos con toma de tierra.
3) El cable alargador debe disponerse de
forma que no quede por encima de la
mesa o encimera, de manera que los
niños no puedan tirar de él o pueda
engancharse sin querer.
4
87(16,/,26
6£ANSE LAS INSTRUCCIONES SOBRE h-ATERIALES
QUE PUEDEN USARSE O DEBEN EVITARSE EN EL
HORNO MICROONDASv !LGUNOS UTENSILIOS NO
METÖLICOS PUEDEN NO SER SEGUROS PARA SU USO
EN UN HORNO MICROONDAS %N CASO DE DUDAS
PUEDE PROBAR EL UTENSILIO EN CUESTIN
35(&$8&,Ï1 APLICANDO EL PROCEDIMIENTO QUE SE DESCRIBE A
3HOLJUR GH OHVLRQHV SHUVRQDOHV CONTINUACIN
%S PELIGROSO PARA CUALQUIERA QUE NO EST£ 3UXHED GH XWHQVLOLRV
CUALIFICADO REALIZAR REPARACIONES O ,LENE UN RECIPIENTE APTO PARA HORNO
MANTENIMIENTO QUE SUPONGAN RETIRAR LA TAPA MICROONDAS CON UN VASO DE AGUA FR¤A ML
DE MICA QUE PROTEGE DE LA EXPOSICIN A LAS E INTROD¢ZCALO EN EL HORNO MICROONDAS CON EL
UTENSILIO EN CUESTIN
MICROONDAS #OCINE A LA POTENCIA MÖS ALTA DURANTE
MINUTO
4OQUE CON CUIDADO EL UTENSILIO 3I ESTÖ
CALIENTE NO LO UTILICE PARA COCINAR EN EL HORNO
MICROONDAS
.O SUPERE MINUTO DE COCCIN
0DWHULDOHVTXHSXHGHQXVDUVHHQHOKRUQRPLFURRQGDV
8WHQVLOLRV 2EVHUYDFLRQHV
3DSHO GH DOXPLQLR 0ARA
PROTECCIN SOLAMENTE 0UEDEN USARSE PIEZAS PEQUE®AS Y LISAS PARA CUBRIR
PIEZAS DELGADAS DE CARNE DE VACUNO O AVE PARA EVITAR LA SOBRECOCCIN 3I EL PAPEL DE ALUMINIO
ESTUVIERA MUY CERCA DE LAS PAREDES DEL HORNO PODR¤A FORMARSE UN ARCO
EL£CTRICO %L PAPEL DEBE COLOCARSE A UNA DISTANCIA DE AL MENOS CM
PULGADA DE LAS PAREDES DEL HORNO
3ODWR7RVWDGRU 3EGUIR LAS INSTRUCCIONES DEL FABRICANTE %L FONDO DEL PLATO TOSTADOR DEBE ESTAR AL MENOS A3/6 PULGADAS
MM POR ENCIMA DEL PLATO GIRATORIO %L USO INCORRECTO PUEDE DAR LUGAR A QUE SE ROMPA DICHO PLATO
0HQDMH 5SE SLO MENAJE APTO PARA HORNOS MICROONDAS 3IGA LAS INSTRUCCIONES DEL FABRICANTE .O
UTILICE PLATOS ROTOS O DA®ADOS
)UDVFRV GH YLGULR 2ETIRE SIEMPRE LA TAPA 5TIL¤CELOS SOLO PARA CALENTAR LOS ALIMENTOS HASTA
QUE EST£N TEMPLADOS ,A MAYOR¤A DE LOS FRASCOS DE VIDRIO NO SON
RESISTENTES AL CALOR Y PUEDEN ROMPERSE
9DMLOODGH YLGULR 5TILICE SOLO VAJILLA DE VIDRIO RESISTENTE AL CALOR DEL HORNO !SEG¢RESE DE QUE NO TENGA
ADORNOS MET ÖLICOS .O UTILICE PLATOS ROTOS O DA®ADOS
%ROVDV GH FRFLQDU 3IGAS
LAS INSTRUCCIONES DEL FABRICANTE .O LAS CIERRE CON TIRAS METÖLICAS
(AGA UNOS CORTES PARA DEJAR SALIR EL VAPOR
3ODWRV \ YDVRV GH 5TIL¤CELOS SOLAMENTE PARA UN CALENTAMIENTO O COCCIN CORTOS .O DESATIENDA EL
SDSHO HORNO MIENTRAS COCINA
3DSHO GH FRFLQD 5TIL¤CELO PARA CUBRIR LOS ALIMENTOS Y PARA RECALENTAR Y ABSORBER LA GRASA
5TIL¤CELO BAJO SUPERVISIN Y DURANTE PER¤ODOS DE COCCIN CORTOS
3OiVWLFR 5TILICE SOLO PLÖSTICO APTO PARA HORNOS MICROONDAS 3IGA LAS INSTRUCCIONES DEL FABRICANTE
$EBE LLEVAR UNA ETIQUETA DE h!PTO PARA MICROONDASv !LGUNOS RECIPIENTES DE PLÖSTICO SE
ABLANDAN A MEDIDA QUE SE CALIENTA EL ALIMENTO EN SU INTERIOR ,AS hBOLSAS PARA HERVIRv Y
LAS BOLSAS DE PLÖSTICO TOTALMENTE CERRADAS DEBEN RASGARSE PINCHARSE O VENTILARSE SEG¢N
SE INDICA EN EL ENVOLTORIO
3OiVWLFR 5TILICE SOLO SOiVWLFRtransparente apto PARA HORNO MICROONDAS 3E USA PARA TAPAR LOS
7UDQVSDUHQWH ALIMENTOS
7HUPyPHWURV 5TILICE SOLO TERMMETROS APTOS PARA HORNOS MICROONDAS TERMMETROS PARA
CARNE Y DULCES
3DSHOYHJHWDO Utilícelo como tapa para evitar salpicaduras, retener la humedad ó como envoltura para
cocinar al vapor.
5
Materiales que hay que evitar en el horno microondas
Utensilios Observaciones
Bandejas de aluminio Pueden formar arco eléctrico. Pase los alimentos a un plato apto para
horno microondas.
Envase de cartón para Pueden formar arco eléctrico. Pase los alimentos a un plato apto para
alimentos con mango horno microondas.
de metal
Utensilios metálicos o El metal impide el paso de la energía de microondas hacia los alimentos.
con adornos metálicos Los adornos metálicos pueden formar arco eléctrico.
Tiras de atar metálicas Pueden formar arco eléctrico e incendiarse dentro del horno
Bolsas de papel Pueden incendiarse dentro del horno
Poliespán El poliespán puede fundirse o contaminar los líquidos
cuando se exponen a altas temperaturas.
Madera La madera se secará si se introduce en el horno microondas
y puede partirse o agrietarse.
E D C B
6
INSTALACIÓN DEL PLATO GIRATORIO
Cubo central (cara de abajo) a. No ponga nunca la bandeja de vidrio boca abajo. La bandeja
de vidrio debe poder moverse siempre.
b. Para la cocción deben usarse siempre la bandeja de vidrio y el
conjunto del aro giratorio
Bandeja de vidrio
c. Todos los alimentos y sus recipientes deben ponerse siempre
sobre la bandeja de vidrio para la cocción.
d. Si la bandeja de vidrio o el conjunto del aro giratorio se
Eje giratorio rompen o agrietan, póngase en contacto con el centro de
servicio autorizado más cercano.
Instalación en la encimera
Retire todo el material de embalaje y los Carcasa: retire la película de protección de la
superficie de la carcasa.
accesorios.
No retire la tapa de color marrón claro de
Revise el horno en busca de daños, como
mica fijada en la cavidad del horno para
puerta con abolladuras o rota. No instale el
proteger el magnetrón
horno si está dañado.
Instalación
(3) El bloqueo de las aberturas de entrada
1. Escoja una superficie nivelada que y/o salida pueden dañar el horno.
tenga espacio suficiente para los (4) Coloque el horno tan lejos como sea
venteos de entrada y/o salida. posible de radios y televisores. El
funcionamiento del horno microondas
puede causar interferencias en la
Se requiere un espacio mínimo de 7,5 cm recepción de las emisiones de radio o TV.
(3,0 pulgadas) entre el horno y la pared 2. Enchufe el horno en una toma doméstica
adyacente. Un lado debe quedar abierto. convencional. Asegúrese de que la tensión
(1) Deje un espacio mínimo de 30 cm (12 y la frecuencia es la misma que la tensión
pulgadas) por encima del horno. y frecuencia indicada en la etiqueta del
(2) No quite las patas de la parte de abajo aparato.
del horno.
ADVERTENCIA: No instale el horno sobre
una placa de cocina u otro electrodoméstico
12 inch(30cm)
que produzca calor. Si se instala cerca o
3.0 inch(7.5cm) OPEN
sobre una fuente de calor, el horno podría
3.0 inch(7.5cm) dañarse invalidando así su garantía.
7
FUNCIONAMIENTO
33 % microondas
Descongelar
8
Detección de averías
Normal
El horno microondas Las emisiones de radio y televisión pueden verse
interfiere con la recepción de la interferidas cuando el horno microondas esté en funcionamiento.
TV Es similar a las interferencias de los pequeños
electrodomésticos, como batidoras, aspiradoras y ventiladores.
La luz del horno es tenue Al cocinar a baja potencia, la luz del horno puede atenuarse. Es
normal
Se acumula vapor en la Al cocinar, puede salir vapor de los alimentos. La mayor parte de
puerta. Sale aire éste sale por los venteos. Pero algo puede quedarse acumulado
FDOLHQWHSRUORVYHQWHRV en un lugar más fresco como la puerta del horno. Es normal.
El horno se enciende No se producen daños en el horno si éste funciona vacío un corto
accidentalmente sin período de tiempo. Sin embargo, debe evitarse.
alimentos dentro.
Según la directiva Waste of Electrical and Electronic Equipment (WEEE), los residuos
WEEE han de recogerse y tratarse por separado. Si, en el futuro, necesita desprenderse
de este producto, NO lo ponga en los residuos domésticos, envíelo a los puntos de
recogida WEEE si existen
9
Forno Microondas
MANUAL DE INSTRUÇÕES
MODELO: MW 200 G BLANCO
Antes de utilizar o seu forno microondas leia estas instruções
atentamente e conserve-as para futuras consultas.
10
PRECAUÇÕES PARA EVITAR A POSSÍVEL EXPOSIÇÃO A UMA
EXCESSIVA ENERGIA DE MICROONDAS
(a) Não tente colocar em funcionamento o forno com a porta aberta, pois pode produzir-se
uma exposição perigosa às microondas. É importante não forçar ou
manipular os fechos de segurança.
(b) Não coloque nenhum objecto entre a frente e a porta do microondas e não deixe
acumular sujidade ou restos de produto de limpeza nas superfícies vedantes.
NOTA:
Se o aparelho não for limpo adequadamente, a sua superfície pode degradar-se diminuindo
o tempo de vida útil, podendo ocorrer perigo.
Especificações
11
,QVWUXo}HVGHVHJXUDQoDLPSRUWDQWHV
$'9(57Ç1&,$ 0ARA REDUZIR O RISCO DE INCäNDIO DESCARGAS EL£CTRICAS LESµES EM PESSOAS
OU EXPOSIÀâO EXCESSIVA ÜS MICROONDAS QUANDO SE UTILIZA O
APARELHO OBSERVE AS SEGUINTES PRECAUÀµES BÖSICAS
5TILIZE ESTE ELECTRODOM£STICO UNICAMENTE
$WHQomR
,¤QUIDOS OU OUTROS ALIMENTOS PARA Os fins DESCRITOs NESTE MANUAL .âO UTILIZE
NâO DEVERâO SER AQUECIDOS EM RECIPIENTES AGENTES OU VAPORES CORROSIVOS NESTE
HERMETICAMENTE FECHADOS POis PODEM ELECTRODOM£STICO %STE aparelho FOI CONCEBIDO
EXPLODIR apenas para uso doméstico e não para uso
$WHQomR
» PERIGOSO retirar a tampa de INDUSTRIAL OU EM laboratório.
segurança que protege contra a exposição
ás microondas. 3E O CABO de alimentação FORNECIDO ESTIVER
DANIFICADO TEM DE SER SUBSTITU¤DO por pessoal
$WHQomR
Não permita A UTILIZAÀâO DO qualificado, de modo a prevenir situações de risco.
mICROONDAS por MENORES SEM
pREVIAMENTE LHES TER dado as devidas
iNSTRUÀµES QUE permitam utilizar o .âO ARMAZENE OU UTILIZE ESTE
fORNO EM SEGURANÀA. Certifique-se que tenham ELECTRODOM£STICO NO EXTERIOR
COMPREENDIDO os perigos a que estão .âO UTILIZE ESTE aparelho PRXIMO DE ÖGUA EM
EXPOSTOS POR uma utilização incorrecta. LAVA LOuÀAS MOLHADOS OU PERTO DE PISCINAS
$URANTE O FUNCIONAMENTO DESTE
$WHQomR
1UANDO O aparelho for UTILIZADO ELECTRODOM£STICO A TEMPERATURA DAS
NA OPÀâO COMBI OS MENORES SUPERF¤CIES ACESS¤VEIS PODE SER ELEVADA
DEVERâO UTILIZÖ LO apenas SOB SUPERVISâO -ANTENHA O CABO DE ALIMENTAÀâO AFASTADO DE
DE UM ADULTO DEVIDO à elevada temperatura SUPERF¤CIES QUENTES. Nunca tape o aparelho.
alcançada APENAS nos modelos com GRILL .
5tilize
APENAS recipientes PRPRIOS .âO DEIXE O CABO DE ALIMENTAÀâO a pender
PARA UTILIZAÀâO EM FORNO MICROONDAS da mesa ou bancada onde está instalado.
Deverá
limpar o microondas regularmente
e retirar os restos de alimentos. Se não seguir as indicações de limpeza,
a superficie do aparelho pode ficar danificada,
reduzindo o seu tempo útil de vida provocando
,EIA
E SIGA AS INDICAÀµES DADAS NO situações de perigo.
PARÖGRAFO 02%#!5¡%3 0!2! %6)4!2
%80/3)ª/ %8#%33)6! ! 2!$)!¡%3 Agite sempre o CONTE¢DO DE BIBERONS E RECIPIENTES
-)#2//.$!3 com ALIMENTOS PARA BEB£S e controle sempre a
1UANDO
AQUECER ALIMENTOS EM TEMPERATURA DOS ALIMEN TOS para evitar queimaduras.
RECIPIENTES DE PLÖSTICO OU PAPEL MANTENHA
O FORNO SOB vigilância por haver
RISCO DE INCäNDIO / AQUECIMENTO DE BEBIDAS no MICROONDAS
OBSERVAR FUMO NO INTERIOR DO FORNO
3E PODE PROVOCAR UM PROCESSO DE EBULIÀâO
DESLIGUE o aparelho retirando a fICHA RETARDADO 0OR ISSO Tenha cUIDADO AO
DA TOMADA E mantenha A PORTA FECHADA PARA MOVer O RECIPIENTE
Apagar uma possível CHAMA .âO Utilize APARELHOS DE LIMPEZA A VAPOR
.âO COZinhe EXCESSIVAMENTE OS ALIMENTOS / APARELHO AQUECE DURANTE O
.âO UTILIZE O interior do microondas para FUNCIONAMENTO Tenha o CUIDADO
GUARDAR alimentos .âO DEIXE PRODUTOS COMO dE não TOCAR NoS elementos QUENTES
PâO BISCOITOS ETC NO INTERIOR DO FORNO no interior do fORNO
2Etire OS FECHOS e pegas METÖLICOs dos !LGUMAS PARTES ACESS¤VEIS PODERâO FICAR
RECIPIENTESSACOS DE papel ou plástico QUENTES DURANTE a utilização -ANTENHA AS
ANTES DE OS colocar NO interior do microondas. CRIANÀAS AFASTADAS DO APARELHO
.âO Utilize PRODUTOS DE limpeza aBRASIVOS OU
)NSTALE O aparelho DE ACORDO COM AS ESFREGµES DE METAL PARA LIMPAR O VIDRO DA
INSTRUÀµES DE INSTALAÀâO QUE LHE são PORTA POIS PODERÖ RISCAR A SUPERF¤CIE.
FORNECidas
/VOS INTEIROS E OVOS COZIDOS NâO DEVERâO
SER AQUECIDOS NO FORNO MICROONDAS POis
PODEM REBENTAR, MESMO DEPOIS DO
AQUECIMENTO ter terminado.
12
Para reduzir o risco de perigo nas pessoas
Ligação à terra
Este electrodoméstico deve ter ligação à terra. No caso de
PERIGO um curto-circuito, a ligação à terra reduz o risco de
Perigo de choque eléctrico. descarga. Este aparelho está equipado com um cabo
O contacto com determinados que possui condutor terra e ficha com ligação à terra.
componentes internos pode A ficha deverá ser ligada apenas a uma tomada
provocar lesões graves ou, correctamente instalada e com ligação à terra.
inclusivamente, a morte. Não
desmonte o electrodoméstico.
Contacte um electricista qualificado se tiver alguma dúvida
sobre as instruções da ligação eléctrica do aparelho
ADVERTÊNCIA à terra.
Perigo de choque eléctrico.
O uso inadequado da ligação à
terra pode provocar descargas
eléctricas. Não ligue o aparelho
enquanto não estiver
correctamente instalado e com
ligação à terra.
13
LOUÇA 6Er AS INSTRUÀµES SOBRE h-ATERIAIS
QUE PODEM ser utilizados e qUE SE DEVEM
EVITAR NO FORNO MICROONDASv !LGUma
louça nâO METÖLICa PODE NâO SER
SEGURa PARA A SUA UTILIZAÀâO NUM FORNO
MICROONDAS %M CASO DE D¢VIDAS PODE
35(&$8d2 TESTAR a louça EM QUESTâO APLICANDO O
3HULJR GH OHV}HV seguinte PROCEDIMENTO:
» PERIGOSO PARA QUALQUER PESSOA QUE NâO
ESTEJA HABILITADA, EFECTUAR REPARAÀµES OU 7HVWH á louça
MANUTENÀâO QUE IMPLIQUEM RETIRAR a tampa Coloque o recipiente vazio e um copo
com água (ml) no interior do forno.
de mica QUE PROTEGE DA EXPOSIÀâO ÜS
MICROONDAS
Seleccione Ü POTäNCIA MÖXIMA DURANTE
1 MINUTO
Se o recipiente estiver muito quente,
nâO O UTILIZE PARA COZINHAR NO FORNO
MICROONDAS
1mR VXSHUH PLQXWR GH FRzedura
0DWHULDLV TXH SRGHP ser utilizados QR IRUQR PLFURRQGDV
8WHQVtOLRV 2EVHUYDo}HV
)ROKD GH DOXPtQLR !PENAS PARA PROTECÀâO 0ODEM UTILIZAR SE PEÀAS PEQUENAS E LISAS PARA tapar
peças FINAS DE CARNE DE BOVINO OU AVE PARA EVITAR cozinhar a mais 3E A FOLHA DE
ALUM¤NIO ESTIVER MUITO PRXIMA DAS PAREDES DO FORNO PODE FORMAR SE
UM ARCO EL£CTRICO Deve colocar o papel a uMA DIST½NCIA DE PELO
MENOS CM DAS PAREDES DO FORNO
Prato tostador 3IGA AS INSTRU˵ES DO FABRICANTE O fundo do prato tostador deve estar a pelo
5mm por CIMA DO PRATO ROTATIVO 5Ma utilização INCORRECTa PODE partir o prato.
Serviço de louça UTILIZE APENAS serviços aPTOS PARA FORNO MICROONDAS 3IGA AS
INSTRUÀµES DO FABRICANTE .âO UTILIZE PRATOS PARTIDOS OU ESTALADOS
)UDVFRV GH YLGUR 2ETIRE SEMPRE A TAMPA 5TILIZE OS APENAS PARA AQUECER OS ALIMENTOS
AT£ ficarem mORNOS ! MAIORIA DOS FRASCOS DE VIDRO NâO SâO
RESISTENTES AO CALOR E PODEM-se partir
Louça de 5TILIZE APENAS louça DE VIDRO RESISTENTE AO CALOR !SSEGURE SE DE QUE
YLGUR NâO TENHAM ADORNOS METÖLICOS .âO UTILIZE PRATOS PARTIDOS OU ESTALADOS
6DFRV SDUD 3IGA AS INSTRUÀµES DO FABRICANTE .âO OS FECHE COM fechos METÖLICOS &AÀA ALGUNS
FR]LQKDU CORTES PARA O VAPOR poder sair
3UDWRV H FRSRV GH 5TILIZE OS APENAS PARA UM AQUECIMENTO OU COzinhado rápido 6IGIE O FORNO ENQUANTO
SDSHO COZINHA
Papel de cozinha 5TILIZE PARA tapar oS aLIMENTOs e pARA AQUECER E ABSORVER A GORDURA
6IGIE O FORNO E UTILIZE APENAS PARA UM cozinhado de pouca duração
3OiVWLFR 5TILIZE aPENAS pLÖSTICO aPTO pARA FORNOS MICROONDAS SIGA AS instruções do
FABRICANTE $EVE TER UMA ETIQUETA a indicar que é "!PTo PARA microondas".
!LGUNS RECIPIENTES DE PLÖSTICO AMOLECEM Ü MEDIDA QUE o alimento
é aquecido NO SEU INTERIOR SaCOS DE PLÖSTICO hermeticamente fechados
DEVEM ser perfurados ou ventilados conforme indicado na embalagem.
Película aderente 5TILIZE APENAS película APTA PARA FORNO MICROONDAS 5TILIZA SE PARA TAPAR OS
ALIMENTOS DURANTE o cozinhado Esta película não deve tocar nOS ALIMENTOS
7HUPyPHWURV 5TILIZE APENAS TERMMETROS APTOS PARA FORNOs MICROONDAS TERMMETROS PARA CARNE E
DOCES
3DSHOvegetal 5TILIZE O COMO COBERTURA PARA EVITAR SALPICOS E RETER A HUMIDADE
14
Materias a evitar utilizar no forno microondas
Recipiente Observações
Bandeja de alumínio Pode formar arco eléctrico. Coloque os alimentos num p r a t o
apto para forno microondas.
Cartão com pega Pode formar arco eléctrico. Coloque os alimentos num
de metal prato apto para forno microondas.
E D C B
G
15
INSTALAÇÃO DA BANDEJA DE VIDRO
Cubo central (face inferior)
a. Nunca coloque a bandeja virada para baixo, esta deve poder
rodar sempre.
b. Para cozinhar deve utilizar sempre a bandeja de vidro e o
Bandeja de vidro conjunto do suporte rotativo.
c. Todos os alimentos e os seus recipientes devem colocar-se
sempre sobre a bandeja de vidro.
Acoplamento motor d. Se a bandeja de vidro ou o conjunto do suporte rotativo se
danificarem, contacte o Serviço Técnico autorizado mais
próximo.
Suporte rotativo
Instalação
(3) O bloqueio das aberturas de ventilação
1. Seleccione uma superfície nivelada que podem danificar o forno microondas.
tenha espaço suficiente para a ventilação.
(4) Coloque o microondas o mais afastado
possível de rádio e TV, pois pode
causar interferência na recepção das
É necessário um espaço mínimo de 7,5 emissões.
cm entre o forno e a parede adjacente.
Um dos laterais deve ficar desimpedido. 2. Ligue o forno a uma tomada standard.
(1) Deixe um espaço mínimo de 30 cm Assegure-se de que a tensão e a
frequência são iguais ás indicadas na
por cima do forno.
(2) Não retire os pés da parte inferior do chapa de características do aparelho.
forno.
12 inch(30cm)
ADVERTÊNCIA: Não instale o forno sobre
3.0 inch(7.5cm) OPEN uma placa de cozinha ou sobre outro
3.0 inch(7.5cm)
electrodoméstico que produza calor. Se for
instalado próximo ou sobre uma fonte de
calor, o forno pode danificar-se,
anulando assim a sua garantia.
16
OPERAÇÃO
Painel de Comandos e Funções
Instruções de funcionamento
1. Rode o botão de potência para o nível desejado para seleccionar a potência do cozinhado.
2. Rode o botão do temporizador para o tempo desejado (conforme guia para cozinhar) para definir o tempo de cozinhar.
3. O microondas vai automaticamente começar a cozinhar após definir o nível de potência e o tempo.
4. Decorrido o tempo seleccionado de cozinhar, ouvir-se-á um sinal sonoro.
5. Se o aparelho não estiver em funcionamento, coloque o temporizador na posição "0".
Selector
Temporizador
Observação: Quando retirar os alimentos do forno, por favor desligue o aparelho rodando o botão do temporizador para
a posição "0".
17
Resolução de problemas
Normal
Interferências do forno A recepção de rádio e televisão pode sofrer interferências quando o
microondas com a recepção forno microondas está a funcionar. São interferências similares às
de televisão produzidas pelos pequenos electrodomésticos, tais como a batedeira,
aspirador e ventilador eléctrico.
É uma situação normal.
Luz com pouca intensidade Ao cozinhar a baixa potência, a luz do forno microondas pode
atenuar-se. É uma situação normal.
Condensação de vapor na porta Ao cozinhar, pode sair vapor dos alimentos. A maior parte sai pelas
e nas saídas de ar quente ou aberturas de ventilação. No entanto pode acumular-se nas zonas
nas aberturas de ventilação mais frias, como por exemplo na porta do forno.
É uma situação normal.
O aparelho inicia O microondas se funcionar em vazio durante pouco tempo, não sofrerá
sem alimentos no interior danos, no entanto deve evitar-se o funcionamento nestas condições.
Este símbolo no produto ou na embalagem indica que não pode ser tratado como lixo
doméstico. Em vez disso, deve ser entregue ao centro de recolha selectiva para a reciclagem
de equipamento eléctrico e electrónico. Ao garantir uma eliminação adequada deste produto,
irá ajudar a evitar eventuais consequências negativas para o meio ambiente e para a saúde
pública, que, de outra forma, poderiam ser provocadas por um tratamento incorrecto do
produto. Para obter informações mais pormenorizadas sobre a reciclagem deste produto,
contacte os serviços municipalizados locais, o centro de recolha selectiva da sua área de
residência ou o estabelecimento onde adquiriu o produto.
18
Microwave Oven
INSTRUCTION MANUAL
MODEL: MW 200 G BLANCO
Read these instructions carefully before using your
microwave oven, And keep it carefully.
If you follow the instructions, your oven will provide you with
many years of good service.
19
PRECAUTIONS T O AVOID P O S S I B L E
E X P O S U R E T O E X C E S S I V E M I C R O WAV E
ENERGY
(a) Do not attempt to operate this oven with the door open since this
(b) Do not place any object between the oven front face and the door or allow
(c) WARNING: If the door or door seals are damaged, the oven must not
ADDENDUM
If the apparatus is not maintained in a good state of cleanliness, its surface could
be degraded and affect the lifespan of the apparatus and lead to a dangerous
situation.
Sp ec i f i c at i o n s
Model: MW 200 G BLANCO
Power Source: 230V~ 50Hz
Power Consumption: 1050 W
Maximum Output: 700 W
Grill: 1000 W
Oven Capacity: 20 Litres
Turntable Diameter: 255 mm
External Dimensions (LxWxH): 440mmX256.6mmX258.2mm
Net weight: Approx. 11.2 Kg
20
IMPORTANT SAFETY INSTRUCTIONS
To reduce the risk of fire, electric shock, injury to persons
WARNING or exposure to excessive microwave oven energy when
using your appliance, follow basic precautions, including
the following:
1. Warning: Liquids and other foods must
15. Use this appliance only for its intended
not be heated in sealed containers since
uses as described in manual. Do not
they are liable to explode.
use corrosive chemicals or vapors
2. Warning: It is hazardous for anyone other
in this appliance. This oven is especially
than a competent person to carry out any
designed to heat. It is not designed for
service or repair operation that involves
industrial or laboratory use.
the removal of a cover which gives
16. If the supply cord is damaged, it must
protection against exposure to microwave
be replaced by the manufacturer, its
energy.
service agent or similarly qualified
3. Warning: Only allow children to use the
persons in order to avoid a hazard.
oven without supervision when adequate
17. Do not store or use this appliance
instructions have been given so that the
outdoors.
child is able to use the oven in a safe way
18. Do not use this oven near water, in a
and understand the hazards of improper
wet basement or near a swimming
use. pool.
4. Warning: When the appliance is operated 19. The temperature of accessible surfaces
in the combination mode, children should may be high when the appliance is
only use the oven under adult supervision operating. The surfaces are liable to
due to the temperatures generated. get hot during use.Keep cord away
(only for grill series) from heated surface, and do not cover
5. Only use utensils suitable for use in any vents on the oven.
microwave ovens. 20. Do not let cord hang over edge of table
6. The oven should be cleaned regularly and or counter.
any food deposits should be removed. 21. Failure to maintain the oven in a clean
7. Read and follow the specific:"PRECAU- condition could lead to deterioration
TIONS TO AVOID POSSIBLE EXPOSURE of the surface that could adversely
TO EXCESSIVE MICROWAVE ENERGY". affect the life of the appliance and
8. When heating food in plastic or paper possibly result in a hazardous situation.
containers, keep an eye on the oven due 22. The contents of feeding bottles and
to the possibility of ignition. baby food jars shall be stirred or shaken
9. If smoke is observed, switch off or unplug and the temperature checked before
the appliance and keep the door closed consumption, in order to avoid burns.
in order to stifle any flames. 23. Microwave heating of beverages can
10. Do not overcook food. result in delayed eruptive boiling,
11. Do not use the oven cavity for storage therefore care must be taken when
purposes. Do not store items, handling the container.
such as bread, cookies, etc. inside the 24.The appliance is not intended for use by
oven. persons (including children) with reduced
12. Remove wire twist-ties and metal handles physical , sensory or mental capabilities,
from paper or plastic containers/bags or lack of experience and knowledge,
before placing them in the oven. unless they have been given supervision
13. Install or locate this oven only in or instruction concerning use of the
accordance with the installation appliance by a person responsible for their
instructions provided. safety.
14. Eggs in the shell and whole hard-boiled 25.Children should be supervised to ensure
eggs should not be heated in microwave that they do not play with the appliance.
ovens since they may explode, even
after microwave heating has ended.
21
26.The microwave oven shall not be placed in a cabinet unless it has been tested in
a cabinet.
27.Appliances are not intended to be operated by means of an external timer or separate
remote-control system.
28.The door or the outer surface may get hot when the appliance is operating.
29.The rear surface of appliance shall be placed against a wall.
To Reduce the Risk of Injury to Persons
Grounding Installation
DANGER
Electric Shock Hazard This appliance must be grounded. In the event of
Touching some of the internal an electrical short circuit, grounding reduces the
components can cause serious risk of electric shock by providing an escape wire
personal injury or death. Do not for the electric current. This appliance is equipped
disassemble this appliance. with a cord having a grounding wire with a
grounding plug. The plug must be plugged into an
outlet that is properly installed and grounded.
WARNING
Electric Shock Hazard
Improper use of the grounding Consult a qualified electrician or serviceman if the
can result in electric shock. Do grounding instructions are not completely
not plug into an outlet until understood or if doubt exists as to whether the
appliance is properly installed appliance is properly grounded. If it is necessary
and grounded. to use an extension cord, use only a 3-wire
extension cord.
CLEANING
Be sure to unplug the
appliance from the power supply.
1. Clean the inside of the oven after using
with a slightly damp cloth. 1. A short power-supply cord is provided to
2. Clean the accessories in the usual way reduce the risks resulting from becoming
in soapy water. entangled in or tripping over a longer cord.
3. The door frame and seal and 2. If a long cord set or extension cord is used:
neighboring parts must be cleaned 1)The marked electrical rating of the cord set
carefully with a damp cloth when they or extension cord should be at least as great
are dirty. as the electrical rating of the appliance.
Two-round-pin plug 2)The extension cord must be a grounding-
type 3-wire cord.
3)The long cord should be arranged so that it
will not drape over the counter top or tabletop
where it can be pulled on by children or tripped
over unintentionally.
22
UTENSILS See the instructions on "Materials you can use in
microwave oven or to be avoided in microwave oven."
There may be certain non-metallic utensils that are not
CAUTION safe to use for microwaving. If in doubt, you can test the
Personal Injury Hazard utensil in question following the procedure below.
It is hazardous for anyone Utensil Test:
other than a compentent person 1. Fill a microwave-safe container with 1 cup of cold
to carry out any service or repair water (250ml) along with the utensil in question.
operation that involves the removal 2. Cook on maximum power for 1 minute.
of a cover which gives protection 3. Carefully feel the utensil. If the empty utensil is
against exposure to microwave warm, do not use it for microwave cooking.
energy. 4. Do not exceed 1 minute cooking time.
23
Materials to be avoided in microwave oven
Utensils Remarks
Aluminum tray May cause arcing. Transfer food into microwave-safe dish.
Food carton with May cause arcing. Transfer food into microwave-safe dish.
metal handle
Metal or metal- Metal shields the food from microwave energy. Metal trim may
trimmed utensils cause arcing.
Metal twist ties May cause arcing and could cause a fire in the oven.
Paper bags May cause a fire in the oven.
Plastic foam Plastic foam may melt or contaminate the liquid inside when exposed
to high temperature.
Wood Wood will dry out when used in the microwave oven and may split
or crack.
E D C B
24
Turntable Installation
Hub (underside) a. Never place the glass tray upside down. The
glass tray should never be restricted.
b. Both glass tray and turntable ring assembly must
Glass tray
always be used during cooking.
c. All food and containers of food are always placed
on the glass tray for cooking.
Turntable shaft
d. If glass tray or turntable ring assembly cracks or
breaks, contact your nearest authorized service
Turntable ring assembly center.
Countertop Installation
Remove all packing material and accessories. Cabinet: Remove any protective film found
Examine the oven for any damage such as on the microwave oven cabinet surface.
dents or broken door. Do not install if oven is Do not remove the light brown Mica cover
damaged. that is attached to the oven
cavity to protect the magnetron.
Installation
1. Select a level surface that (3) Blocking the intake and/or outlet openings
provide enough open space for can damage the oven.
the intake and/or outlet vents.
(4) Place the oven as far away
from radios and TV as possible.
12 inch(30cm)
3.0 inch(7.5cm) OPEN Operation of microwave oven may
3.0 inch(7.5cm) cause interference to your radio or TV
reception.
2. Plug your oven into a standard household
outlet. Be sure the voltage and the
frequency is the same as the voltage
and the frequency on the rating label.
25
OPERATION
Control Panel and Features
Combi 1 80% grill + 20% micro Western steak, pork chop, meat, poultry, etc.
Combi 2 70% grill + 30% micro Chinese steak, meat, pork chop, etc.
Combi 3 60% grill + 40% micro Chickens, ducks, meat, make food crispy and tasty
26
7URXEOHVKRRWLQJ
,WLVIRUELGGHQWRUXQWKHXQLWZLWKRXWDQ\IRRGLQVLGH
,WLVYHU\GDQJHURXV
$FFRUGLQJWR:DVWHRI(OHFWULFDODQG(OHFWURQLF(TXLSPHQW
:((( GLUHFWLYH:(((VKRXOGEHVHSDUDWHO\FROOHFWHGDQG
WUHDWHG,IDWDQ\WLPHLQIXWXUH\RXQHHGWRGLVSRVHRIWKLV
SURGXFWSOHDVHGR127GLVSRVHRIWKLVSURGXFWZLWKKRXVHKROG
ZDVWH3OHDVHVHQGWKLVSURGXFWWR:(((FROOHFWLQJSRLQWV
ZKHUHDYDLODEOH
27
COUNTRY COMPANY CC TELEPHONE E-MAIL / FAX