Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Extracion de Zin
Extracion de Zin
Carro
Estudios en Conservación
Volumen 64, 2019 - Número 3
479 5 0
Vistas Citas de CrossRef hasta la fecha Altmétrico
Documentos originales de investigación o tratamiento
ABSTRACT
Pintura sobre metal Pintura sobre planchas Placas de zinc Jabones de zinc sales de zinc
Agradecimientos
Los autores desean agradecer al Dr. Jacek Stachera, al Prof. Bogumiła Rouba y al Prof.
Robert Rogal, todos del Departamento de Conservación de Pinturas y Esculturas
Policromadas de la Universidad Nicolás Copérnico de Toruń, Polonia, por sus
esclarecedoras discusiones y aportaciones metodológicas en varias etapas de este
proyecto. Se deben hacer reconocimientos por separado al personal del laboratorio
SEM-EDX en el Departamento de Química de la NCU, dirigido por el Dr. Grzegorz
Trykowski, quien ayudó a realizar el análisis técnico.
Declaración de divulgación
ORCID
Notas
1. There was a hypothesis that the object was bent in order to construct the roof over
it, but the relatively good state of preservation of the titulus plate from the upper part
of the Jesus figure leads to rejection of such conclusion, as the top without the roof
should be one of the most damaged parts.
2. The total dimensions are: 137 cm height and 62 cm width for the Virgin Mary and
142 cm height and 52 cm width for the figure of St. John. The original dimensions of
the Jesus on the cross figure were 234 cm in height and 13.5 cm in width, but now,
after the bending of the top and bottom parts of the cross, the vertical outline is a bit
smaller (around 225 cm).
4. Zinc soaps (especially zinc stearates) are often used as industrial lubricants, what
shows how low adhesion to the support surface they might have.
5. Data presented are for the city of Brodnica, about 10 km south-east from Bobrowo.
It is also important that these are monthly averages aggregated over the years, daily
the temperatures can deviate from that significantly in both directions.
6. Even though B-48N is not usually a primary choice for metal coating (with B-44
taking first place), it is being used as such at NCU occasionally. It is described as a
possible metal coating in the CAMEO database run by the Museum of Fine Arts in
Boston (MFA 2016).
7. Epoxy resin usually should not interact chemically with zinc. The metal is even used
as an additive in epoxy nanocomposites (Han et al. 2010). The adhesion of epoxy to
zinc depends on several factors (e.g. metal surface roughness and plasticity of the
resin), but it can achieve a satisfactory level (Hine, El Muddarris, and Packham 1984).
9. The authors would like to thank one of the reviewers for pointing this out.
Log in
Issue Purchase
30 days online access to complete issue
Article PDFs can be downloaded
Article PDFs can be printed
USD 209.00 Add to cart
Investigación relacionada
La gente también lee Artículos recomendados Citado por
5
Authors Overview
Societies F1000Research
Keep up to date
Sign me up
conditions Accessibility