Documentos de Académico
Documentos de Profesional
Documentos de Cultura
con rotor
ANT-HD-100
Gracias por la compra de este producto Steren.
2
IMPORTANTE
- Antes de utilizar su nueva Antena aérea HD con rotor, por favor lea las
siguientes recomendaciones.
- Siempre utilice un paño suave, limpio y seco para limpiar el equipo.
- La garantía no es válida si trata de abrir el equipo.
- Asegúrese de que las conexiones estén perfectamente colocadas a fin de
evitar una mala recepción.
CARACTERÍSTICAS
- Rotación de 360°.
- Control remoto.
- Booster de 15 dB.
- Fácil instalación.
- Con divisor para 2 Televisores.
3
CONTROLES
Booster
1
4
Antena
8
7.- Malla 7
Control remoto
13
13.- Botón de movimiento giratorio de la
antena hacia la izquierda.
14.- Botón de movimiento giratorio de la
antena hacia la derecha. 14
5
INSTRUCCIONES
1.- Inserte la terminal con 3 elementos como se muestra en la figura y
atornille hasta quedar firmemente sujeta.
6
3.- Saque la base para tubo y colóquela en la parte posterior de la antena,
como muestra la figura. Asegúrela utilizando los tornillos incluidos en el
empaque.
4.- Una vez que instaló la base, colóquela en el tubo para antena (no
Incluido) y asegúrela utilizando los seguros de la base.
7
5.- Extienda el cable coaxial que va a utilizar para conectar la antena con
el amplificador de señal y conecte una terminal al conector coaxial de la
Antena y el extremo contrario conéctelo al amplificador de señal en el
conector marcado como ANT.
8
6.- Conecte un cable coaxial en la entrada coaxial del Televisor y el extremo
contrario conéctelo a la entrada TV1 del amplificador de señal.
9
7.- Inserte el cordón de energía a un contacto eléctrico y encienda el
amplificador de señal.
8.- Encienda su televisor y compruebe la recepción de los canales.
9.- Coloque los dipolos en la posición más adecuada a fin de lograr la mejor
recepción (los dipolos cuentan con dos posiciones).
10.- Use el control remoto para mover la antena hacia la derecha o la
izquierda para captar mejor las señales de TV.
ESPECIFICACIONES
- Alimentación: 120 V~ 60 Hz 40 mA
- Ganancia: 15 dB
Control remoto
- Alimentación: 3V - - - (2 x AAA)
CONDICIONES
1.- Para hacer efectiva la garantía, presente esta póliza y el producto, en donde fue adquirido o en
Electrónica Steren S.A. de C.V.
2.- Electrónica Steren S.A de C.V. se compromete a reparar el producto en caso de estar defectuoso sin
ningún cargo al consumidor. Los gastos de transportación serán cubiertos por el proveedor.
3.- El tiempo de reparación en ningún caso será mayor a 30 días, contados a partir de la recepción del
producto en cualquiera de los sitios donde pueda hacerse efectiva la garantía.
4.- El lugar donde puede adquirir partes, componentes, consumibles y accesorios, así como hacer válida esta
garantía es en cualquiera de las direcciones mencionadas posteriormente.
ANT-HD-100
This manual includes all the feature operations and troubleshooting necessary
to install and operate your new Steren´s High definition rotor antenna.
www.steren.com
The instructions of this manual are for reference about the product. There may
be differences due to updates.
Please check our web site (www.steren.com) to obtain the latest version of the
instruction manual.
2
IMPORTANT
- Before using your new High definition rotor antenna, please read the
following recommendations.
- Always use a soft and dry cloth in order to clean.
- Do not attempt to open this device as this could cause malfunctions or the
voiding of the warranty.
- Make sure to connect the cables correctly, in order to avoid a bad signal
reception.
HIGHLIGHTS
- 360 degress rotation.
- Remote control.
- 15 dB booster.
- Easy installation.
- Splitter for two TV sets.
3
CONTROLS
Booster
1
5.- ANT
Allows you to connect a coaxial cable from the antenna to the signal amplifier.
6.- ROTATING.
This button allows you to turn left or right antenna.
4
Antenna
8
7.- Mesh 7
Remote control
13
13.- This button allows you to turn left
antenna.
14.- This button allows you to turn right
antenna. 14
5
INSTRUCTIONS
1.- Insert the terminal with 3 elements as shown in Figure and screw to be
firmly attached.
6
3.- Release the base and place it in the rear side of the antenna, see the
figure. Fasten it using the included screws.
4.- Then, place the antenna into the outdoor tube (not included), and fasten
it using the base’ s secures.
7
5.- Extend a coaxial cable (not included), one of the ends plug it into the
signal amplifi er (ANT) and the other end plug it into the antenna’s coaxial
connector.
8
6.- Connect a coaxial cable at the input coaxial of the TV and connect it to the
end opposite the input of the TV1 signal amplifier.
9
7.- Plug the power cord into an AC outlet, then power on the signal amplifier.
8.- Turn the TV on and check the TV signal reception.
9.- Put the dipoles in the best position to get a good signal quality reception
(dipoles has 2 positions).
10 .- Use the remote control to move the antenna to the right or the left to get
the best TV signal.
ESPECIFICATIONS
- Input: 120 V~ 60 Hz 40 mA
- Gain: 15 dB
Remote control
- Input: 3V - - - (2 x AAA)
10
Product: High definition rotor antenna
Part number: ANT-HD-100
Brand: Steren
WARRANTY
This Steren product is warranted under normal usage against defects in workmanship
and materials to the original purchaser for one year from the date of purchase.
CONDITIONS
1. This warranty card with all the required information, invoice, product box or
package, and product, must be presented when warranty service is required.
2. If the product is in the warranty time, the company will repair it free of charge.
3. The repairing time will not exceed 30 natural days, from the day the claim was
received.
4. Steren sell parts, components, consumables and accessories to customer, as well
as warranty service, at any of the addresses mentioned later.
If the product has been damaged by an accident, acts of God, mishandling, leaky
batteries, failure to follow enclosed instructions, improper repair by unauthorized
personnel, improper safe keeping, among others.
a) The consumer can also claim the warranty service in the purchase establishment.
b) If you lose the warranty card, we can reissue it, if you show the invoice or purchase
ticket.
RETAILER INFORMATION
Name of the retailer In case your product fails
Address or have questions, please
Product contact your nearest dealer.
Brand If you are in Mexico, please
Part number call to our Call Center.
Serial number 01 800 500 9000
Date of delivery
11