Documentos de Académico
Documentos de Profesional
Documentos de Cultura
3 Refer to the circuit shown in Figure Exp. 73 if the timer has been set for a 10 second delay,
explain the operation of the circuit when the START button is pressed
4 in the circuit shown in Figure Exp 7-3 is it necessary to hold the START button closed for a period
of at least 10 seconds to ensure that the circuit Will remain energized? Explain your answer
5. Assin that the timer in Figure Exp 7.3 is set for a delay of 10 seconds Now assume that the
START button is pressed, and after an 8-second delay the STOP button is pressed Will the motor
start 2 seconds after the STOP button was pressed
6 What is generally done to compensate when a set of instantaneous timer contacts are needed
and the timer does not contain them?
7 Refer to the circuit shown in Figure En 7-6 Assume that it is necessary to stop the operation of
both motors after the second motor has been operating for a period of 10 seconds. Using the
space provided in Figure Exp 7-7 redrawt the circuit to turn off both motors after the second
motor hay been in operation for 10 seconds (Note. it will be necessary to use a second timer).
8 After your instructor has approved the design change connect the new circuit in the laboratory
and fest in for proper operation
Preguntas de revisión
5. Suponga que el temporizador en la Figura Exp 7.3 está configurado para un retraso de 10
segundos Ahora suponga que se presiona el botón START, y después de un retraso de 8 segundos
se presiona el botón STOP ¿Arrancará el motor 2 segundos después de que se presione el botón
STOP? presionado
7 Consulte el circuito que se muestra en la figura En 7-6 Suponga que es necesario detener el
funcionamiento de ambos motores después de que el segundo motor haya estado funcionando
durante un período de 10 segundos. Usando el espacio proporcionado en la Figura Exp 7-7, vuelva
a dibujar el circuito para apagar ambos motores después de que el segundo motor haya estado en
funcionamiento durante 10 segundos (Nota: será necesario usar un segundo temporizador).
8 Después de que su instructor haya aprobado el cambio de diseño, conecte el nuevo circuito en el
laboratorio y asegúrese de que funcione correctamente