Documentos de Académico
Documentos de Profesional
Documentos de Cultura
7507 Usb-R
7507 Usb-R
3007-I
SURGE PROTECTED OUTLETS. NOT BATTERY SUPPORTED
En estos
contactos puede En estos
BATTERY PROTECTED PLUS SURGE PROTECTED OUTLETS
En estos
conectar: contactos puede contactos puede
En estos contactos
WARNING: DO NOT CONNECT A LASER PRINTER
in out
conectar:
COAXIAL LINE
CPU, monitor,
120V - 60Hz - 10A
Línea Telefónica
Teléfono PC Puerto USB
a RJ11/RJ45 IMPORTANTE: SI CUENTA CON SERVICIO DE INTERNET es
muy importante que proteja su fax/módem conectando un cable
Línea telefónico (RJ11/RJ45) del no break a su computadora (Ver
Comercial dibujo A), ya que por la línea telefónica pasa corriente que
No Break puede dañar componentes internos de su equipo de cómputo.
parte trasera
XI. GARANTÍA
Koblenz Eléctrica, S.A. de C.V. garantiza este producto por un término de 5 años en Producto:
todas sus partes (2 años en la batería) y mano de obra contra cualquier defecto de Marca:
fabricación a partir de la fecha de entrega. Tratándose de productos que requieran de
enseñanza o adiestramiento en su manejo o instalación de aditamentos, accesorios, Modelo:
implementos o dispositivos, a partir de la fecha en que se hubiera quedado operando Número de Serie:
normalmente después de su instalación en el domicilio que señale el consumidor bajo Nombre del Distribuidor:
las siguientes CONDICIONES: Calle y Número:
1. Para hacer efectiva esta garantía, no podrán exigirse mayores requisitos que la Colonia o Poblado:
presentación de esta póliza debidamente sellada por el establecimiento que lo vendió
junto con el producto en el lugar donde fue adquirido o en cualquiera de los Centros de Ciudad / C. P. :
Servicio Autorizados. Fecha de Entrega:
2. La empresa se compromete a reparar o cambiar el producto, así como las piezas y Sello y Firma:
componentes defectuosos del mismo, sin ningún cargo para el consumidor; los costos Descripción: CENTROS DE SERVICIO, REFACCIONES Y CONSUMIBLES
del transporte que se deriven de su cumplimiento serán cubiertos por el fabricante o por SISTEMA DE RESPALDO DE ENERGÍA
el importador. Para mayores informes sobre un centro de servicio autorizado cercano a su
domicilio visite nuestro sitio de internet: www.koblenz-energia.com.mx o llame
3. El tiempo de reparación, en ningún caso será mayor de 30 días contados a partir de Modelos: 7507-USB/R, 7507-IR, sin costo al: 01 800 849 4711 o contáctenos: servicio@koblenz-electric.com
la recepción del producto en cualquiera de los sitios en donde pueda hacerse efectiva. 5007-USB/R, 5007-IR, GUADALAJARA, JAL. MONTERREY, N.L. EDO. DE MÉXICO
4. En cualquiera de los Centros de Servicio Autorizados podrá adquirir las refacciones y partes. 5007-I, 3007-IR, 3007-I
CINCINNATI No. 125 PLATÓN SÁNCHEZ No. 1860 AV. CIENCIA No. 28
SECTOR REFORMA NORTE, COL. 1 DE MAYO FRACCIONAMIENTO INDUSTRIAL
Consultar hoja anexa de talleres de servicio autorizados para Reguladores y No Breaks. Hecho en México por:
01 800 711 8046
01 800 711 8047
01 800 711 8114
01 800 712 7714
CUAMATLA, CUAUTITLÁN IZCALLI
01 800 849 4711
(55) 5864 0300
E S TA G A R A N T Í A N O E S V Á L I D A E N L O S S I G U I E N T E S C A S O S : Koblenz Eléctrica, S.A. de C.V.
a. Cuando el producto ha sido utilizado en condiciones distintas a las normales. Av. Ciencia No. 28, Cuautitlán Izcalli, SERVICIO Y REFACCIONES EN TODA LA REPÚBLICA
b. Cuando el producto no ha sido operado de acuerdo con el manual de uso proporcionado. Edo. de México, C.P. 54730
c. Cuando el producto ha sido alterado o reparado por personas no autorizadas por la empresa. Tel: 5864 0300
El consumidor podrá solicitar que se haga efectiva la garantía ante la propia casa comercial 19-0444-0 G
Operating Instruction Manual
UPS Battery Backup.
Models: 7507-USB/R, 7507-IR, 5007-USB/R,
5007-IR, 5007-I, 3007-IR and 3007-I
4. Hook up your telephone line to the UPS jack marked "TEL LINE". Using a
regular telephone cable (not included) hook up the UPS "MODEM" jack to
your computer's LINE IN jack. Finally, connect your telephone or fax to the
computer's TELEPHONE / LINE OUT jack (figure A).
5. Turn on your UPS, when the ON LINE light is on the UPS is ready.
6. If you want to install the Koblenz Protek Software connect a USB cable (not
included) from the USB port in the UPS to the computer. Insert the CD in
I. INTRODUCTION your computer and follow the instructions. Only models USB/R.
This Uninterruptible Power Supply (UPS) is a high quality product designed * In case of a blackout:
to protect your computer system against information loss and damages All models will emit a beep and the "ON BATTERY" light will flash. As the battery
to computer peripherals like monitors and modems in case of a blackout. depletes the pace of the beep will become faster.
All Koblenz UPS models feature RJ11 / RJ45 telephone jacks to protect If you have installed the Koblenz Protek Software and the USB cable, you will
your computer modem against voltage spikes and surges coming also receive a warning message on your computer screen and the software
through your telephone line (cable not included). Selected models have will automatically save your files and shut down your system before the
coaxial cable protector (see table 1). battery runs out.
USB/R models (see table 1) also include an integrated USB port that with III. STATUS INDICATORS
the Koblenz Protek Software gives you on screen warnings in case of
power failure (cable not included). If the blackout continues and your Placed on the front panel to indicate UPS status.
computer is unattended, the Koblenz Protek Software will save and 1. On Line (green): This indicator is lit when there is utility power.
close your open files and safely shut down your computer. 2. On Battery (red): This indicator is lit when the UPS battery is powering the
You can download the Koblenz Protek Software free of charge at battery backup outlets.
www.koblenz-protek.com 3. Battery Level: If the light is green the battery is totally charged; if it is yellow,
the battery has less than the 50% of the charge and if it is red, the UPS is
II. INSTALLATION AND USE almost run out of battery.
4. Overload (red): This indicator is lit when the equipment connected to battery
1. Place the UPS to avoid: backup outlets (silver) consume more than the UPS capacity. Remove one
a. Direct sunlight or more pieces of equipment to the surge protection outlets until the light
b. Excessive heat and the beep turn off.
c. Excessive humidity or contact with liquids 5. Replace Suppressor (yellow): This indicator is lit when the surge suppressor
2. Plug the UPS directly into a properly grounded 3-prong outlet. The UPS is burnt out. It is necessary to take the UPS to a service center or to connect
begins charging when connected to utility power and turned on. Charge a surge suppressor to it. The UPS continues working normally but it does
the UPS 24 hours before using for the first time. not protect against spikes any more.
3. Turn off your UPS. Plug your equipment into the battery backup outlets. 6. Replace Battery (red): This indicator is lit when the battery is near to the end
Do not plug surge protectors or power strips into battery backup of its useful life. The battery should be replaced. Failure to replace the battery
outlets. may result in insufficient runtime during a power outage.
a. To make sure that your computer or video equipment is protected
against a power failure it is important to know its volt / ampere rating IV. BATTERY
and compare it with your UPS capacity (see table 3). You may plug
one or more pieces of equipment into the UPS making sure that the 1. The battery automatically recharges whenever the UPS is plugged into an
total power requirement does not exceed the UPS capacity. electrical outlet and turned it on.
b. If the UPS is overloaded, a red light will flash and the UPS will beep, 2. Average battery life is 2 to 3 years.
this will turn off when the extra load is disconnected. 3. To buy a new battery, call toll free: 1-800-548-5741.
c. Battery backup plus surge protection outlets (silver). 4. Koblenz batteries are sealed and maintenance free.
These outlets should be used for sensitive equipment such as
computers, monitors and external drives. Battery power is automatically V. SAFETY
provided in case of power outage. Power (utility or battery) is not 1. Keep your Koblenz UPS away from moisture and liquids.
supplied to these outlets when the UPS is switched off. 2. Do not expose the UPS to direct sunlight.
Do not plug in laser printers to battery backup outlets, if so the UPS 3. Do not use for medical or life support equipment.
warranty is voided. 4. Plugging any domestic appliance (i.e. blender, iron, refrigerator, etc.) into
d. Surge Protection Outlets. the UPS will void the warranty.
These outlets should be used for all others peripherals such a printer, 5. Black outlets should not be used to plug in laser printers.
scanner, fax machine, etc. These outlets do not provide power
during a power outage.
BACKSIDE OF UPS
ON
LINE
ON
BATTERY
BATTERY
LEVEL
OVERLOAD REPLACE REPLACE
SUPRESSOR BATTERY
MODELS MODELS TOTAL OUTPUT CURRENT 10A
MODELS
7507-USB/R 5007-USB/R, 3007-IR,
in out
TEL. LINE/MODEM USB PORT
3007-I
SURGE PROTECTED OUTLETS. NOT BATTERY SUPPORTED
Use with:
BATTERY PROTECTED PLUS SURGE PROTECTED OUTLETS
CPU and
in out
modem, fax,
CPU, monitor,
300VA Max.
Monitor.
COMPUTER LOAD ONLY 120VAC 60 HZ
scanner, inkjet
200 WATTS Max.
telephone,
modem, fax, printer, fax,
INPUT INPUT
120V - 60Hz - 10A
answer machine
120V - 60Hz - 10A
Use with:
LASER PRINTER, scanner, inkjet printer, fax, modem,
telephone or answer machine.
VI. TROUBLESHOOTING
Use the table below to solve minor UPS installation or operation problems.
Outlets
Model VA / W Battery Surge Fax/Modem USB Coaxial Regulator Volts Volts Frec. Weight Batteries
Backup Protection Protection Port Cable included in out Hz lbs
7507-USB/R 750/500 4 3 Yes Yes Yes Yes 120 V~ 120 V~ ±10% 60 24,2 2
7507-IR 750/500 4 3 Yes No No Yes 120 V~ 120 V~ ±10% 60 24,2 2
5007-USB/R 500/325 4 3 Yes Yes Yes Yes 120 V~ 120 V~ ±3% 60 14,6 1
5007-IR 500/325 4 3 Yes No Yes Yes 120 V~ 120 V~ ±3% 60 14,6 1
5007-I 500/325 4 3 Yes No No No 120 V~ 120 V~ ±3% 60 14,6 1
3007-IR 300/200 2 2 Yes No No Yes 120 V~ 120 V~ ±3% 60 11,8 1
3007-I 300/200 2 2 Yes No No No 120 V~ 120 V~ ±3% 60 11,8 1
VIII. TYPICAL RUN TIME (MINUTES) - TABLE 2 IX. SAMPLE EQUIPMENT REQUIREMENTS - TABLE 3
Model With PC and 15" monitor Battery reserve Pentium III with 17" monitor 150 VA
"continuous" beep alarm Pentium IV with 17" monitor 150 VA
7507-USB/R Up to 60 minutes 2 - 3 minutes Mac G3 with 19" monitor 200 VA
7507-IR Up to 60 minutes 2 - 3 minutes Mac G4 with 19" monitor 200 VA
5007-USB/R Up to 24 minutes 2 - 3 minutes 34 " Television 190 VA
5007-IR Up to 24 minutes 2 - 3 minutes T.V. and DVD 250 VA
5007-I Up to 24 minutes 2 - 3 minutes Audio System 180 VA
3007-IR Up to 17 minutes 2 - 3 minutes
3007-I Up to 17 minutes 2 - 3 minutes
X. DRAWING A
XI. WARRANTY
This warranty gives you specific legal rights, and you may have other rights which may return it freight prepaid.
vary from state to state. This warranty is the sole warranty of Koblenz, and there are no other warranties, expressed,
This product is warranted against defects in material and workmanship for a period of five or otherwise except as required by law. Among the excluded warranties are the implied
(5) years from the date of purchase with the exception of the battery which is warranted warranty of merchantability and implied warranty of fitness for a particular purpose. Implied
for two (2) years. After this two year period Koblenz will replace the battery free of charge warranties, if any, are limited in duration to the term of this warranty. Some states do not
for up to three (3) additional years for $29.99 to cover shipping and handling costs. allow limitations on how long an implied warranty lasts, so the above limitation may not
This warranty shall not apply to any products or parts thereof which have been damaged apply to you.
by tampering, misuse or abuse or which have been altered or repaired by an unauthorized Koblenz will in no event be liable for any direct, indirect, special, incidental or consequential
person or service center. damages or losses whatsoever and Koblenz's liability under no circumstances will exceed
For repair, the inoperative product must be delivered with shipping and delivery charges the contract price for the goods or parts for which liability is claimed. Some states do not
prepaid, together with satisfactory evidence of the purchase date to our authorized allow the exclusion or limitation of incidental or consequential damages, so the above
representative for handling claims indicated below. Koblenz will either repair or replace, limitation or exclusion may not apply to you.
at its election, all defective product and / or the battery during the warranty period and This limited warranty applies only to the original purchaser. Proof of purchase will be
required.