Documentos de Académico
Documentos de Profesional
Documentos de Cultura
ECUACIÓN DE STOKES
RESUMEN:
El presente informe de laboratorio tiene como objetivo determinar la viscosidad del aceite
aplicando las formulas presentadas en clase y siguiendo los procesos adecuados con el fin
de que podamos comprobar si el resultado obtenido en laboratorio es igual o muy parecido
al que se conoce teoricamente.
En el ensayo se determinó la densidad promedio del agua, la densidad prpmedio del aceite
y finalmente la viscocidad del aceite, obteniendo como resultados muy cercanos a los
valores teóricos.
ABSTRACT:
The objective of this laboratory report is to determine the viscosity of the oil by applying
the formulas presented in class and following the appropriate processes so that we can
check whether the result obtained in the laboratory is the same or very similar to the one
known theoretically.
To perform this test it is necessary to use some laboratory materials and equipment, as
well as: oil, water, a dropper, a stopwatch, balance, ruler and test tubes. To obtain better
results it is advisable to do the test three times and then take your average.
In the test the average density of the water, the prpmedium density of the oil and finally
the viscosity of the oil were determined, obtaining as results ...
1
I. INTRODUCCIÓN
Mtara = 102.42 gr
Mtara + muestra = 198.54 gr
Volumen= 100 ml
𝑀𝑡𝑎𝑟𝑎 + 𝑚𝑢𝑒𝑠𝑡𝑟𝑎 − 𝑀𝑡𝑎𝑟𝑎
Aceite 𝜌=
𝑉𝑜𝑙𝑢𝑚𝑒𝑛
Agua 198.54 − 102.42
𝜌=
100
Gotero 𝜌 = 0.9612 × 1000
Regla 𝑘𝑔
𝜌 = 961.2 ⁄𝑚3
III. PROCEDIMIENTOS:
Segundo ensayo
Primero pesamos la probeta de M tara= 102.42 gr
500g.
Vertimos el agua hasta la marca M tara + muestra= 198.27 gr
de 100 ml para luego pesarlos, Volumen= 100 ml
este procedimiento se realiza
también para el aceite. 𝑀𝑡𝑎𝑟𝑎 + 𝑚𝑢𝑒𝑠𝑡𝑟𝑎 − 𝑀𝑡𝑎𝑟𝑎
𝜌=
Seguidamente sacamos las 𝑉𝑜𝑙𝑢𝑚𝑒𝑛
densidades tanto del aceite como 198.27 − 102.42
del agua. 𝜌=
100
Llenamos con aceite la probeta.
Llenamos el gotero con agua. 𝜌 = 0.9585 × 1000
Marcamos la probeta llena de 𝑘𝑔⁄
aceite con espacios cada 5 cm. 𝜌 = 958.5 𝑚3
Echamos cinco gotas de agua en
la probeta con aceite y esperamos Tercer ensayo
que esta se desprenda sola, este
procedimiento repetimos tres M tara= 102.42 gr
veces. M tara + muestra = 198.93 gr
Calculamos el tiempo por el que Volumen= 100 ml
demora en caer la gota al pasar 𝑀𝑡𝑎𝑟𝑎 + 𝑚𝑢𝑒𝑠𝑡𝑟𝑎 − 𝑀𝑡𝑎𝑟𝑎
𝜌=
por cada marca hecha en la 𝑉𝑜𝑙𝑢𝑚𝑒𝑛
198.93 − 102.42
probeta, y tomamos datos. 𝜌=
100
Por último, se procede a realizar
𝜌 = 0.9651 × 1000
los cálculos con los datos 𝑘𝑔
obtenidos. 𝜌 = 965.1 ⁄𝑚3
3
(𝜌𝑝𝑟𝑖𝑚𝑒𝑟 𝑒𝑛𝑠𝑎𝑦𝑜 + 𝜌𝑠𝑒𝑔𝑢𝑛𝑑𝑜 𝑒𝑛𝑠𝑎𝑦𝑜 +𝜌𝑡𝑒𝑟𝑐𝑐𝑒𝑟 𝑒𝑛𝑠𝑎𝑦𝑜 ) 𝜌 = 0.875 × 1000
⇒
3 𝑘𝑔
= 𝜌𝐻2𝑂 𝜌 = 875 ⁄𝑚3
𝑘𝑔⁄
𝜌𝐻2𝑂 = 961.6 𝑚3
(𝜌𝑝𝑟𝑖𝑚𝑒𝑟 𝑒𝑛𝑠𝑎𝑦𝑜 + 𝜌𝑠𝑒𝑔𝑢𝑛𝑑𝑜 𝑒𝑛𝑠𝑎𝑦𝑜 +𝜌𝑡𝑒𝑟𝑐𝑐𝑒𝑟 𝑒𝑛𝑠𝑎𝑦𝑜 )
2. Determinación de la densidad ⇒
3
del aceite = 𝜌𝐴𝐶𝐸𝐼𝑇𝐸
Primero ensayo
M tara = 163.68 gr 𝑘𝑔⁄
𝜌𝐴𝐶𝐸𝐼𝑇𝐸 = 865.33 𝑚3
M tara + muestra = 249.68 gr
Volumen= 100 ml
3. Viscosidad
𝑀𝑡𝑎𝑟𝑎 + 𝑚𝑢𝑒𝑠𝑡𝑟𝑎 − 𝑀𝑡𝑎𝑟𝑎
𝜌=
𝑉𝑜𝑙𝑢𝑚𝑒𝑛 𝑉𝑜𝑙𝑢𝑚𝑒𝑛 = 0.030 𝑐𝑚3
249.68 − 163.68
𝜌= ∑𝑉𝑖
100 𝑉𝑒𝑥𝑝 =
𝜌 = 0.86 × 1000 𝑛
𝑘𝑔
𝜌 = 860 ⁄𝑚3
3 3𝑉
𝑟= √
4𝜋
Segundo ensayo
M tara= 164.5 gr Primer ensayo
x t Δx Δt vi
M tara + muestra= 250.57 gr 0 0 0 0 0
Volumen= 100 ml 5 1.52 5 1.52 3.29
10 3.02 5 1.50 3.33
𝑀𝑡𝑎𝑟𝑎 + 𝑚𝑢𝑒𝑠𝑡𝑟𝑎 − 𝑀𝑡𝑎𝑟𝑎 15 4.17 5 1.15 4.35
𝜌=
𝑉𝑜𝑙𝑢𝑚𝑒𝑛 20 6.32 5 2.15 2.33
250.57 − 164.5 25 7.84 5 1.62 3.09
𝜌= 30 8.98 5 1.04 4.81
100
𝜌 = 0.861 × 1000
𝑘𝑔⁄ 3 3𝑉
𝜌 = 861 𝑚3 𝑟= √
4𝜋
Tercer ensayo
3 3(0.030)
𝑟= √
M tara= 165.27 gr 4𝜋
M tara + muestra = 252.80 gr
Volumen= 100 ml 𝑟 = 0.192 × 10−2
𝑀𝑡𝑎𝑟𝑎 + 𝑚𝑢𝑒𝑠𝑡𝑟𝑎 − 𝑀𝑡𝑎𝑟𝑎
𝜌= 𝑟 = 1.9275 × 10−3 𝑚3
𝑉𝑜𝑙𝑢𝑚𝑒𝑛
252.80 − 165.27
𝜌=
100
4
21.2 17.88
𝑉𝑒𝑥𝑝 = = 3.53 × 10−2 𝑉𝑒𝑥𝑝 = = 2.98 × 10−2
6 6
= 0.0353 𝑚⁄𝑠 = 0.0298 𝑚⁄𝑠
𝜌𝐻2𝑂 − 𝜌𝐴𝑐𝑒𝑖𝑡𝑒 𝜌𝐻2𝑂 − 𝜌𝐴𝑐𝑒𝑖𝑡𝑒
µ = 2𝑔𝑟 2 µ = 2𝑔𝑟 2
9 𝑉𝑒𝑥𝑝 9 𝑉𝑒𝑥𝑝
5
6