Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Micrometro Partida 521
Micrometro Partida 521
Certificado de Calibración
Calibration Certificate
Laboratorio de Metrología Magnitud: LONGITUD
Metrology Laboratory, Measure equipment calibration in several Areas
Descripción: MICROMETRO
Description
Tipo de Indicación: DIGITAL
Marca: STARRETT Número de Serie: 313
Indication type
Manufacturer Serial Number
Resolución:-/+.002mm por 25mm
Modelo: S824MAZ Identificación: P-519
Resolución
Model / Type Identification
Alcance Nominal: 50-150MM
Nominal Ranger
CALIBRO: APROBO:
Calibrated by Approved by
Fecha de Recepción: (Reception date) 2023-02-02
Fecha de Calibración: (Calibration date) 2023-02-03
Fecha de Emisión: (Date of Issue) 2023-02-04
Ing. Alberto Mendoza Ing. Emmanuel Molinero
METROLOGO METROLOGO FORMATO ASIC-365(6)
Este certificado tiene validez únicamente en su forma íntegra, no se permite la reproducción parcial de este documento, sin la autorización por escrito de Asesoría y Servicios Integrales en Calibración S.C.
(This certificate is not valid without the corresponding signatures and stamp and it may not be reproduced other than in full, except with the prior written approval of the issuing Laboratory).
Asesoría y Servicio Integral de Calibración, S.C.
NUESTRO COMPROMISO POR LA CALIDAD
Resultados de la Calibración
Calibration Date Sheet
Laboratorio de Metrología Magnitud: LONGITUD
Metrology Laboratory, Measure equipment calibration in several Areas
FECHA DE CALIBRACIÓN: 2023-02-03 No. DE CERTIFICADO: QELC 0530/18 HOJA: 2 DE 2
(Calibration Date) (Certificate Number) (Page)
resultados de calibracion
LA INCERTIDUBRE DE LA MEDIDA SE OBTUVO MULTIPLICANDO LA INCERTIDUBRE COMBINADA POR UN FACTOR QUE ASEGURA UN NIVEL DE CONFIANZA DE AL MENOS 95% EN VALOR FACTOR DE
COBERTURA ES K=2. LA INCERTIDUNBRE DE LA MEDIDA FUE ESTIMADA DE ACUERDO A LA NORMA NMX-CH-140-IMNC.2002 “Guia para la expresión de la incertidubre en las mediciones”,
EQUIVALENTE AL DOCUMENTO “Guide to the of uncertainly in measurement BIPM, IEC, IFCC, ISO, IUPAP, OIML (1995)”.
EL VALOR NORMAL DEL PATRON Y EL VALOR DE MEDIDA DEL INSTRUMENTO, CORRESPONDE AL PROMEDIO DE LAS LECTURAS OBTENIDAS EN LA CALIBRACIÓN, BAJO LAS CONDICIONES ESPECIFICADAS.
EL PRESENTE CERTIFICADO SOLO AMPARA LAS MEDICIONES REPORTADAS EN EL MOMENTO Y CONDICIONES AMBIENTALES Y DE USO EN QUE SE REALIZO ESTA CALIBRACIÓN
Este certificado tiene validez únicamente en su forma íntegra, no se permite la reproducción parcial de este documento, sin la autorización por escrito de Asesoría y Servicios Integrales en Calibración S.C.
(This certificate is not valid without the corresponding signatures and stamp and it may not be reproduced other than in full, except with the prior written approval of the issuing Laboratory).