Documentos de Académico
Documentos de Profesional
Documentos de Cultura
CÓDIGO: 20142291
JEFES DE LABORATORIO:
2017 – 2
Laboratorio 10 – Metalurgia Extractiva 2017
ÍNDICE
Objetivos de la práctica.................................................. 3
Abstract ........................................................................ 3
Resultados ……………………………………………………… 7
Conclusiones …………………………………………………….... 10
Cuestionario ……………………………………………………….... 10
Bibliografía ……………………………………………………… 11
2
Laboratorio 10 – Metalurgia Extractiva 2017
1. OBJETIVOS DE LA PRACTICA
- Identificar cuáles son los factores externos que afectan a la recuperación de oro
en el proceso de precipitación de oro, con el fin de optimizar dicha recuperación.
2. ABSTRACT
In the present laboratory, the gold precipitation process was carried out. This
process was carried out for a high grade mineral of head (6.3 ppm) in order to
obtain gold from the cyanide solution in which it is housed. The results to be
obtained will be the metal content and the percentage of recovery. The following
stages were carried out: the first stage is clarification, based on the fact that solid
particles suspended in the gold cyanide solution should not exist, the second
stage, which is deoxygenation, indicates that the solution should not have
quantities of oxygen of 5 - 8 mg / l and must therefore be reduced by means of
vacuum pumps to an amount of oxygen of 0.5 - 1 mg / l in order that the solution
sweeps consume a reasonable amount of zinc. The third stage is that of
precipitation and sedimentation of gold, in this stage is where 1 gram of zinc
powder was used to apply the sedimentation of gold. After that, samples were
taken for chemical analysis obtaining the gold grades in ppm. The conclusion is
reached that as the time of agitation of the cyanide gold solution passes, a higher
percentage of gold recovery is obtained. That is why the Merrill - Crowe process
is a very effective process, besides it is very economical, since it allows to obtain
high recoveries in a short time of started with this process
3
Laboratorio 10 – Metalurgia Extractiva 2017
3. METODOLOGIA DE LA PRACTICA
3.1. Equipo y materiales utilizado
Solución básica Barren de cianuracion
Polvo de Zinc
Agitador
pH metro
Pipeta
Solución 0.1 molar de NaOH
Bomba de vacío
3.2. Procedimiento:
3ra etapa -
1ra etapa - 2da etapa -
Precipitacion de
Clarificación Desoxigenación
oro
4
Laboratorio 10 – Metalurgia Extractiva 2017
- Precipitacion de oro:
5
Laboratorio 10 – Metalurgia Extractiva 2017
6
Laboratorio 10 – Metalurgia Extractiva 2017
Imagen 5: Vaso precipitado en proceso de sedimentación para luego pasar a análisis químico.
4. RESULTADOS
- Tiempo de agitación
- Ley de oro en solución
- Ley de cabeza de la solución barren
Calculo:
Recuperación de oro:
Ejemplo:
Porcentaje de recuperación:
6.3 − 4.1
𝑅𝑒𝑐𝑢𝑝𝑒𝑟𝑎𝑐𝑖𝑜𝑛 % = ∗ 100% = 34.92%
6.3
La siguiente tabla son los resultados que se obtuvieron en los demás tiempos:
7
Laboratorio 10 – Metalurgia Extractiva 2017
15
15
10
10
5
5
0
0 1 2 3 4 5 6 7
TIEMPO (MIN)
- Esta grafica debe de guardar relación con la siguiente grafica a que es la del
porcentaje de recuperación con el transcurrir del tiempo.
8
Laboratorio 10 – Metalurgia Extractiva 2017
- % recuperación vs tiempo
% Recuperacion vs tiempo
100.00% 92.06%
90.00%
80.00%
RECUPERACION %
70.00% 58.73%
60.00%
50.00%
34.92%
40.00%
30.00%
20.00%
6.35%
10.00%
0.00%
0 5 10 15 20 25
TIEMPO (MIN)
5. DISCUSION DE RESULTADOS
- Las recuperaciones obtenidas por el proceso de Merrill Crowe son altas para el
tiempo que se trabajó además se dan de manera constante y lineal y no se
identifican problemas ya que la gráfica 3 es creciente y con una pendiente positiva.
9
Laboratorio 10 – Metalurgia Extractiva 2017
6. CONCLUSIONES
7. CUESTIONARIO
ÁNODO:
CÁTODO:
Cementación:
10
Laboratorio 10 – Metalurgia Extractiva 2017
Ya que son fáciles y rápidos de limpiar, solo se filtran partículas de oro y plata
que inmediatamente están listos para su proceso de fundición. Además, este
mineral es inerte y esto ayuda ya que no reacciona químicamente con otros
compuestos.
8 BIBLIOGRAFIA
- ALFARO, Edmundo
2017 Guía de laboratorio de Metalurgia extractiva. PUCP
11