Documentos de Académico
Documentos de Profesional
Documentos de Cultura
PSP
Eje trasero 156-2853 y eje trasero 156-2857
202 -0006
13: 3/07/1 49A6
0
RE 1:07- 0
N
© 2 R35 05:00
023 76
Cat
erp
illa
r In
c.
Ilustración 1 g00560763
(1) Utilice las siguientes cuñas para ajustar el cojinete del diferencial. El tamaño de la cuña es igual
a la dimensión entre la copa del cojinete y el disco de freno antes de instalar la carcasa del freno.
9R-2427 Grosor del suplemento ... 0,965 a 1,016 mm (0,0380 a 0,0400 pulgadas)
9R-2428 Grosor de la cuña ... 1,118 a 1,168 mm (0,0440 a 0,0460 pulgadas)
9R-2429 Grosor del suplemento... 1,270 a 1,321 mm (0,0500 a 0,0520 pulgadas)
(3) Apriete los 25 pernos 9X-8880 al siguiente par. ... 176 a 258 N·m (130 a 190 lb pie)
(4) Tighten the six 3K-3379 Bolts to the following torque. ... 135 to 170 N·m (100 to 125 lb ft)
(5) Tighten the 9R-2502 Nut to the following torque. ... 271 to 813 N·m (200 to 600 lb ft)
(6) The pinion bearing preload is 1.1 to 4.5 N·m (10 to 40 lb in). Spacers that are used to adjust the
pinion
(8) Tighten the twelve 8S-4740 Bolts to the following torque. ... 169 N·m (125 lb ft)
(9) The axle shaft end play is 0.025 to 0.076 mm (0.001 to 0.003 inch). Spacers that are used to
adjust the axle shaft end play
(10) Tighten the two 9R-2466 Bolts to the following torque. ... 620 ± 80 N·m (457 ± 60 lb ft)
(11) Tighten the four 156-1929 Studs to the following torque. ... 40.8 ± 13.6 N·m (30.09 ± 10.00 lb ft)
(12) Tighten the four 5P-0540 Nuts to the following torque. ... 119 ± 10 N·m (88 ± 7 lb ft)
(13) Apriete las doce contratuercas 2M-2570 al siguiente par. ... 115 N·m (85 libras-pie)
(14) Apriete los ocho pernos 9R-2485 al siguiente par. ... 92 a 125 N·m (68 a 92 lb pie)