Documentos de Académico
Documentos de Profesional
Documentos de Cultura
836 977 1 PB PDF
836 977 1 PB PDF
de probetas de tierra
Analysis of results of tests carried
out on earth test pieces
JULIAN SALAS, Dr. Ing. Industrial (lETcc-CSIC)
MARIA JESUS GUINEA, Arquitecta (lETcc-CSIC)
Serrano Galvache, s.n. 28033 Madrid/España
JUAN DIEGO BERNAL, Arquitecto (MEDELLIN-Colombia) {*)
Fecha de recepción: 15-IV-88
RESUMEN SUMMARY
Partiendo de un suelo concreto, tierra roja de Soria, de la A series of test pieces of 4X4X16 were prepared from
que se aportan datos para su caracterización Red Earth from Soria, the physical-chemical characteristics
físico-química, se han realizado series de probetas of which are given. The effect of each of the following
de 4X4X16 cm, sobre las que se ha estudiado la upon the test pieces was studied: increasing the amount
influencia: del aumento de cemento sobre distintas of cement on different earth/sand proportions; the type of
proporciones tierra/arena; del tipo de cemento; de la cement; the variation of the cement proportion
variación de la proporción de cemento sobre relaciones maintaining constant earth/sand proportions. In each
concretas tierra/arena; ...presentando en todos los casos case the bending-tensile and compressive strengths are
los valores a compresión, a flexotracción, así como la given, and well as interrelationships between them.
interrelación entre ellos.
El suelo empleado queda definido, a efectos The earth used is defined for the purposes of
de este trabajo, por la aportación de this study by the results of the following tests:
resultados de las siguientes pruebas: Análisis mineralogical analysis by X-ray diffraction
mineralógico por difracción de Rayos X (Fig. 1); chemical composition (Table 1);
(Fig. 1); Composición química (Tabla 1); particle size analysis (Figs. 2a and 2b) and
Estudio granulométrico (Figs. 2a y 2b) y geo-technical and mechanical characteristics
Características geotécnicas y mecánicas (Table 2).
(Tabla 2).
(*) Este trabajo, realizado en el nriarco del Equipo de (*) This study, carried out within the framework of the
investigación "Viviendas de muy bajo coste", es Research Team "Very Low Cost Housing", is the result
resultado de un dilatado proceso de ensayos, en of a long series of tests, some of which saw the
parte de los cuales se contó con la colaboración de collaboration of Edgard Rohmer and Carmen Luengo.
Edgard Rohmer y Carmen Luengo. Igualmente Likewise, we are indebted to Drs. Luxán and
han aportado su inestimable colaboración las Sanchez-Rojas, as well as Dr. Sagrera and Ms. Gómez
Dras. Luxán y Sanchez-Rojas así como el for their invaluable collaboration.
Dr. Sagrera y la Lda. Gómez. A todos ellos nuestro
agradecimiento.
1 .00
0.64
0.49
0.36H
0 .25
0 .1 b H
0.09
0-044
0 . 0 1 |-Y^'^>^N>-.4-H^^ ^/^^ w Hrr-lHttl '^.•r'
OCT Í?)
5 10.0 15.0 20.0 30.0 r^:5 , 0 40 . 0
1 .00
0.3H
0.64
0.49
0.25
0.16
0.09
0 .04 « f ir: 1 ft- 3
'•.K^V^^W^í'-.^^
0.01 M '-^^1
TEST.18/18.10.87/15:^28 :?T.18/18.10.8?/15:2?
40
hi
0
M
1 J
36 1 1 llllll 1 llllll II 1 III
'\. llllll 1 1 llllll
it intWWKK\\\\\\\
1 111 , . . ,L«4
h
3
Jl It:
J; 28
L
I' M
\w\\\ 5
OP 16 M
1 Ml
11
So. \\m
\m -J
in 1
Z
3n
o
ft/»
Mi J^
Mm
U
1 8
12
/ 1
10
-1
M 0
10
2
10
1 so 2
10
3
10 yA
— 1
mf
10
0
10
1 2
10
1
1 1 l l l l l l — 1 1 1 l l l l l l — 1 1 1,1 lllllAoc?.! 1 1 l l l l l l
10
3
X / MICRONS X / mCROHS
TABLA 2 (TABLE 2)
Caraterísticas geotécnicas y mecánicas del Suelo Rojo de Soria
(Geotechnical and Mechanical Characteristics of Red Earth from Soria)
Arena: 36,9 %; Limo: 36,5 %; Arcilla: 26,6 % Sand: 36.9 %; Mud: 36.5 %; Clay: 26.6 %
A la vista del abaco, se deduce que el suelo es It can be deduced from this abacus that
apto para la estabilización y la construcción. the earth is apt for stabilizing and
Podría objetarse la presencia de un exceso construction. The presence of an excess of
(63,1 %) de finos (limo+arcilla), por lo tanto ha fine particles (mud + clay = 63.1 %) can be
de corregirse la granulometría, añadiendo una objected to; thus the graduation must be
pequeña proporción de arena, consiguiendo corrected by adding a small proportion of
así una granulometría no uniforme y, por sand. In this way a non-uniform graduation is
Retracción lineal = 0,654 IP — 0,00333 IP^. Linear Retraction = 0.654 PI — 0.00333 (Pl)^
Para el suelo en estudio: IP = 14,4;
For the earth under study: PI = 14.4; therefore,
por lo tanto la R.L = 8,73 %. the L.R. = 8.73 %.
OAIOO
100^^ ^ ^ ^ c^ ^ V V ^ V \Q
0 10 20 30 40 50 60 70 80 90 100
LIMO ( 0 . 0 5 m m - 0 . 0 0 5 m m )
Fig. 3.—Abaco de clasificación de los suelos por su tex- Fig. 4.—Cuadro de zonas preferenciales de estabiliza-
tura. ción en función de la plasticidad.
Fig. 3.~Soils clasification abacus by textures. Fig. 4.—Preferential zones of stabilization by plasticity.
En la Tabla 3 se recogen las características The graduation of the sand used are shown in
granulométricas de la arena empleada. Table 3.
TABLA 3 (TABLE 3)
Granulometría de la arena empleada (Graduation of the sand used)
1 2,000 0
2 1,500 90 - 240 6- 16
3 1,200 270 - 420 18- 28
4 0,750 630 - 780 42 - 52
5 0,500 900 - 1.080 60- 72
6 0,250 1.110- 1.260 74- 84
7 0,150 1.245- 1.395 83- 93
8 0,090 1.395- 1.470 93- 98
9 0,075 1.440 - 1.500 96-100
TABLA 4 (TABLE 4)
TABLA 5 (TABLE 5)
El suelo se preparó antes de la mezcla en la Before mixing, the earth was prepared in the
forma siguiente: following manner:
a) se secó en estufa a 60° O y O % H.R. Se a) stove-dried at 60° C and 0 % R.H. This was
realizó esta operación para poder calcular done in order to accurantely determine the
con fiabilidad el agua de amasado, ya que mixing water, since this depended
ésta depende considerablemente de la considerably on the natural humidity
humedad natural que retiene el suelo, retained by the earth's clay content;
debido a la arcilla;
b) se machacó con martillo de goma, para b) crushed using a rubber hammer in order to
desmenuzar ios terrones; break up clods;
c) se pasó Dor el tamiz de 2.000 jum; n.° 10, c) passed through a sieve of 2.000 ¡im; no. 10,
UNE-7050. UNE-7050.
La mezcla se mantuvo durante 10 minutos en The mix was kept for 10 minutes in a type
una túrbula Tipo T-2C, Nr. 810820, para T-2C, Nr. 810820 mixer in order to achieve
conseguir mayor homogeneidad, se agregó a greater homogeneity; later, water was added
continuación el agua y se amasó manualmente and the mix was manually mixed for at least
durante 5 minutos como mínimo, para 5 minutes in order to achieve the greatest
conseguir un reparto lo más homogéneo homogeneity possible. The test pieces were
posible de la misma. Las probetas se executed in molds of three, with dimensions of
realizaron en moldes de tres, de dimensiones 4X4X16 cm.
4 X 4 X 1 6 centímetros.
La masa se colocó en tres tongadas, The mass was then set in three layers,
golpeando a mano con una maza de madera manually struck with a wooden maul in
para conseguir una cierta compacidad, order to compact it somewhat. This factor,
comprobándose que, aun siendo manual, es even if acheved manually, clearly influences
éste un factor claramente influyente sobre la the porosity and the mechanical strength of
porosidad y la resistencia mecánica de las the test pieces.
probetas.
Por razones de claridad metodológica, en In each case, and in order to follow a clear-cut
todos los casos se ha optado por mantener methodology, we have chosen to maintain
constantes las proporciones porcentuales de constant the percentages of test pieces
los materiales componentes de las probetas component materials, despite being aware that
ensayadas, aún conscientes de que el mathematically this is erroneous. Table 6
planteamiento matemático es erróneo. En la shows the real percentage equivalents. For
Tabla 6 se recogen las equivalencias example, when we refer to test pieces of "80 %
porcentuales reales. Por ejemplo, cuando nos earth, 20 % standardized sand and 12 %
referimos a probetas con "un 80 % de tierra, cement" one must understand the real
20 % de arena normalizada y 12 % de percentage values to be, according to said
98,03 96,15 94,33 92,59 90,90 89,28 87,21 86,20 84,74 83,33
100
0 0 0 0 0 0 0 0 0 0
0
1,97 3,85 5,67 7,41 9,1 10,72 12,29 13,80 15,26 16,67
88,23 86,53 84,90 83,33 81,80 80,35 78,94 77,58 76,27 75,00
90
9,8 9,61 9,25 9,10 9,10 8,92 8,77 8,62 8,47 8,33
0 1,97 3,86 5,49 7,42 9,10 10,73 12,29 13,80 15,26 15,67
78,43 76,92 75,47 74,07 72,72 71,43 70,17 68,96 67,79 66,66
80 '
19,61 19,23 18,86 18,52 18,18 17,86 17,54 17,24 16,95 16,67
20
1,96 3,85 5,67 7,41 9,10 10,71 12,28 13,80 15,26 16,67
68,62 67,30 66,03 64,81 63,63 62,50 61,40 60,34 59,32 58,33
70
29,41 28,84 28, 30 27,77 27,27 26,78 26,31 25,86 25,42 25,00
30 1,97 5,67 9,10 13,80 16,67
3,86 7,42 10,72 12,29 15,26
58,72 57,69 56,60 55,55 54,54 53,57 52,63 51,72 50,84 50,00
60
39,21 38,46 37,73 37,03 36,35 35,71 35,08 34,48 33,89 33,33
40 15,67
1,97 3,85 5,67 7,42 9,10 10,72 12,29 13,80 15,27
49,01 48,07 47,16 46,29 45,45 44,64 43,85 43,10 42,37 41,66
50
49,01 48,07 47,15 46,29 45,45 44,64 43,85 43,10 43,27 41,66
50
1,98 3,86 5,68 7,42 9,10 10,72 12,30 13,80 15,26 17,68
39,21 38,46 37,73 37,03 36,36 35,71 35,08 34,48 33,89 33,33
40
53,82 57,69 56,60 55,55 54,54 53,57 52,63 51,72 50,84 50, CO
60 16,67
1,97 3,85 5,67 7,42 9,10 10,72 12,29 13,80 15,27
29,41 28,84 28.30 27,77 27,27 26,48 26,31 25,86 25,42 25,00
30
68,62 67,30 66,03 64,81 63,63 62,50 61,40 60, 34 59, 32 58,33
70
1,97 3,86 5,67 7,42 9,10 10,72 12,29 13,80 15,26 16,67
19,61 19,23 18,86 18,52 18,18 17,86 17,54 17,24 16,95 16,67
20 71,43 70,17 68,96 67,79 66,66
78,43 76,92 75,47 74,07 72,72
80 16,67
1,95 3,85 5,67 7,41 9,10 10,71 12,28 13,80 15,26
cemento" hay que interpretar, según la tabla Table: 71.43 % earth, 17.86 % standardized
mencionada, que la proporción porcentual real sand, and 10.71 % cement.
de dicha probeta es: 71,43 % de tierra,
17,86 % de arena normalizada y 10,71 % de
cemento.
Dos han sido los datos estudiados en todos Two data were studied in each case:
los casos: resistencia a compresión y a compressive strength and bending tensile
flexotracción. En ambos casos se procedió strength. In both cases, the tests were carried
sobre probetas de 4 X 4 X 1 6 cm realizadas en out upon test pieces produced in the manner
la forma que se describe en el Apartado 2. Al described in Part 2. After one day, the test
cabo de un día, en ambiente de laboratorio, las pieces were broken and the pieces weighed.
probetas se desmoldaban, se pesaban y se They were then kept for 6 days in a curing
mantenían seis días en la cámara de curado a chamber at a constant temperature
temperatura ( 2 1 ° C ± 1°C) y humedad (2rC±rC)and humidity (95 %±3 %).
(95 % ± 3 %) constante, pasando Immediately afterwards they were put in a
seguidamente —durante 24 horas— a una stove for 24 hours at 60"" C and 0 % R.H. Once
estufa a 60° C y O % H.R.; transcurrido este the 24 hours was up they were weighed once
tiempo se pesaban nuevamente y se sometían more and submitted to the bending-tensile
En los gráficos siguientes se representan los The following graphics show the three results of
tres valores resultantes en cada serie y el each series and their average.
valor de la media de éstas.
Otros resultados sobre el comportamiento de Other results concerning the behaviour of this
este tipo de suelo, han sido publicados por los type of earth have been previously published
autores (4) y (5), anteriormente. by authors (4) (5).
Se prepararon series de probetas a base de A series of earth test pieces were prepared to
tierra, a las que posteriormente se agregaron which increasing quantities of PA'350
cantidades crecientes de cemento PA-350, cement were later added. This quantity ranged
desde O % a 20 %, en incrementos de 2 % en from 0 % to 20 %, and was added in increments
2 %. Por tratarse de composiciones binarias, of 2 %. Since these are binary compositions, in
los valores porcentuales teóricos y reales son, this case the real and theoretical percentages
en este caso, coincidentes. are coincidents.
I.b. La tendencia general de caída de I.b. The general trend of a drop in compressive
resistencias a compresión, sólo se frena strengths is only stopped at proportions of
para proporciones de cemento superiores cement superior to 14 %, equivalent to a
a M 4 %, que equivale en valor real al real value of 12.29 %.
12,29 %.
I.e. Resulta notable la escasa influencia del I.e. The small effect of cement on bending-
cemento sobre la resistencia a tensile strength is worth noting. This
flexotracción, que se mantiene entre practically remains within the 0.8 MPa to
0,8 MPa y 1,7 MPa, prácticamente para 1.7 MPa range for cement contents
contenidos desde el 2 % de cemento al between 2 % and 20 %.
20%.
Partiendo de una proporción constante de A series of three test pieces were prepared
tierra (80 %) y arena normalizada (20 %), se using a constant proportion of earth (80 %)
han realizado series de tres probetas con la and sand (20 %). PA-350 cement was added in
incorporación de cemento PA-350, en increments of 2 %, from 0 % to 20 % (real
proporciones crecientes de 2 % en 2 %, desde values are given in Table 6). Figure 6 shows
el O % al 20 % (para los valores reales, ver the average compressive and bending-tensile
Tabla 6). En la figura 6 se recogen los valores strengths.
medios de las resistencias a compresión y a
flexotracción.
\
\ /_ ^ • - —
i i
) " -- ^ \ C O M P f LESION: 1 ; \ ^ \.
COMPRESIÓN:
• j -
• y - 0.02 4 0 x2 - 0 . 6 4 5 4
y = 0 . 0 1 5 8 2 x2 -- 0 . 3 0 5 3 9 X -i- 4 . 7 7 6 1 9 ''
^^<:^ '' \
N
• — " ^ ]•-••• \ - X
^.... _..
\ _ - -" •i——- \
• ^
3 i y "1
^ \ I7
FLEXO TRACCI DN:
'y 0.0 0 7 1 6 X 1.04659
1 y = - 0.0548 X + 1 .9193
• — - H =—.=^^ 1\ _ —, LJ-...- J
~1
~~]
r '"' -^
— - 1
Pl-
G Q 10 12 IG 18 20 10 12 14 16 IB 20
% PA-350 % Cemenio PA-350
Figura 5 Figura 6
Del análisis de los resultados pueden The following can be deduced from an analysis
deducirse algunas conclusiones: of the results:
Para los valores medios de las once series de Figure 7 shows the line
probetas estudiadas, la figura 7 recoge la y = 0.26076 x = 0.05237 for the average
recta de ajuste / = 0,26076 x — 0,05237. values of the eleven series of test pieces studied.
lll.a. La influencia del tipo de cemento lll.a. The effect of the type of cement
empleado es francamente notable; en employed is worth noting. In some cases,
algunos casos se superan los increases of more than 100 % are seen in
incrementos del 100 % al emplear el the use of P-450 with respect to PA-350.
P-450 respecto del PA-350.
•I.I-XOTRACCION
COMPFÍhSION
~ " ;••""••• • " T 1 r T - 1 1
• 8 0 % S U E L O R O J O DE SORIA
• i 1 i 2 0 % ARENA N O R M ALIZADA y
1 • X % C E M E N T O PA-3 5 0 y ^
: , i ¡ 1 1
¡ ; i i o"'"''
• " • " ~ í i 1
i i -1 « ¡ ^
<i
1
fl.. ^ 1. \ i I COMPRESIÓN
Figura 7 Figura 8
TLEXOTRACCION
FLEXOTHACCION
MPa
X, % S U E L O ROJO DE SORIA
X2 % A R E N A N O R M A L I Z A D A
! i 1
X, % S U E L O R O J O DE SORIA
Xj % ARENA N O R M A L I Z A D A
1 2 % C E M E N T O PA-350
1 2 % C E M E N T O P-450
i l„, X
>o
1 s^'^'y
,0-
^^^ / ^
^ • y
^
0-^
1 2 3 4 5 B 7
Figura 9 Figura 10
lll.c. Las figuras 9 y 10 muestran la muy clara lll.c. The clear relation between compressive
relación existente entre la resistencia a and bending-tensile strengths in both
la compresión y a flexotracción en ambas series is seen in Fig. 9 and 10.
series de probetas.
Cada una de estas series se repitió con Each series was repeated with cement
adiciones de cemento PA-350 de O %; 2 %; additions of 0 %, 2 %, 6 %, 12 %, and
6 %; 12 % y 20 %, lo que supone un total de 20 %. A total of 120 test pieces were
120 probetas ensayadas. tested.
-^ COMPRESIÓN:
y = 0.0007 X? — 0 . 0 0 p 3 8 5 x • 2.8685
FLEXOTRACCIÓN:
y = - 0 . 0 1 7 0 X -i- 2.2252
Figura 11 Figura 12
I " T
] 1 r • T í !1 i 1
1 ;
X, % S U E L O ROJO DE SORIA |
Xj% ARENA N O R M A L I Z A D A •• 1 i X, % S U E L O ROJO DE SORIA
Xy % ARENA N O R M A L I ZADA
6 % C E M E N T O PA-350 I 12% C E M E N T O PA-35 0
r i 1 1 ! '•
i I . ..i : -
i
i 1 ' i
-- i ! i !
COMPRESIÓN:
y = 0 . 0 0 1 1 4 X? - 0.162 X t- 6.7238 z' k\ COMPRESIÓN:
y - 0 . 0 0 0 1 9 7 x-í - 0 . 0 4 7 8 x t- 5.1 3 7 8
I * 1 ^ ^^ ^ i !
i •
•S~ -~-~~A^^_'^ \
^
TLEXOTRACCION;
y • •• - 0 . 0 0 8 0 X ' 1.2877
— — • •
~^—T"—i ^
i 1-
Figura 13 Figura 14
IV.a. Las series de probetas sin cemento IV.c. The series of test pieces without cement
presentan caídas de resistencias, tanto show a drop in strength, both
a compresión como a flexotracción, compressive and bending-tensiie, as the
conforme aumenta la proporción de percentage of standardized sand
arena normalizada. increases.
IV.b. La adición del 2 % de cemento no frena IV.b. The addition of 2 % cement does not
la caída de la resistencia aludida, sólo stop the above-mentioned fall, although
que con valores sensiblemente inferiores this drop is not as steep as in IV.a.
a los del caso anterior.
IV.c. La aportación del cerinento en una IV.c. The addition of 12 % cement (theoretical
proporción teórica del 12 % frena las proportion) stops loss of strength only for
pérdidas de resistencia sólo para earth/sand mixed equal to or less than
proporciones tierra/arena iguales o 50/50, a fact explained by the behaviour
menores de 50/50, lo cual es explicable as a mortar of standardized sand with
por el comportamiento como mortero de cement. In these cases, earth has a
la arena normalizada con el cemento. La perturbing effect
tierra en estos casos tiene una presencia
perturbadora.
FLEXO-TRRCCION
X, % S U E L O R O J O DE SORIA
Xj % ARENA N O R M A L I Z A D A
2 0 % C E M E N T O PA-350
COMPRESIÓN:
y •• — 0 . 0 0 0 1 4 x2 — 0 . 0 4 9 7 x -i- 3 . 1 2 4 4 l
I I
FLEXOTRACCIÓN:
y = 0 . 0 0 4 8 1 x t- 1.2947 i
( 1 • 1
% CEMENTO PA-350
Figura 15 Figura 16
FLEXOTRACCIÓN
COMPRESIÓN
1 1 1
X, % S U E L O R O J O DE SORIA
Xj % A R E N A N O R M A L I Z A D A .f*
0 % CEMENTO ^
^.-^
yi
y ^
Figura 17 Figura 18
De forma general, para la tierra ensayada, In general and with respect to the earth tested,
puede afirmarse de acuerdo con la figura 16 the following can be deduced from Fig. 16:
que:
^0
''/^
. 1 ^ ^ '
^!^
#0^
^ i
>^
0 -
MPa
COMPRESIÓN COMPRESIÓN
Figura 19 Figura 20
FLEXOTRACCIÓN
FLEXOTRACCIÓN
MPa
L,*^^
^/ „ r^^'^ wO'
.0
^-^ >^'
^0
*» >^
^ *
y -
9 10
MPn MPa
COMPRESIÓN COMPRESIÓN
Figura 21 Figura 22
De los resultados a compresión (figura 17), se And with respect to compressive stengths,
deduce: from Fig. 17 we can deduce:
Vl.a. Decrecen sensiblemente los resultados Vl.a. The results decrease notably upon
al añadir un 2 % de cemento PA-350. adding 2 % of PA-350. They continue
Continúan decreciendo al pasar a un 6 % falling until 6 %, with the exception of
de cemento, con excepción de las earth/sand mixes of 80/20 and 20/80.
proporciones tierra/arena del 8 0 / 2 0 y del
20/80.
VI.b. Todas las proporciones tierra/arena ven VI.b. All earth/sand proportions show an
incrementar, de forma sensible y cuasi en increase in compressive strengths,
forma lineal, sus resistencias a almost in a linear fashion, going from
compresión, cuando se pasa del 6 % al 6 % to 12 % cement.
12 % de cemento.
Vl.c. Se detectan crecimientos moderados en Vl.c. Moderate increases are seen in all cases
todos los casos, excepto en la proporción as the cement proportion increases from
tierra/arena de 2 0 / 8 0 , que es del orden 12 % to 20 %, except for earth/sand
del 200 %, al incrementar el cemento del 20/80, where it is around 200 %.
12 % al 20 %.
REFERENCIAS BIBLIOGRÁFICAS
(1) CRATerre: "Construiré en Terre". Editions Alternatives, pp. 285. Paris, 1979.
(2) Department of Scientific and Industrial: Traducción de L. Valero. "Mecánica del Suelo". Centro de Estudios y Experi-
mentación de Obras Públicas, pp. 659. Madrid, 1963.
(3) BRANSAKA, Muhirve: "Habitat au Burundi: l'apport du matériau terre". pp. 99-112. UCL-UCO, 1982.
(4) GUINEA, María Jesús: "La tierra material resistente al agua". Monografía n.° 385/386. Instituto Eduarto Torreja,
pp. 25-30. 1987.
(5) SALAS, Julián; GUINEA, M.* Jesús; NAREDO, Teresa: "Influencia de cinco procesos de curado en las resistencias
mecánicas de probetas de tierra". (Pendiente de su publicación). Housing Science and its applications.