Documentos de Académico
Documentos de Profesional
Documentos de Cultura
1 1 19-12
SUBJECT DATE
Driver Notifications, Descriptions, and Action & Parked Regeneration
January 2012
Procedure
DDC-SVC-MAN-0084 EPA10 DD
Instrument Panel Lamps Two new instrument panel lamps added to section
DDC-SVC-MAN-0083 Platform
Amber Warning Lamp (AWL) Indicates a fault with the engine Vehicle can be driven to end of
controls. shift. Call for service.
• At the start of every ignition cycle (bulb check). • Diagnostic request switch is used to activate the AWL to flash
• When an electronic system fault occurs. (Fault should be diagnosed inactive codes. (EPA07 function only.)
as soon as possible.) • Flashes last 90 seconds before idle shutdown if programmed for
override.
• Flashes when idle shutdown or the optimized idle shutdown occurs.
Red Stop Lamp (RSL) Indicates a major engine fault that Move the vehicle to the nearest
may result in engine damage. safe location and shut down the
Engine derate and/or shutdown engine. Call for service.
sequence will be initiated.
• At the start of every ignition cycle (bulb check). • Flashes when engine protection shutdown occurs.
• A potential engine damaging fault is detected. • Diagnostic request switch is used to activate the RSL to flash active
codes. (EPA07 function only).
• At the start of every ignition cycle (bulb check). When a regeneration is required immediately (if the lamp flashing is
• Regeneration is required. ignored), a derate and/or shutdown could occur.
High Exhaust System Lamp is yellow. Indicates exhaust Vehicle can be driven. Lamp solid
Temperature (HEST) Lamp temperature is above a preset limit for an extended period (Longer
and unit is operating at low vehicle than 40 Minutes) - call for service.
speed (below 5 mph [8 kph]).
When the engine speed is
elevated for a parked
regeneration, lamp will flash once
every 10 seconds.
• At the start of every ignition cycle (bulb check). Flashes every 10 seconds when the Selective Catalytic Reduction
• Vehicle speed is less than 5 mph and the Diesel Particulate Filter ( SCR Catalyst) is not up to temperature
(DPF) outlet temperature is greater than 525° C (977° F).
Malfunction Indicator Lamp (MIL) Yellow lamp Indicates a failure of Vehicle can be driven to end of the
an Emission Control device. May shift. Call for service.
illuminate at the same time as the
Amber Warning Lamp.
Fuel Filter Restriction Sensor Yellow lamp Indicates that the fuel Service soon
(FFRS) Lamp filter is restricted and needs to be
serviced. May illuminate at the
same time as the Malfunction
Indicator Lamp (MIL) and Amber
Warning Lamp (AWL)
Water-In-Fuel (WIF) Lamp Yellow lamp indicates that the fuel Engine water separator must be
water separator has reached its drained or an engine derate will
capacity and needs to be drained. occur.