Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Características – Instalación -
Comisionamiento Mayo 2015
2
CARACTERISTICAS: Layout y versión de HW del equipo
IDU ALC Plus2e COMPACT – 1+0 – 18xE1 4xGigabit Ethernet PWE3 EPP
IDU Short Description Part Number Configurations
Enhanced Packets
IDU ALC+2e 1+0 4GE 18xE1 PWE3 EPP GAI0198 Processor 1+0
(ETH Compressor)
3
CARACTERISTICAS: Descripción de HW IDU - ODU
MNGT Ports Puerto LAN3 y LAN4 Óptico Conectores SCSI
Port USB
10/100 Mbps 100/1000 Mbps Tributarios E1 Power Supply
Local Craft Terminal
Puerto de Sync,
Puertos Ethernet Eléctricos
10/100/1000 Mbps T3-E1, MNGT
Conector DB9
Alarmas Externas
Fusible de
Protección
IDU
(2Mhz) Conector SMA
IF Interface
Tarjeta SD
Respaldo firmware y backup
ODU
4
CARACTERISTICAS: Operativilidad
Interfaz Ethernet: Descripción
Consumo de Energía
IMAX (IDU only) IMAX (IDU + ODU) Consumo
IDU
(Solo IDU)
ALC Plus2e 1+0 0.88A (@40.8 Vdc) 1.5A (@40.8 Vdc) 36 W (@57.6 Vdc)
5
CARACTERISTICAS: Throughput o Capacidad de Enlace
BW Modulación Throughput
28 Mhz 256 QAM 170 Mbps
56 Mhz 256 QAM 340 Mbps
6
CARACTERISTICAS: Funcionalidades
General performances:
• Modulations: 4 – 16 – 32 – 64 – 128 – 256 QAM
• Bandwidth (ETSI): 7 – 14 – 28 – 40 – 56 MHz
• Fast ACM: switch-over speed up to 400changes/sec, 30dB/s guaranteed, 70dB/s typical
• Power consumptions: 36W (Only IDU)
• Power supply range: 35 ÷ 60V.
• Up to 500Gbps with Multilayer Packet Header Compression
• Radio buffer size 65.5Mbit (8 queues with unlimited pointers, 8.2Mbit per queue)
Additional features :
• Synchronous Ethernet on Radio, electrical and optical LAN ports
• Support of SyncE Quality G.8261/G.8264 with SSM
• Ethernet Multilayer Packet Header Compression
• PWE3 Cross Conection TDM to Eth / MEF8, IPv4 and IPv6, MPLS
• Input filter policing - Control & Bandwidth Profile:
CIR/EIR: per UNI, per EVC and per CoS
• Congestion Avoidance / Scheduling:
RED & WRED / WFQ & Strict Priority.
• QoS based on Pbit - IPv4/IPv6 and MPLS "EXP" bits
• Monitoring and statistics :ToS+QinQ+VLAN
7
CARACTERISTICAS: Modulación Adaptativa
• ACM Adaptive Code Modulation with 8 profiles
• Hitless modulation and code selection from 4 to 256 QAM
• TDM i/f (if any) undisturbed during ACM Switch
• Fast ACM switch-over
• From 7 MHz to 56 MHz (all modulations 4 -> 256 QAM) channel BW
• MSE based hitless modulation switch
256QAM
Voice & real 128QAM 8
64QAM 32QAM
time 16QAM 4QAM
8QAM 4QAM STRONG
services
Non-real
time services
CARACTERISTICAS: Comprensión de Paquetes
PACKET HEADER COMPRESSION
+ • ETHERNET OPTIMIZATION:
2% - 7% Gain depending on frame sizes
This features is always embedded in the equipment.
• HEADER COMPRESSION:
10% - 200% Gain depending on frame sizes & protocols
This features can be enabled and configured by WebLct
9
CARACTERISTICAS: Comprensión de Paquetes
• ETHERNET OPTIMIZATION
• HEADER COMPRESSION
10
CARACTERISTICAS: Comprensión de Paquetes
• ETHERNET OPTIMIZATION
• HEADER COMPRESSION
11
CARACTERISTICAS: Comprensión de Paquetes
• ETHERNET OPTIMIZATION
• HEADER COMPRESSION
O O O
PAYLOAD PAYLOAD PAYLOAD
H H H
12
CARACTERISTICAS: Comprensión de Paquetes
ALCplus2e - PACKET HEADER COMPRESSION
Just 12 bit label streams
Compression gain : 3% up to 200% depending on protocol stack
CRC protected process
Pure hardware compression : Low additional latency (<5μs)
Responsive header compression (L2, L2.5, L3, L4)
Compressed in
10/12bits context
CONTEXT LABEL
CARACTERISTICA: Sincronismo IEEE 1588v2 PTP
Distributes time and frequency over packet based network
eNodeB (Slave)
Ordinary Clock
PACKET
NETWORK
eNodeB (Slave)
Ordinary Clock
14
CARACTERISTICA: Sincronismo IEEE 1588v2
Diagrama de transporte del sincronismo a través de la trama Ethernet
QoS Q4
Q3
Q2
Q1 256QAM 4QAM
JUMBO
Q0 J U M B O
CARACTERISTICA: Proceso de Gestión de Tráfico
16
INSTALACIÓN
17
INSTALACION: Ensamblado de Antena y ODU
Fijación de Support
Posición del Ring Mount en el mástil
18
INSTALACION: Ensamblado de Antena y ODU
19
INSTALACION: Ensamblado de Antena y ODU
ODU ASN con Antena integrada con ODU ASN con Antena integrada con
polaridad Vertical polaridad Horizontal
20
INSTALACION: Kit de Antena
21
INSTALACIÓN: Característica de los Cables
22
INSTALACION: Cable RG8 o IF
23
INSTALACION: Puntos de Aterramiento
24
INSTALACION: Kit de Accesorios de Instalación
25
INSTALACION: Kit de Accesorios de Instalación
26
INSTALACION: Kit de Accesorios de Instalación
Solar Shield – Protector Plástico color blanco
27
COMISIONAMIENTO
28
COMISIONAMIENTO: BW y Modulación
29
COMISIONAMIENTO: Seteo del TDM Capacity
30
COMISIONAMIENTO: Seteo de la Frecuencia de Tx
31
COMISIONAMIENTO: Seteo de la Potencia de Tx
32
COMISIONAMIENTO: Habilitación de la LAN1 y PORT A
LAN1 Port A
33
SIAE MICROELETTRONICA S.A.C
Av. Paz Soldán, 170 int 602
San Isidro
Lima - Perú