Documentos de Académico
Documentos de Profesional
Documentos de Cultura
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
Resumen
Se compararon tres tipos de circuitos resistivo, RC y RC con diodo, acoplados a un tiristor SCR para medir
el comportamiento de la onda de salida u onda que estaba realizando trabajo sobre una carga determinada,
con ello se pudo comprobar el comportamiento de la amplitud de la onda, el Angulo de retardo y la relación
de la parte resistiva del circuito de control con el retardo de la señal.
Además de esto se demostró la relación entre el voltaje y la corriente, en el cual se observó que el valor
de la resistencia limita la magnitud del voltaje y la corriente.
Palabras claves
Señal de entrada, rectificador, frecuencia, potenciómetro, diodo.
Abstract
Three types of resistive circuits, RC and RC with diode, were compared, coupled to an SCR thyristor to
measure the behavior of the output wave or wave that was doing work on a given load, with this it was
possible to verify the behavior of the amplitude of the waveform, the delay angle and the ratio of the
resistive part of the control circuit to the delay of the signal.
In addition to this, the relationship between voltage and current was demonstrated, in which it works that
the value of the resistance limits the magnitude of the voltage and the current.
Keywords
Input signal, rectifier, frequency, potentiometer, diode.
1
UNIVERSIDAD DE LA COSTA
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
2
UNIVERSIDAD DE LA COSTA
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
3
UNIVERSIDAD DE LA COSTA
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
𝑇 1𝑚𝑠
Figura 4. Señal de onda de la carga con circuito = = 0,5𝑚𝑠
2 2
a 12,3kΩ.
Si se pretende tener una corriente de conducción
Como se observa en el osciloscopio, la amplitud a partir del 10% de amplitud de la onda, se tiene
de la señal que ingresa en la carga es la amplitud entonces que:
máxima del voltaje, teniendo en cuenta que la
frecuencia de la señal es de 1kHz. Se observa que VALOR MINIMO
luego de alcanzar su amplitud máxima pasa a un
estado de no conducción. 0,5𝑚𝑠 → 180˚
𝑥 → 10˚
0,5𝑚𝑠 ∗ 10˚
𝑥= = 0,027𝑚𝑠
180˚
𝜏 = 𝑅𝐶
𝜏 0,027𝑚𝑠
𝑅= = = 270Ω
𝐶 100𝑛𝐹
VALOR MAXIMO
0,5𝑚𝑠
𝑅= = 5𝑘Ω
100𝑛𝐹
4
UNIVERSIDAD DE LA COSTA
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
5
UNIVERSIDAD DE LA COSTA
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
6
UNIVERSIDAD DE LA COSTA
DEPARTAMENTO DE ENERGÍA
ELECTRONICA DE POTENCIA
FACULTAD DE INGENIERÍA
Bibliografía