Documentos de Académico
Documentos de Profesional
Documentos de Cultura
PHYSICS PAPER 2
(PART B & C)
PHYSICS IS FANTASTIC
Paper 2 ( ESSAY )
Part B ( Observing ) => 20 Part C ( Choosing) => 20
Tahun
2004
Q9
Light /mirror pericope.
Q12
Electromagnet/ Electronic Transformer / diod Electomagnet (transformer- transmission electricity) Radioactive (sterilization of med. equipments)
2005
2006
2007
Pressure Bernoulli ( Sailboat) Force and motion (elasticity/safety in sport) Pressure (Vacuum cleaner) Pressure Archimedes( raft)
Electronic Transistor (On when darkOn when hot) Radioactive (safety in handling radioactive source) Radioactive (halt life/ treatment cancer) Waves (dish-solar cooker)
Force and motion (Safety feature for lorry) Light Total internal reflection ( fibre optic) Heat ( Water flask ) Force and motion (force- lawnmover)
2008
2009
2010
2007
2008 2009 2010
I
I
I
I I I
I
I I I I
I
I I
I --- Part B
I ---- Part C
Construct: Conceptualize
1. Make and state the observation Observation skill & critical thinking 2. Make comparison State the similarities and differences 3. State the relationship from the similarities and differences or state the principle/law involved.
5 POINTS
9.1 SINK DEEPER THAN 9.2 BOTH WEIGHT ARE SAME AREA 9.2 IS LARGER THAN 9.I DEPTH INCREASES, PRESSURE INCREASES 5. AREA INCREASES, DEPTH DECREASES 1. 2. 3. 4.
1. The Fan blows the air out of the vent 2. Produce a partial vacuum( low pressure) in vacuum cleaner. 3. Atmospheric pressure is higher than the pressure inside the vacuum cleaner. 4. Atmospheric pressure Pushed in the dirt
characteristics
reasons
reasons Cannot be compress Lighter Does not change to gas state easily Small force used Produce bigger force Strong (hard )/ does not rust easily
Pemarkahan -- kes 1
1. Maximum ONLY 4 marks
BUTTTT
Pemarkahan -- kes 2
EXPLAINING ALL THE CHARACTERISTICS OF given RETAINING WALL BUTTTTCHOOSE wrongly
reason. 3. Distinguish the most suitable material based on the characteristics stated. 4. Give reasons why the material chosen.
Q.12-2008
A new harbour is to be built at a new location. The suggested new location is either at a bay or a cape. Four models for the structure of the retaining wall are given. Table 12 below shows the location and the characteristics of the four retaining walls.
Explain the best location and the suitability of each characterictics in Table12. Determine the most suitable retaining wall to be used. Give the reason for your choice.
Worksheet
Answer
Characteristic
BAY The ______ SLOPING ______retaining
wall.
UNEVEN
______ surface
Decrease the wavelength / higher water pressure at higher depth. Reduce energy, wave is reflected at different direction. Protect form high wave / overflow of water.
8 marks
2 marks
TOTAL : 10 marks
No 11
characteristics
Method of moving lawnmover - Push the handle
Explaination
Bigger force produced
Therefore, I choose lawnmover M, 9 because it has push handle, big mass of lawnmower, big size of cutter blade and has large angle between handle and horizontal line
10
No 12
characteristic 1 Connection of cell - series Reason
Increase the voltage
2 4
Connection of battery To allow the flow of current -Positive terminal of cell to negative terminal of next cell 5 Connection of resistor and bulb Increase the resistance -series 7 Connection of bulb - parallel the most suitable circuit is X Because .
10 (1,4,5,7)
7M
Physics is Fantastic
Worksheet
low ability to break at high temperature, and ________________________________________ low oxidation level.
NO.3
Characteristic LOW ____specific heat capacity. smaller ______size of ice cream box Material for outer box: Plastic PVC ______ Bright ______ colour of outer box Explaination / reason Easy get cold / becomes cool quickly Easier to carry
Poor conductor of heat Does not absorb heat from surrounding quickly
No. 4
Characteristic Large ____ diameter
LOW _____density LOW ______ rate of expansion HIGH ______ melting point
Explaination / reason Reduce the resistance of the cables The cables will be lighter
Less expansion and sagging in the cable during hot day Can withstand high temperature / does not melting easily
Q is _____
Large diameter, low density, Because _________________________________ Low rate of expansion and high melting point. ________________________________________