Documentos de Académico
Documentos de Profesional
Documentos de Cultura
www.radiocrafts.com
Agenda
AMI overview Wireless M-Bus
NTA8130 OMS
AMI
WAN
NAN
HAN/LAN
HAN/LAN
Gateway
Wireless M-Bus
figawa,
Radiocrafts AS
Only European Norm for wireless metering Field proven in millions of meters Supported by all major metering companies in Europe
Radiocrafts AS
Background
Standardization work -> Cenelec, TC 294
EN 13757 standard Comm. Syst. for remote reading of meters
The Netherlands: NTA8130 as of Feb 2006 (last revision of Jan 2009) Germany: OMS specification released September 2009 TC 294 again active (re-launched July 2009)
EN13757-4:2005
Stationary Mode S
Unidirectional, S1, or bi-directional, S2 32.768 kb/s, 868.3 MHz
OMS
Open Metering System specification Assured co-existence with NTA 8130 / DSMR Unified approach for the different media (electricity, gas, heat and water) as well as actuators and displays Interoperation Optimized for battery lifetime of > 14 years Installation supported
OMS cont.
MUC (Multi Utility Controller): Intelligent concentrator between AMM and the devices Either S or T mode and AES 128 encryption MUC <-> meters OMS is being reviewed by CEN as European new work item proposal TC294
System topology
RC1180-MBUS module
Embedded protocol
supporting EN 13757-4:2005 mode S, T and R2
RC1180-MBUS module
2 channels in mode S and T
868.3 and 868.95 MHz
10 channels in mode R2
868.03 + n x 0.06 MHz
CE marked
Conforms with EU R&TTE directive EN 300 220, EN 301 489, EN 60950
High-end performance
Output power typical 10 dBm Excellent receiver sensitivity
Typical -102 dBm at 32.768 kbps
Excellent blocking
>-45 dBm at 2 MHz offset
Two way communication simplifies installation compared to only one-way 8-900m range / quarterwave antenna
20
EN 13757-4
UART
GPRS modem
UART
Ethernet gateway
UART
22
23
RC1180-MBUS
Man. ID
KNX is a registered Trademark of the KNX Association cvba, used with kind permission
Radiocrafts AS
&
KNX is a registered Trademark of the KNX Association cvba, used with kind permission
KNX is the worldwide standard for home and building control (~7000 certified products) IEC/ISO and EN standard Supporting media (RF, PL, TP, IP)
KNX is a registered Trademark of the KNX Association cvba, used with kind permission
RF
KNX-RF has the same lower layers as wireless M-Bus KNX RF
868 MHz, multiple channels New version of standard just released Improvement in battery lifetime and performance improvement in noisy environment
Radiocrafts AS
ZigBee basics
Short range radio based on IEEE 802.15.4 2.4 GHz Mesh radio Limited to 10 mW/MHz in Europe by EN 300 328
ZigBee Smart Energy : Preferred solution in US. for Smart Energy HAN
Certificate based public key exchange to achieve final link key Utilizes a Certificate Authority for the device keys Process has been independently audited and approved by Carnegie-Mellon
6LoWPAN
Standardized through IETF IPv6 packets over Low power Wireless Personal Area Network Compression, fragmentation++ ROLL (Routing Over Low power and Lossy networks ) Radiocrafts is working with 6LoWPAN leader Sensinode
RC2400/RC2400HP
Support ZigBee Smart Energy and ZigBee PRO 256 kB Flash Excellent range
102 dB system gain RC2400 110 dB system gain RC2400HP(European setup)
FW options
ZigBee Network Module
Include precompiled ZigBee PRO stack UART/SPI to external processor
RC2400-ZNM
MCU
Bill of material
Lowest TCO
New!
KNX-RF
New!
ZigBee
Customer specific
Questions?