Documentos de Académico
Documentos de Profesional
Documentos de Cultura
PAR05_Tarea. Por Diego Armando Navarro Rodríguez G.ASIR IES PABLO SERRANO
CAMBIO LA X POR MI CODIGO DE ALUMNO (45) YA EN LOS ENUNCIADOS.
Donde se hace referencias a X hay que sustituirlo por el número asignado para la
realización de las tareas. La siguiente tabla muestra opciones de configuración para
el router.
Se pide crear varias VLAN, definir enrutamiento entre VLAN y probar la conectividad.
4. Guarda la configuración.
Switch45#copy running-config startup-config
Destination filename [startup-config]?
Building configuration...
[OK]
PAR05_Tarea. Configuración de redes virtuales.
Switch45#show running-config
PAR05_Tarea. Configuración de redes virtuales.
3. Configura el switch para colocar las interfaces Fa0/1 a Fa0/4 en VLAN 10.
Switch45(config)#interface range fastethernet 0/1 - 4
Switch45(config-if-range)#switchport mode access
Switch45(config-if-range)#switchport access vlan 10
Switch45(config-if-range)#exit
4. Configura el switch para colocar las interfaces Fa0/5 a Fa0/8 en VLAN 20.
Switch45(config)#interface range fastethernet 0/5 - 8
Switch45(config-if-range)#switchport mode access
Switch45(config-if-range)#switchport access vlan 20
Switch45(config-if-range)#exit
Realiza captura de pantalla del resultado de ejecutar el comando show vlan brief
después de realizar las configuraciones del paso 3.
Paso 4. Comprobar la conectividad entre los equipos una vez realizados el paso 3. Se
piden capturas de pantalla de las siguientes pruebas de conectividad.
No hay conexión entre distintas vlan o red, solo existe conexión de momento entre
equipos que estan en la misma red o vlan
Router45(config)#interface fa0/0
Router45(config-if)#no shutdown
Router45(config-if)#
%LINK-5-CHANGED: Interface FastEthernet0/0, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/0, changed state to up
Router45(config-if)#interface fa0/0.1
Router45(config-subif)#
%LINK-5-CHANGED: Interface FastEthernet0/0.1, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/0.1, changed state to up
Router45(config-subif)#encapsulation dot1Q 1
Router45(config-subif)#ip address 192.45.1.254 255.255.255.0
Router45(config-subif)#exit
Router45(config)#interface fa0/0.10
Router45(config-subif)#
%LINK-5-CHANGED: Interface FastEthernet0/0.10, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/0.10, changed state to up
PAR05_Tarea. Configuración de redes virtuales.
Router45(config-subif)#encapsulation dot1Q 10
Router45(config-subif)#ip address 192.45.10.254 255.255.255.0
Router45(config-subif)#exit
Router45(config)#interface fa0/0.20
Router45(config-subif)#
%LINK-5-CHANGED: Interface FastEthernet0/0.20, changed state to up
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/0.20, changed state to up
Router45(config-subif)#encapsulation dot1Q 20
Router45(config-subif)#ip address 192.45.20.254 255.255.255.0
Router45(config-subif)#end
Router45#
%SYS-5-CONFIG_I: Configured from console by console
Switch45>enable
Switch45#config terminal
Enter configuration commands, one per line. End with CNTL/Z.
Switch45(config)#int fa0/24
Switch45(config-if)#switchport mode trunk
Switch45(config-if)#
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/24, changed state to
down
%LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/24, changed state to up
Switch45(config-if)#exit
Switch45(config)#
Switch45#show interfaces trunk
Switch45#show running-config
PAR05_Tarea. Configuración de redes virtuales.
Paso 7. Comprobar la conectividad entre los equipos una vez realizados los pasos 5 y
6. Se piden capturas de pantalla de las siguientes pruebas de conectividad.
Hay ping entre todas las maquinas gracias al haber enrutado los enlaces
troncales entre Switch y Router.
PAR05_Tarea. Configuración de redes virtuales.
Criterios de corrección