Está en la página 1de 66

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws.

f you acquired this


document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 1 of 66




Honda Securty, Remote Start, Keyess Entry & Navgaton
Wre Coors Verson 4.2









PLEASE NOTE

The information contained is accurate to the best of our knowledge. 12 Volt Resource LLC
makes no representation or warranty with respect to the information contained in this
document including its accuracy or completeness. 12 Volt Resource LLC disclaims all
liability or responsibility for errors or omissions therein or any decision made by the
recipient in reliance thereon.

nstallations should be attempted by experienced installers only. Proper installation
remains the responsibility of the installer. t is the installer's responsibility to test and verify
all circuitry with the proper test equipment prior to installation.


Additional nformation:

This information is sorted alphabetically by vehicle model. f there are multiple
years for a particular vehicle model, then the oldest year comes first.

The installation notes referenced below and the full installation guide are located
in the nstall nstructions & Notes folder on this CD-ROM.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 66


Make: Model: Year:
Honda Accord 1979-1985


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL OR DSTRBUTOR *
Parking Lights: RED/BLACK (+) AT LGHT SWTCH
Headlights: RED/WHTE (LO) OR RED/BLUE (H) (+) HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some 1985 Models Are Port Fuel njection, Rest Are Carburated.

Honda Accord 1979-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) BELOW CON TRAY
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK PANEL **
Power Unlock: GREEN/RED DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) BELOW CON TRAY

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 66

Make: Model: Year:
Honda Accord 1986-1989


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL (AUTOMATC TRANSMSSON) *
Parking Lights: RED/BLACK OR RED (+) LGHT SWTCH OR AT FUSE BOX
Headlights: NOT RECOMMENDED - POP-UP MOTORS ARE SEPARATE
CRCUT
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Electronic Fuel njection Models Only. Rest Are Carburated Or Throttle Body njection.

Honda Accord 1986-1989

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE AND
WHTE/BLACK
GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER KCK PANEL OR DOME LGHT
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK PANEL **
Power Unlock: GREEN/RED DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) DRVER KCK PANEL OR DOME LGHT

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 66

Make: Model: Year:
Honda Accord 1990-1993


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS (HEATER)
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH,BRACKET ABOVE PEDAL
BRACKET
Tach Signal: BLUE AT DSTRBUTOR OR DASH FUSE BLOCK
Parking Lights: BLACK/RED (+) HEADLGHT SWTCH OR AT FUSE BOX
Headlights: BLUE/RED (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda Accord 1990-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE OR BLUE/WHTE (-) AT DS-ARM SWTCH
Dome
Lights/Superv:
BLACK/WHTE (-) BROWN CONNECTOR ABOVE FUSE
PANEL
OEM Horn: BLUE/RED OR GRAY (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE DRVER KCK PANEL, 2 PN PLUG TAPPED
Power Unlock: BLACK/RED TO HARNNESS ABOVE FUSE BOX *
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) BROWN CONNECTOR ABOVE FUSE
PANEL

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 66

Make: Model: Year:
Honda Accord 1994-1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT BRAKE LGHT SWTCH
Tach Signal: BLUE OR TAN/BLUE
TACH TEST CONN.-DRV ENG
COMFUNCTONMENT
Parking Lights: RED/BLACK (+) ABOVE DRV KCK-20 PN BLUE CONN PN
6
Headlights: RED/BLACK (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda Accord 1994-1995

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS(FUSED 50
AMP)
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE/SLVER (-
)
GRAY MOLEX TO RT. OF STEERNG
COLUMN
OEM Horn: LGHT GREEN/BLUE (-) N GNTON SWTCH HARNESS
Power Lock: BLACK/WHTE 2 PN PLUG, TAPED TO WRNG
Power Unlock: ORANGE HARNNESS ABOVE FUSE BOX *
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE/SLVER (-
)
GRAY MOLEX TO RT. OF STEERNG
COLUMN

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 66

Make: Model: Year:
Honda Accord 1996-1997


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE
TACH TEST CONN. ON PASS. STRUT
TOWER *
Parking Lights: RED/BLACK (+) 18 PN BLUE CONN. ABOVE FUSE BLOCK
Headlights: BLUE (-) (COUPE) OR BLUE/RED (-) (WAGON)BEHND DR. DASH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * BLUE Tach Wire Also Located n 18 Pin Blue Connector On Top Of Fuse Block n
Driver Kick Panel.

Honda Accord 1996-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: RED/YELLOW (-) AT ANT THEFT MOD. UNDER DRVER'S
SEAT
Dome
Lights/Superv:
BLACK/WHTE (-) 20 PN GRAY CONN. BEHND DR. DASH **
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE DRVER'S KCK PANEL ***
Power Unlock: ORANGE DRVER'S KCK PANEL ***
Trunk Release: N/A CABLE OPERATED
Alarm nput Wire: BLACK/WHTE (-) 20 PN GRAY CONN. BEHND DR. DASH **

NOTES: ** Door Trigger n Pin #5, Trunk Trigger n Pin #7 *** Door Lock Wires Found n Gray 3
Pin Connector (Gray 4 pin Conn. On Wagon) Above Fuse Block n Driver Kick Panel Taped To
Harness With Blue Tape. See Note #201 - Negative Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 66
Make: Model: Year:
Honda Accord 1998-2002


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS **
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL MODULE
Parking Lights: RED/BLACK AT FUSE BLOCK ON DRVER'S SDE
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This vehicle is equipped with a transponder immobilizer system; See nstallation Note
#144 - Bypassing Transponder Theft Systems.

Honda Accord 1998-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE NSDE OF DRVER'S DOOR
Dome
Lights/Superv:
BLACK/WHTE (-) 4 PN GREEN CONN. N PASS FUSE BOX
OEM Horn: BLUE/GREEN (-) N STEERNG COLUMN HARNESS
Power Lock: BLACK/BLUE (-) PASSENGER SDE FUSE BOX**
Power Unlock: ORANGE (-) PASSENGER SDE FUSE BOX**
Trunk Release: WHT/RED+ 18 PN GRAY CONN. ABOVE DRVER'S
KCK
Alarm nput Wire: BLACK/WHTE (-) 4 PN GREEN CONN. N PASS FUSE BOX

NOTES: ** See Note#201 Negative Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 66

Make: Model: Year:
Honda Accord 2003-2005


FUNCTON COLOR LOCATON
Start: Black/White gnition Switch Harness
gnition #1: Black/Yellow gnition Switch Harness*
gnition #2: Black/Red gnition Switch Harness
gnition #3: N/A
Accessory: White/Red gnition Switch Harness
Brake Light: White/Black At Brake Switch
Tach Signal: Blue/Red or Blue
On ECM/PCM in front of the transmission
tunnel.
Parking Lights: Red/Black Large white plug above fusebox
Headlights: No Color Available Please call with info
Diesel Glow Plug: N/A
Clutch Bypass Wire: No Color Available Please call with info

NOTES: * This vehicle has a transponder anti-theft system. Use a universal alarm bypass
module.

Honda Accord 2003-2005

FUNCTON COLOR LOCATON
Constant +12 Volts: White gnition Switch Harness
OEM Alarm Disarm: White (-) n drivers door module in door
Dome
Lights/Superv:
Green/Red Behind Fuse Box
OEM Horn: Green/Yellow Steering Column Harness
Power Lock: Pink/Black Green plug left side of fuse box***
Power Unlock: Pink/Blue Green plug left side of fuse box***
Trunk Release: Yellow/Green (+) Drivers kick panel harness
Alarm nput Wire: Green/Red Behind Fuse Box

NOTES: *** The door lock wires must be tested from the passenger switch. See Note#201
Negative Trigger Door Locks





This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 66
ACCORD 2006

KEY
T-
HARNES
S
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE
AND EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/RED (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) RED/BLACK (-)
@ HEADLGHT SWTCH
UNDER STEERNG COLUMN
COVER
PARKNG LGHTS ( + ) RED/BLACK (+)
@ TOP of FUSEBOX, LARGE
WHTE Plug
POWER LOCK PNK/BLACK (TYPE B)
@ MCU, GREEN Plug, Pin 25,
See NOTE *1
POWER UNLOCK PNK/BLUE (TYPE B)
@ MCU, GREEN Plug, Pin 9,
See NOTE *1
DOOR TRGGER See NOTE * 2 @ BACK of FUSE BOX
DOMELGHT SUPERVSON GREEN/RED (-)
@ BACK of FUSE BOX, LGHT
GREEN, 5-Pin Plug

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 10 of 66

TRUNK RELEASE YELLOW/GREEN (+)


N DRVERS KCK PANEL,
HARNESS to REAR of
VEHCLE
SLDNG POWER DOOR N/A
HORN GREEN/YELLOW (-) @ HORN SWTCH in COLUMN
TACH
Any wire NOT BLACK/WHTE
or BLACK
@ Any GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM BLACK/RED to WHTE (-)
@ DRVERS DOOR in DOOR
MODULE
ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 the MCU (Multiplex ntegrated Control Unit), is part of the underdash FUSE/RELAYBOX.
The plugs for the MCU Module are on the LEFT SDE EDGE of the RELAY/FUSE BOX. NOTE *2
the DRVERS DOOR is a GREEN (-) in the LGHT GREEN 16-Pin Plug, Pin 15, the PASSENGER
DOOR is a LGHT GREEN/RED (-) in the LGHT GREEN 14-Pin Plug, Pin 12, the DRVERS REAR
DOOR is a GREEN/YELLOW (-) in the LGHT GREEN 16-Pin Plug, Pin 14 and the PASSENGER
REAR DOOR is a GREEN/WHTE (-) in the LGHT GREEN 14-Pin Plug, Pin 13. When connecting to
an ALARM SYSTEM use all 4 Door Trigger wires and DODE SOLATE, to connect,


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 11 of 66

ACCORD HYBRID 2006

KEY
T-
HARNES
S
MMOBLZER
N/A HON-4 HONDA'S TRANSPONDER ANT-THEFT SYSTEM, and Extra gnition Key

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) @ GNTON HARNESS
STARTER BLACK/WHTE (+) @ GNTON HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) @ GNTON HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) @ GNTON HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/RED (+) @ GNTON HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) RED/BLACK (-)
@ HEADLGHT SWTCH under
Column Cover
PARKNG LGHTS ( + ) RED/BLACK (+)
@ TOP of FUSE BOX, Large
WHTE Plug
POWER LOCK PNK (TYPE B) See NOTE *2
@ MCU, GREEN Plug, Pin 25
See NOTE *1
POWER UNLOCK BLUE (TYPE B) See NOTE *2
@ MCU, GREEN Plug, Pin 9
See NOTE *1
DOOR TRGGER See NOTE *3 @ BACK of FUSE BOX
DOMELGHT SUPERVSON GREEN/RED (-)
@ BACK of FUSE BOX, LGHT
GREEN 5-Pin Plug
TRUNK RELEASE YELLOW/GREEN (+)
N DRVERS KCK PANEL,
HARNESS to REAR of
VEHCLE

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 66

SLDNG POWER DOOR N/A


HORN GREEN/YELLOW (+) @ HORN SWTCH
TACH BLUE/RED
@ PCM, GRAY 31 Pin
Connector E, Pin 23
WAT TO START LGHT N/A
BRAKE LGHT GREEN (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM BLACK/RED to WHTE (-)
N DRVERS DOOR at DOOR
MODULE
ANT-THEFT
HONDA'S TRANSPONDER
ANT-THEFT SYSTEM
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 The MCU (Multiiplex ntegrated Control Unit) is attached to the FUSE/RELAY BOX, the
Plugs for this unit are on the LEFT SDE of the FUSE BOX. NOTE *2 TEST the LOCK and UNLOCK
wires using the PASSENGER DOOR LOCK/UNLOCK Switch. NOTE *3 The DRVERS DOOR is a
LGHT GREEN (-) at the 16-Pin Plug, Pin 15 , the PASSENGER DOOR is a LGHT GREEN (-) in a
LGHT GREEN 14-Pin Plug, Pin 12, the DRVERS REAR DOOR is a PURPLE (-) in a LGHT GREEN
16-Pin Plug, Pin 14 and the PASSENGER REAR DOOR is a WHTE (-) in a LGHT GREEN 14-Pin
Plug, Pin 13. When connecting to an ALARM SYSTEM use all 4 wires and DODE SOLATE,

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 13 of 66

Make: Model: Year:
Honda Civic 1980-1983


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3:
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT BRAKE LGHT SWTCH
Tach Signal: BLUE AT COL *
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/WHTE (LO) OR RED/BLUE (H) AT BEAM SELECT SW. (+)
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine.

Honda Civic 1980-1983

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/BLACK ('80-81) GREEN/BLUE ('82-83) DRVER PN SW.(-)
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS (NO
RELAY)
Power Lock: ADD ACTUATOR N BOTH DOORS **
Power Unlock: ADD ACTUATOR N BOTH DOORS **
Trunk Release: RED/WHTE (+) AT RELEASE SWTCH
Alarm nput Wire: GREEN/BLACK ('80-81) GREEN/BLUE ('82-83) DRVER PN SW.(-)

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 14 of 66

Make: Model: Year:
Honda Civic 1984-1986


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL *
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/WHTE (LO) OR RED/BLUE (H) (+) AT LGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Electronic Fuel njection Models Only, Rest Are Carburated Or Throttle Body njection.

Honda Civic 1984-1986

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/BLACK OR GREEN/RED (-) AT PN SWTCH
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS **
Power Unlock: ADD ACTUATOR N BOTH DOORS **
Trunk Release: WHTE/GREEN (+) AT RELEASE SW. (WAGON ONLY)
Alarm nput Wire: GREEN/BLACK OR GREEN/RED (-) AT PN SWTCH

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 15 of 66

Make: Model: Year:
Honda Civic 1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/WHTE (LO) OR RED/BLUE (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda Civic 1987

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/BLACK OR GREEN/RED (-) AT PN SWTCH
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS *
Power Unlock: ADD ACTUATOR N BOTH DOORS *
Trunk Release: WHTE/GREEN (+) AT RELEASE SW. (WAGON ONLY)
Alarm nput Wire: GREEN/BLACK OR GREEN/RED (-) AT PN SWTCH

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 66

Make: Model: Year:
Honda Civic 1988-1991


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/GREEN (+) AT HEADLGHT SWTCH
Headlights: RED/YELLOW (LO) OR RED/BLUE (H) (+) AT LGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda Civic 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK AND WHTE/BLACK-GNTON SWTCH
HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/RED (-) WHTE CONNECTOR AT FUSE BOX
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE NSDE OF DRVER'S DOOR *
Power Unlock: GREEN/RED NSDE OF DRVER'S DOOR *
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) WHTE CONNECTOR AT FUSE BOX

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 66

Make: Model: Year:
Honda Civic 1992-1994


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) SWTCH ON BRAKE PEDAL BRACKET
Tach Signal: BLUE AT DSTRBUTOR OR TACH TEST CONN. *
Parking Lights: RED/BLACK (+) AT
GREEN
CONNECTOR UNDER DASH OR N
FUSEBOX
Headlights: RED/WHTE (LOW) RED/BLUE (H) AT HEADLGHT SWTCH (+)
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector (White 2 Pin) Found n Driver Rear Of Engine Compartment.
BLUE Tach Wire Also Found n Gray 14 Pin Connector On Top Of Fuse Block At Pin #3.

Honda Civic 1992-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/RED (-) DRVER KCK PANEL
OEM Horn: BLUE/RED OR GRAY (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE SWTCH OR DOOR LOCK CONTROL
Power Unlock: GREEN/RED UNT N DRVER DOOR **
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) DRVER KCK PANEL

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 66

Make: Model: Year:
Honda Civic 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/GREEN (+) AT BRAKE PEDAL BRACKET
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/GREEN (+) DRVER KCK PANEL BEHND FUSE
BOX
Headlights: RED/WHTE (+) DRVER KCK PANEL BEHND FUSE
BOX
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector Located On Passenger Rear Corner Of Engine Compartment.

Honda Civic 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AND GREEN/BLACK (+) AT SECURTY MODULE
Dome
Lights/Superv:
LGHT GREEN/RED (-) ABOVE DRV KCK 2 PN GRAY CONN.PN 2
OEM Horn: BLUE/GREEN (-) AT HORN RELAY
Power Lock: GREEN/WHTE GRAY 2 PN PLUG ABOVE FUSE BLOCK **
Power Unlock: GREEN/RED GRAY 2 PN PLUG ABOVE FUSE BLOCK **
Trunk Release: N/A
Alarm nput Wire: LGHT GREEN/RED (-) ABOVE DRV KCK 2 PN GRAY CONN.PN 2

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 66

Make: Model: Year:
Honda Civic 1996-2000


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/BLACK (+) 7 PN GRAY CONN. AT FUSE BLOCK
Headlights: RED (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector s A 2 Pin WHTE Connector Located On Driver Rear Of Engine
Compartment.

Honda Civic 1996-2000

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS **
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
L GREEN/RED (-) 14 PN GRAY CONN. N DR. KCK PANEL
OEM Horn: BLUE (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE 16 PN BLUE CONNECTOR
Power Unlock: GREEN/ORANGE TO LEFT OF FUSE BLOCK ***
Trunk Release: N/A
Alarm nput Wire: L GREEN/RED (-) 14 PN GRAY CONN. N DR. KCK PANEL

NOTES: ** WHTE Wire Changes To WHTE/BLACK At Base Of Steering Column. *** See Note
#201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 20 of 66

Make: Model: Year:
Honda Civic 2001-2003


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS **
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE
N 2-PN PLUG AT PASSENGER SDE OF
BATTERY
Parking Lights: RED/BLACK (+) AT BACK OF FUSE BOX
Headlights: BLUE/RED (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This Vehicle s Equipped With A Transponder Type Engine mmobilizer Theft System.
Use a universal alarm bypass module.

Honda Civic 2001-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
SEE NOTE BELOW
OEM Horn: ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: WHTE/BLUE (-) GRAY PLUG ABOVE DRVER'S KCK PANEL
Power Unlock: WHTE/GREEN (-) GRAY PLUG ABOVE DRVER'S KCK PANEL
Trunk Release: N/A
Alarm nput Wire: SEE NOTE BELOW

NOTES: ** The Driver's Door Trigger s Green (-), Front Passenger Door Trigger s Lt.
Green/Red (-), Rear Doors Trigger s Green/White (-). The Wires Are Found n The Alarm Plug n
A Green Plug Above The Driver's Kick Panel. See Note#201 Negative trigger door locks




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 21 of 66
CIVIC 2004 - 2005

KEY
T-
HARNES
S
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE
AND EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/RED (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-)
@ HEADLGHT SWTCH
UNDER STEERNG COLUMN
COVER
PARKNG LGHTS ( + ) RED/BLACK (+)
@ BACK OF FUSEBOX, TOP
MDDLE PLUG
POWER LOCK WHTE/BLUE (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK WHTE/GREEN (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER See NOTE *1
@ FACTORY ALARM PLUG,
See NOTE *3
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 22 of 66

HORN ORANGE (-)


@ STEERNG COLUMN
HARNESS
TACH BLUE
@ TACH TEST CONNECTOR,
See NOTE *2
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 THE DRVERS DOOR TRGGER S GREEN (-),THE FRONT PASSENGER DOOR
TRGGER S LGHT GREEN/RED (-),AND THE REAR DOOR TRGGERS ARE GREEN/WHTE (-
).WHEN CONNECTNG TO AN ALARM SYSTEM. USE ALL 3 DOOR TRGGER WRES AND
DODE SOLATE, TO CONNECT, NOTE *2 THE TACH TEST CONNECTOR S A 2 PN
CONNECTOR TO THE PASSENGER SDE OF THE BATTERY. NOTE *3 THE FACTORY ALARM
PLUG S LOCATED ABOVE THE DRVERS KCK PANEL N A GREEN PLUG.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 23 of 66

CIVIC 2006


FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLUE (+) GNTON SWTCH HARNESS
GNTON 2
BLACK/RED (+) GNTON
SWTCH HARNESS

GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
Accessory 1 ORANGE (+)
GNTON SWTCH HARNESS

ACCESSORY/HEATER
BLOWER 2
RED (+) GN TON SWTCH
HARNESS
RED (+) GN TON SWTCH
HARNESS
KEYSENSE
PNK (-) GNTON SWTCH
HARNESS

PARKNG LGHTS
RED (+) FUSE BOX LEFT
SDE OF DRVERS DASH
RED (+) FUSE BOX LEFT
SDE OF DRVERS DASH
POWER LOCK BLUE (-)
DRVERS DOOR HARNESS
(CAN ALSO BE GREEN
DEPENDNG ON WHERE YOU
FND THE WRE)
POWER UNLOCK GREY (-) DRVERS DOOR HARNESS
DOOR TRGGER PNK (-)
BLUE PLUG AT DRVERS
DASH FUSE BOX
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE BLUE (-)
FUSE BOX LEFT SDE OF
DRVERS DASH
SLDNG POWER DOOR N/A
HORN ORANGE (-)
@ STEERNG COLUMN
HARNESS
TACH BROWN (AC) AT COL

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 24 of 66

WAT TO START LGHT N/A


BRAKE LGHT GREEN AT SWTCH
FACTORY ALARM DSARM BROWN (-) DRVERS KCK
ANT-THEFT
THE KEY SENDS AN RF
SGNAL TO THE BCM
MODULE THROUGH AN
ANTENNA LOCATED AROUND
THE GNTON CYLNDER



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 25 of 66

Make: Model: Year:
Honda Civic - DeI SoI 1993-1994


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNES
Brake Light: GREEN/WHTE (+) SWTCH ON BRACKET ABOVE BRAKE
PEDAL
Tach Signal: BLUE AT DSTRBUTOR ASSEMBLY
Parking Lights: RED/BLACK (+)
STEERNG
COLUMN HARNESS OR NUM. TWO N
FUSE BX
Headlights: RED/WHTE (LOW) RED/BLUE (H) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda Civic - DeI SoI 1993-1994

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE (CHANGES TO WHTE/BLACK) GNTON SWTCH
HARNESS
OEM Alarm Disarm: BLUE/WHTE DSARM SWTCH/OPENNG CRCUT
DSARMS
Dome
Lights/Superv:
GREEN/RED (-) DRVER KCK PANEL OR CONTROL UNT
OEM Horn: BLUE/GREEN OR GRAY (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS *
Power Unlock: ADD ACTUATOR N BOTH DOORS *
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) DRVER KCK PANEL OR CONTROL UNT

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 26 of 66

Make: Model: Year:
Honda Civic - DeI SoI 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/GREEN (+) AT BRAKE PEDAL BRACKET
Tach Signal: BLUE 2 PN TACH TEST CONNECTOR *
Parking Lights: RED/GREEN (+) DRVER KCK PANEL BEHND FUSE
BOX
Headlights: RED/WHTE (+) DRVER KCK PANEL BEHND FUSE
BOX
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector Located On Passenger Rear Of Engine Compartment.

Honda Civic - DeI SoI 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AND GREEN/BLACK (+) @ SECURTY
CON.MODULE
Dome
Lights/Superv:
LGHT GREEN/RED (-) ABOVE DRV KCK 2 PN GRAY CONN.PN 2
OEM Horn: GRAY (-) GNTON SW. HARNESS - YELLOW 6 PN CONN. - PN 1
Power Lock: GREEN/WHTE GRAY 2 PN PLUG ABOVE HOOD RELEASE
**
Power Unlock: GREEN/RED GRAY 2 PN PLUG ABOVE HOOD RELEASE
**
Trunk Release: N/A
Alarm nput Wire: LGHT GREEN/RED (-) ABOVE DRV KCK 2 PN GRAY CONN.PN 2

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 66
Make: Model: Year:
Honda Civic - DeI SoI 1996-1998


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT TACH TEST CONNECTOR *
Parking Lights: RED/GREEN (+) AT HEADLGHT SWTCH
Headlights: RED/WHTE (LO) & RED/BLUE (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector Located On Driver Strut Tower.

Honda Civic - DeI SoI 1996-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
GREEN/RED (-) AT PASSENGER PN SWTCH
OEM Horn: BLUE/GREEN (-) STEERNG COLUMN HARNESS
Power Lock: N/A MUST ADD ACTUATOR TO DRVER DOOR
**
Power Unlock: N/A MUST ADD ACTUATOR TO DRVER DOOR
**
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) AT PASSENGER PN SWTCH

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 28 of 66

Make: Model: Year:
Honda Civic - Hybrid 2003


FUNCTON COLOR LOCATON
Start: Black/White gnition Switch Harness*
gnition #1: Black/Yellow gnition Switch Harness
gnition #2: White/Red gnition Switch Harness
gnition #3: N/A
Accessory: Black/Red gnition Switch Harness
Brake Light: White/Black At Brake Switch
Tach Signal: Blue 2 pin connector near battery
Parking Lights: Red/Black (+) 12 pin connector on back of fuse box
Headlights: Blue/Red(-) At Headlight Switch
Diesel Glow Plug: N/A
Clutch Bypass Wire: No Color Available Please call with information

NOTES: *Equipped with Trasnsponder Ant-Theft System as standard equipment. Use Universal
Alarm Bypass Module to bypass this anti-theft system. **OEM alarm must see key sens wire and
ignition to be disabled. Armed by OEM remote only.

Honda Civic - Hybrid 2003

FUNCTON COLOR LOCATON
Constant +12 Volts: White gnition Switch Harness
OEM Alarm Disarm: N/A **
Dome
Lights/Superv:
Green/Red (-) Under Dash at fuse/Relay Box
OEM Horn: Orange (-) At Steering Column Harness
Power Lock: White/Blue 20 pin Connector **
Power Unlock: White/Green n Drivers Kick Panel
Trunk Release: N/A *
Alarm nput Wire: Green/Red (-) Under Dash at fuse/Relay Box

NOTES: *Trunk Pin switch is a red wire, located at the green 18 pin connector above the drivers
kick panel. **20 pin connector in Drivers Kick Panel. Negative Lock System. See Note #202
Negative Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 66

Make: Model: Year:
Honda CR-V 1997-2001


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW (Blower Motor) GNTON SWTHC HARNESS
gnition #3:
Accessory: WHTE/BLACK (Radio) GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH OR 20 PN GRAY N LOWER
KCK
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) GREEN 20 PN CONN. ABOVE FUSE BOX
Headlights: RED/WHTE (+) AT 7 PN CONN. ABOVE FUSE BOX
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda CR-V 1997-2001

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: See Note **
Dome
Lights/Superv:
LT. GREEN/RED (-) 20 PN OEM ALARM CONN. LOWER DR.
KCK
OEM Horn: GRAY 20 PN OEM ALARM CONN. LOWER DR.
KCK
Power Lock: GREEN/WHTE (-) 20 PN ALARM CONN. LOWER DR. KCK *
Power Unlock: GREEN/ORANGE (-) 20 PN ALARM CONN. LOWER DR. KCK *
Trunk Release: YELLOW (+) AT RELEASE SWTCH
Alarm nput Wire: LT. GREEN/RED (-) 20 PN OEM ALARM CONN. LOWER DR.
KCK

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram. ** Factory Alarm s n The
Driver's Kick Panel. Use A Relay To Open The Yellow gnition Sense Wire Of The Alarm.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 30 of 66

Make: Model: Year:
Honda CR-V 2002-2003


FUNCTON COLOR LOCATON
Start: Black/White (+) gnition switch harness
gnition #1: Black/Yellow (+) gnition switch harness*
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Black/Red (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Blue (AC) Test connector**
Parking Lights: Red/Black (+) Drivers kick panel
Headlights:
Diesel Glow Plug: N/A
Clutch Bypass Wire:

NOTES: *This vehicle is equipped with a transponder immobilizer system. Use a universal alarm
bypass module. **The test connector is next to the battery.

Honda CR-V 2002-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm:
Dome
Lights/Superv:

OEM Horn: Orange (-) Steering column harness
Power Lock: White/Blue (-) Gray plug above driver kick panel**
Power Unlock: White/Green (-) Gray plug above driver kick panel**
Trunk Release: Black/Yellow (-) Drivers kick panel harness
Alarm nput Wire:

NOTES: ** See Note #201 Negative Trigger Door Locks



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 66

Honda CR-V 2004-2006

FUNCTON COLOR LOCATON
Start: Black/White (+) gnition switch harness
gnition #1: Black/Yellow (+) gnition switch harness*
gnition #2: Black/Red (+) gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: White/Red(+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Blue (AC) Test connector**
Parking Lights: Red/Black (+) Drivers kick panel
Headlights:
Diesel Glow
Plug:
N/A
Clutch Bypass
Wire:

Notes: *This vehicle is equipped with a transponder immobilizer system. Use a universal alarm bypass
module. **The test connector is next to the battery.

Honda CR-V 2004-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
White (+) gnition switch harness
OEM Alarm
Disarm:

Dome
Lights/Superv:
Green (-) See note below**
OEM Horn: Orange (-) Steering column harness
Power Lock: White/Blue (-) Gray plug above driver kick panel***
Power Unlock: White/Green (-) Gray plug above driver kick panel***
Trunk Release: Black/Yellow (-) Drivers kick panel harness
Alarm nput
Wire:
Green (-) See note below**
Notes:
**The drivers door trigger is green, and lt green/red for all the other doors. We recommend to diode
isolate each wire. *** See Note #201 Negative Trigger Door Locks.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 32 of 66

Make: Model: Year:
Honda CRX 1985-1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: RED/WHTE (LO) OR RED/BLUE (H) (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda CRX 1985-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE AND WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/RED (-) AT ANY PN SWTCH
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS *
Power Unlock: ADD ACTUATOR N BOTH DOORS *
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) AT ANY PN SWTCH

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 33 of 66

Make: Model: Year:
Honda CRX 1988-1991


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/GREEN (+) AT HEADLGHT SWTCH
Headlights: RED/BLUE (LO) OR RED/YELLOW (H) (+) AT LGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda CRX 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK AND WHTE/BLACK - GNTON SWTCH
HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
GREEN/RED (-) AT PN SWTCH OR DRVER KCK PAN.
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS *
Power Unlock: ADD ACTUATOR N BOTH DOORS *
Trunk Release: N/A
Alarm nput Wire: GREEN/RED (-) AT PN SWTCH OR DRVER KCK PAN.

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 34 of 66

Make: Model: Year:
Honda EIement 2003


FUNCTON COLOR LOCATON
Start: Black/White (+) gnition switch harness
gnition #1: Black/Yellow (+) gnition switch harness*
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: Black/Red (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Blue (AC) Test connector**
Parking Lights: Red/Black (+) Drivers kick panel
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: *This vehicle is equipped with a transponder immobilizer system. Use a universal alarm
bypass module. **The test connector is next to the battery.

Honda EIement 2003

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm:
Dome
Lights/Superv:

OEM Horn: Orange (-) Steering column harness
Power Lock: White/Blue (-) Gray plug above driver kick panel**
Power Unlock: White/Green (-) Gray plug above driver kick panel
Trunk Release: N/A
Alarm nput Wire:

NOTES: ** See Note #201 Negative Trigger Door Locks




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 35 of 66

ELEMENT 2004 -2006



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE
AND EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
BLACK/RED (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/RED (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-)
@ FACTORY ALARM Plug,
See NOTE *2
PARKNG LGHTS ( + ) RED/BLACK (+) @ BACK OF FUSEBOX
POWER LOCK WHTE/BLUE (TYPE B)
N DRVER KCK PANEL at
DOOR HARNESS
POWER UNLOCK WHTE/GREEN (TYPE B)
N DRVERS KCK PANEL, at
DOOR HARNESS
DOOR TRGGER
GREEN (-) and GRAY/BLACK (-
) Use both, See NOTE *1
@ FACTORY ALARM PLUG,
See NOTE *2
DOMELGHT SUPERVSON GREEN/RED (-) BACK OF FUSEBOX
TRUNK RELEASE N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 66

SLDNG POWER DOOR N/A


HORN ORANGE (-)
@ STEERNG COLUMN
HARNESS
TACH BLUE
@ ECM/PCM, BEHND
GLOVEBOX, PN E25
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM N/A
ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 THE DRVERS DOOR TRGGER S GREEN (-) AND THE PASSENGER DOOR TRGGER
S GRAY/BLACK (-). WHEN CONNECTNG TO AN ALARM SYSTEM, USE BOTH DOOR TRGGER
WRES AND DODE SOLATE, NOTE *2 THE FACTORY ALARM PLUG S LOCATED LEFT OF
THE STEERNG COLUMN N A GREEN PLUG.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 66

FIT 2007

KE
Y
T-
HARNE
SS
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, Requires an Extra Programmed
gnition Key and 791 Bypass Module

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+)
@ GNTON SWTCH
HARNESS
STARTER BLACK/WHTE (+)
@ GNTON SWTCH
HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+)
@ GNTON SWTCH
HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW/BLACK (+)
@ GNTON SWTCH
HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/RED (+)
@ GNTON SWTCH
HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-)
@ HEADLGHT SWTCH or
GCM, 40-Pin Plug, Pin 19 See
NOTE *1
PARKNG LGHTS ( + ) RED/BLACK (+)
@ FUSE BOX, 14-Pin Plug, Pin
5
POWER LOCK WHTE/GREEN (TYPE B)
in DRVERS KCK PANEL or
GCM, 40-Pin Plug, Pin 9, See
NOTE *1
POWER UNLOCK WHTE/BLUE (TYPE B)
in DRVERS KCK PANEL or
GCM, 40-Pin Plug, Pin 10, See
NOTE *1

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 38 of 66

DOOR TRGGER
GREEN (-) (Drivers Door),
PURPLE (-) (Passenger Door)
Use both
in EACH KCK PANEL, or GCM,
20-Pin Plug, Pins 13 and 14
See NOTE *1
DOMELGHT SUPERVSON GREEN/RED (-)
@ FUSE BOX or GCM, 20-Pin
Plug, Pin 12 See NOTE *1
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A
HORN ORANGE (-)
@ HORN SWTCH or GCM, 14-
Pin Plug, Pin 8 See NOTE *1
TACH GREEN/ORANGE @ FUSE BOX, 6-Pin Plug, Pin 2
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL or FUSE BOX, 14-Pin
Plug, Pin 4
FACTORY ALARM DSARM WHTE (-) See NOTE *3
in DRVERS KCK PANEL or
SCU, 20-Pin Plug, Pin 3 See
NOTE *2
ANT-THEFT
HONDA'S TRANSPONDER
ANT-THEFT System
@ GNTON SWTCH
TUMBLER

EXTRA NFORMATON
NOTE *1 the GCM (Gauge Control Module) is located inside the nstrument Cluster on this vehicle.
NOTE *2 the SCU (Security Control Unit) is located under the Drivers Side of the Dash. NOTE *3
Text this wire while turning the Key in the Drivers Door Key Cylinder.

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 39 of 66

INSIGHT 2000 -2003



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE
AND EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/BLACK (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-)
@ HEADLGHT SWTCH or
KEYLESS DOORLOCK UNT
See NOTE *1
PARKNG LGHTS ( + ) RED/WHTE (+)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
POWER LOCK WHTE/BLUE (TYPE B)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
POWER UNLOCK WHTE/GREEN (TYPE B)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
DOOR TRGGER LGHT GREEN/RED (-)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
DOMELGHT SUPERVSON TURNS ON with UNLOCK
TRUNK RELEASE BLUE (+) @ HATCH RELEASE SWTCH

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 40 of 66

SLDNG POWER DOOR N/A


HORN ORANGE (-)
@ STEERNG COLUMN
HARNESS
TACH BLUE
@ TEST CONNECTOR, See
NOTE *2
WAT TO START LGHT N/A
BRAKE GREEN/WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY!!!

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 THE KEYLESS DOORLOCK UNT S LOCATED BEHND THE CONBOX ON THE
DRVERS SDE DASH. NOTE *2 THE TACH TEST CONNECTOR S LOCATED ABOVE THE
BRAKE MASTERCYLNDER UNDER THE HOOD.




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 41 of 66

INSIGHT 2004 - 2006



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE
AND EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-)
@ HEADLGHT SWTCH or
KEYLESS DOORLOCK UNT
See NOTE *1
PARKNG LGHTS ( + ) RED/WHTE (+)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
POWER LOCK WHTE/BLUE (TYPE B)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
POWER UNLOCK WHTE/GREEN (TYPE B)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
DOOR TRGGER LGHT GREEN/RED (-)
@ KEYLESS DOORLOCK
UNT, See NOTE *1
DOMELGHT SUPERVSON GREEN/RED (-)
@ KEYLESS DOORLOCK
UNT, See NOTE *1

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 42 of 66

TRUNK RELEASE BLUE/BLACK (+) @ HATCH RELEASE SWTCH


SLDNG POWER DOOR N/A
HORN ORANGE (-)
@ STEERNG COLUMN
HARNESS
TACH BLUE
@ TEST CONNECTOR, See
NOTE *2
WAT TO START LGHT N/A
BRAKE GREEN/WHTE (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
DSARMS with FACTORY
REMOTE ONLY!!!

ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 THE KEYLESS DOORLOCK UNT S LOCATED BEHND THE CONBOX ON THE
DRVERS SDE DASH. NOTE *2 THE TACH TEST CONNECTOR S LOCATED ABOVE THE
BRAKE MASTERCYLNDER UNDER THE HOOD.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 43 of 66

Make: Model: Year:
Honda Odyssey 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT BRAKE PEDAL SWTCH
Tach Signal: BLUE
5 PN BLUE CONN.ON BACK OF FUSE BOX
*
Parking Lights: RED/BLACK (+) AT HEADLGHT SWTCH
Headlights: BLUE (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * BLUE Tach Wire Can Also Be Found At 2 Pin White Tach Test Connector n
Passenger Rear Corner Of Engine Compartment To Right Of Fuse/Relay Box.

Honda Odyssey 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: WHTE/RED (-) DRVER KCK N GRAY 4 PN CONNECTOR
Dome
Lights/Superv:
WHTE/BLACK (-) @ 20 PN GRAY CONN-RT OF STEERNG
COL
OEM Horn: LGHT GREEN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE (-) DRVER KCK PANEL N GRAY CONECTOR
**
Power Unlock: ORANGE DRVER KCK PANEL N GRAY CONECTOR
**
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK (-) @ 20 PN GRAY CONN-RT OF STEERNG
COL

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 44 of 66
Make: Model: Year:
Honda Odyssey 1996-1998


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT DSTRBUTOR OR TACH TEST CONN. **
Parking Lights: RED/BLACK (+) 18 PN BLUE CONN. AT FUSE BLOCK
Headlights: BLUE (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 1998+ Models May Be Equipped With a Transponder mmobilizer System; See
nstallation Note #144 - Bypassing Transponder Theft Systems. ** Distributor Located On
Passenger Front Of Engine. Tach Test Connector (2 Pin WHTE Plug) Located On Passenger
Strut Tower.

Honda Odyssey 1996-1998

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A DSARMS THRU OEM REMOTE OR VALET
Dome
Lights/Superv:
WHTE/BLACK (-) 20 PN GRAY CONN. BEHND DR. DASH ***
OEM Horn: L GREEN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE 4 PN GRAY CONN. HGH N DR KCK ****
Power Unlock: ORANGE 4 PN GRAY CONN. HGH N DR KCK ****
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK (-) 20 PN GRAY CONN. BEHND DR. DASH ***

NOTES: *** 20 Pin GRAY Connector Located Behind Driver Dash To Right Of Steering Column.
*** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 45 of 66

Make: Model: Year:
Honda Odyssey 1999-2002


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE
N A 2-PN CONNECTOR ABOVE MASTER
CYLNDER
Parking Lights: RED/BLACK (+) N A 10-PN PLUG AT BOTTOM OF FUSE
PANEL
Headlights: BLUE/RED (-) STEERNG COLUMN HARNESS
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: * This vehicle is equipped with a transponder immobilizer system; See nstallation Note
#144 - Bypassing Transponder Theft Systems.

Honda Odyssey 1999-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AT DOOR MODULE NSDE OF DRVER'S
DOOR **
Dome
Lights/Superv:
BLACK/WHTE (-) AT DOMELGHT ON/OFF SWTCH
OEM Horn: LT. GREEN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE (-) N A GREEN 6-PN CONNECTOR BELOW
FUSE PANEL **
Power Unlock: GREEN/RED (-) N A GREEN 6-PN CONNECTOR BELOW
FUSE PANEL **
Trunk Release:
Alarm nput Wire: BLACK/WHTE (-) AT DOMELGHT ON/OFF SWTCH

NOTES: ** See nstallation Note #201 - Negative Pulse Door Locks Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 46 of 66

Make: Model: Year:
Honda Odyssey 2003-2004


FUNCTON COLOR LOCATON
Start: Black/White (+) gnition switch harness
gnition #1: Black/Yellow (+) gnition switch harness*
gnition #2: Yellow (+) gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: White/Black (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Blue (AC) Tach test connector**
Parking Lights: Red/Black (+) 10 pin harness at the bottom of the fuse box
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle is equipped with a Transponder Anti-Theft system. Use a universal alarm
bypass module. You may also use a Vehicle Specifit Bypass Module. **The tach test connector
is a 2 pin plug above the brake master cylinder.

Honda Odyssey 2003-2004

FUNCTON COLOR LOCATON
Constant +12 Volts: White (+) gnition switch harness
OEM Alarm Disarm: Blue (-) Drivers door module inside the door
Dome
Lights/Superv:
Lt.Green (-) Domelight on/off switch
OEM Horn: Lt.Green/Blue (-) Steering column harness
Power Lock: Black/White (-) Green plug at the bottom of the fuse box**
Power Unlock: Gree/Red (-) Green plug at the bottom of the fuse box
Trunk Release: N/A
Alarm nput Wire: Lt.Green (-) Domelight on/off switch

NOTES: **See Note #201 Negative Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 47 of 66

Honda Odyssey 2005-2006

FUNCTON COLOR LOCATON
Start: Black/White (+) gnition switch harness
gnition #1: Black/Yellow (+) gnition switch harness*
gnition #2: Black/Red(+) gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: White/Red(+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Not Yellow/Black(AC) Any Fuel injector
Parking Lights: Red/Black (+) 17 pin harness at the bottom of the fuse box
Headlights: N/A
Diesel Glow
Plug:
N/A
Clutch Bypass
Wire:
N/A
Notes: *This vehicle is equipped with a Transponder Anti-Theft system. Use a universal alarm bypass
module. **The tach test connector is a 2 pin plug above the brake master cylinder.

Honda Odyssey 2005-2006

FUNCTON COLOR LOCATON
Constant +12
Volts:
White (+) gnition switch harness
OEM Alarm
Disarm:
Black/red or White Drivers door module inside the
door

Dome
Lights/Superv:
Black/Red (-) Domelight on/off switch
OEM Horn: Lt.Green/Yellow (-) Steering column harness
Power Lock: Not available
Power Unlock: Not available
Trunk Release: N/A
Alarm nput Wire: Black/Red (-) Domelight on/off switch
Notes: **See Note #201 Negative Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 48 of 66

Make: Model: Year:
Honda Passport 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE OR BLACK/RED - GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: BLUE OR BLACK GNTON SWTCH HARNESS
Brake Light: RED (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE (2.6L) OR BLACK/RED (3.2L) SEE NOTES *
Parking Lights: GREEN/RED (+) AT HEADLGHT SW.OR DRVER KCK
Headlights: RED/BLUE (-) AT HEADLGHT SWTCH OR AT RELAY
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * 2.6L Engine BLUE Tach Wire Located On Passenger Side Of Engine Compartment
(Single BLUE Wire With Female Bullet Terminal n Clear nsulator). 3.2L Engine BLACK/RED
Tach Wire Located At Black 6 Pin Plug On Electronic gnition Module.

Honda Passport 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: BLACK GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
RED/GREEN OR BLACK
(-)
2 WAY WHT CONN.BEHND DRV FRT
SPEAKER
OEM Horn: BLACK/ORANGE (-) 13 WAY WHTE CONN.ABOVE PARK
BRAKE
Power Lock: ADD ACTUATOR ADD ACTUATOR TO DRVER DOOR **
Power Unlock: ADD ACTUATOR ADD ACTUATOR TO DRVER DOOR **
Trunk Release: RED/BLUE (+) AT TALGATE GLASS RELEASE SWTCH
Alarm nput Wire: RED/GREEN OR BLACK
(-)
2 WAY WHT CONN.BEHND DRV FRT
SPEAKER

NOTES: * See Note #204 - Adding Actuator Door Lock Diagram. 1995 1/2 Passport Door Locks:
L GREEN/RED (Lock) & RED/WHTE (Unlock) n Driver Kick Panel. See Note #201 - Negative
Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 49 of 66

Make: Model: Year:
Honda Passport 1995.5


FUNCTON COLOR LOCATON
Start: WHTE/BLUE GNTON SWTHC HARNESS
gnition #1: BLACK/RED GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLUE/BLACK GNTON SWTCH HARNESS
Brake Light: RED (+) AT SWTCH ABOVE BRAKE PEDAL **
Tach Signal: BLACK/RED AT POWERTRAN CONTROL MODULE *
Parking Lights: GREEN/RED (+) 20 PN CONNECTOR N DR. KCK PANEL
Headlights: RED/BLUE (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module Located n Front Of Center Console. ** RED (+) Wire Also
Located n 20 Pin Connector n Driver Kick Panel.

Honda Passport 1995.5

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK & WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
RED/GREEN (-) 2 PN CONNECTOR N DR. KCK PANEL ***
OEM Horn: ORANGE/BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L GREEN/RED WHTE 16 PN CONN. N DR. KCK ****
Power Unlock: RED/WHTE WHTE 16 PN CONN. N DR. KCK ****
Trunk Release: N/A
Alarm nput Wire: RED/GREEN (-) 2 PN CONNECTOR N DR. KCK PANEL ***

NOTES: *** 2 Pin Connector Located High n Driver Kick Panel At Base Of Driver ""A"" Pillar. ****
See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 50 of 66

Make: Model: Year:
Honda Passport 1996-1997


FUNCTON COLOR LOCATON
Start: WHTE/BLUE GNTON SWTHC HARNESS
gnition #1: BLACK/RED GNTON SWTCH HARNESS
gnition #2: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLUE/BLACK GNTON SWTCH HARNESS
Brake Light: RED (+) AT SWTCH ABOVE BRAKE PEDAL **
Tach Signal: BLACK/RED AT POWERTRAN CONTROL MODULE *
Parking Lights: GREEN/RED (+) 20 PN CONNECTOR N DR. KCK PANEL
Headlights: RED/BLUE (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Powertrain Control Module Located n Front Of Center Console. ** RED (+) Wire Also
Located n 20 Pin Connector n Driver Kick Panel.

Honda Passport 1996-1997

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK & WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
RED/GREEN (-) 2 PN CONNECTOR N DR. KCK PANEL ***
OEM Horn: ORANGE/BLACK (-) STEERNG COLUMN HARNESS
Power Lock: L GREEN/RED WHTE 16 PN CONN. N DR. KCK ****
Power Unlock: RED/WHTE WHTE 16 PN CONN. N DR. KCK ****
Trunk Release: N/A
Alarm nput Wire: RED/GREEN (-) 2 PN CONNECTOR N DR. KCK PANEL ***

NOTES: *** 2 Pin Connector Located High n Driver Kick Panel At Base Of Driver ""A"" Pillar. ****
See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 51 of 66

Make: Model: Year:
Honda Passport 1998-2001


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: BLACK/RED GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BLUE GNTON SWTCH HARNESS
Brake Light: RED AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLACK/RED AT COL #1 ON DRVER FRONT ENGNE *
Parking Lights: GREEN/RED (+) AT FUSE BOX
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Wire Can Also Be Found At PCM Located At Front Of Center Console.

Honda Passport 1998-2001

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK & WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: YELLOW/BLUE (-) WHTE PLUG N DRVER'S KCK PANEL
Dome
Lights/Superv:
RED/GREEN (-) DRVER'S KCK PANEL
OEM Horn: DK. GREEN (-) N STEERNG COLUMN HARNESS
Power Lock: LT. GREEN/RED (-) DRVER'S KCK PANEL **
Power Unlock: RED/DK. BLUE (-) DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: RED/GREEN (-) DRVER'S KCK PANEL

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 52 of 66

Make: Model: Year:
Honda Passport 2002-2003


FUNCTON COLOR LOCATON
Start: Blk/Wht or Wht/Blu gnition Switch Harness*
gnition #1: Blk/Yel or Blk/Red gnition Switch Harness
gnition #2: Blk/Yel or Blk/Red gnition Switch Harness
gnition #3: N/A
Accessory: Blue gnition Switch Harness
Brake Light: Red (+) At Brake Switch
Tach Signal: Black/Red See notes**
Parking Lights: Green/Red Drivers Kick Panel Pin 4 of Black Connector
Headlights: Red/Blue (-) At Headlight Switch
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *May have Transponder Anti-Theft system - Use Universal Alarm Bypass Module.
**Tack is located in a 16 pin green connector on the left side of the engine compartment near the
top of the firewall. **** From schematics alarm is present only in EX models. Alarm module is
located behind glove box.

Honda Passport 2002-2003

FUNCTON COLOR LOCATON
Constant +12 Volts: Wht/Blk or Wht gnition Switch Harness
OEM Alarm Disarm: Yellow/Blue At Alarm Module****
Dome
Lights/Superv:
Red/Green Driver Kick Panel Area
OEM Horn: Orange/Black At Steering Column Harness
Power Lock: Green/Red SEE NOTES*
Power Unlock: Red/Blue SEE NOTES*
Trunk Release: N/A Locks/Unlocks with doors
Alarm nput Wire: Red/Green Driver Kick Panel Area

NOTES: *Lock/Unlock wires located where rubber boot from driver door joins body harness. See
Note #201 Negative Trigger Door Locks


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 53 of 66

Make: Model: Year:
Honda PiIot 2003-2004


FUNCTON COLOR LOCATON
Start: Black/White gnition Switch Harness*
gnition #1: Black/Yellow gnition Switch Harness
gnition #2: Yellow gnition Switch Harness
gnition #3: N/A
Accessory:
Brake Light: White/Black At Brake Switch
Tach Signal: Blue At Coil
Parking Lights: Red/Black (+) Driver Side Fuse Box
Headlights: N/A Not recommended
Diesel Glow Plug: N/A
Clutch Bypass Wire: No Color Available Please call with information

NOTES: *Equipped with Transponder Anti-Theft system - Use Universal Alarm Bypass Module.
**EX models with OEM keyless disarm=Red/Black (Arm=Blue/Black) at Drivers Fuse Box. This
also locks/unlocks the doors.

Honda PiIot 2003-2004

FUNCTON COLOR LOCATON
Constant +12 Volts: White gnition Switch Harness
OEM Alarm Disarm: Black/Red(-) Passenger Side Fuse Box**
Dome
Lights/Superv:
Black/White or Lt.Green At Domelight Switch
OEM Horn: Green/Blue Steering Column Harness
Power Lock: Black/White Drivers Side Fuse Box*
Power Unlock: Green/Red Driver Side Fuse Box
Trunk Release: No Color Available Please call with information
Alarm nput Wire: Black/White or Lt.Green At Domelight Switch

NOTES: *Negative Trigger Door Lock System. See Note #201 Negative Trigger Door Locks




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 54 of 66

PILOT 2005 - 2006



KEY
T-
HARNES
S
MMOBLZER
N/A N/A
HONDA'S TRANSPONDER ANT-THEFT SYSTEM, REQURES BYPASS MODULE
AND EXTRA GNTON KEY

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/BLACK (+) GNTON SWTCH HARNESS
KEYSENSE BLUE/BLACK (-) (Required) GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) RED/YELLOW (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) RED/BLACK (+)
@ DRVERS FUSEBOX, LGHT
GREEN 20-Pin Plug
POWER LOCK
BLACK/ORANGE (TYPE B)
See NOTE *1
@ PASSENGER FUSEBOX,
LGHT GREEN 20-Pin Plug
POWER UNLOCK
BLUE/ORANGE (TYPE B) See
NOTE *1
@ PASSENGER FUSEBOX,
LGHT GREEN 20-Pin Plug
DOOR TRGGER BLACK/WHTE (-)
@ NTEROR LGHT SWTCH
on DASH
DOMELGHT SUPERVSON LGHT GREEN (-)
@ NTEROR LGHT SWTCH
on DASH
TRUNK RELEASE N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 55 of 66

SLDNG POWER DOOR N/A


HORN LGHT GREEN/BLUE (-) @ HORN SWTCH in COLUMN
TACH BLUE
@ DRVERS FUSEBOX, LGHT
GREEN 10-Pin Plug
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM
BLACK/RED to BLUE (-) See
NOTE *2
@ DRVERS DOOR in DOOR
MODULE
ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER

EXTRA NFORMATON
NOTE *1 Test these wires while using the POWER DOOR LOCK SWTCH on the PASSENGER
DOOR only. NOTE *2 Test this wire while turning the KEY in the DRVERS DOOR KEY CYLNDER.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 56 of 66

Make: Model: Year:
Honda PreIude 1983-1985


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL OR DSTRBUTOR *
Parking Lights: RED/BLACK (+) AT FUSE/JUNCTON BLOCK
Headlights: NOT RECOMMENDED POP-UP MOTOR SEPARATE CRCUT
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Carburated Engine!!

Honda PreIude 1983-1985

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER KCK PANEL OR AT LGHT
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS **
Power Unlock: ADD ACTUATOR N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) DRVER KCK PANEL OR AT LGHT

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 57 of 66

Make: Model: Year:
Honda PreIude 1986-1987


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT FUSE/JUNCTON BLOCK
Headlights: NOT RECOMMENDED - POP-UP MOTORS ARE SEPARATE
CRCUT
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Some Models Carburated, Check For Cruise Control (Available Only On Electronic
Fuel njection Models).

Honda PreIude 1986-1987

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) 25 PN CONNECTOR-DRVER KCK PAN.
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: ADD ACTUATOR N BOTH DOORS **
Power Unlock: ADD ACTUATOR N BOTH DOORS **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) 25 PN CONNECTOR-DRVER KCK PAN.

NOTES: ** See Note #204 - Adding Actuator Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 58 of 66

Make: Model: Year:
Honda PreIude 1988-1991


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: BLUE/WHTE GNTON SWTCH HARNESS
Accessory: WHTE/RED GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL
Parking Lights: RED/BLACK (+) AT LGHT SWTCH OR FUSE BOX
Headlights: NOT RECOMMENDED POP-UP MOTORS ARE SEPARATE
CRCUT
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda PreIude 1988-1991

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE/BLACK AND
WHTE
GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) WHTE CONNECTOR RGHT OF
COLUMN
OEM Horn: BLUE/RED (-) STEERNG COLUMN HARNESS
Power Lock: GREEN/WHTE DRVER'S KCK PANEL *
Power Unlock: GREEN/RED DRVER'S KCK PANEL *
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) WHTE CONNECTOR RGHT OF
COLUMN

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 59 of 66

Make: Model: Year:
Honda PreIude 1992-1993


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE (+) SWTCH ON TOP OF BRAKE PEDAL
SUPPORT
Tach Signal: BLUE AT DSTRBUTOR OR TEST CONNECTOR *
Parking Lights: RED/BLACK (+) HEADLGHT SWTCH OR FUSE BOX
Headlights: BLUE/RED (LO) RED/BLUE (H) HEADLGHT SWTCH (-)
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Tach Test Connector Located On Passenger Strut Tower.

Honda PreIude 1992-1993

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) DRVER KCK PANEL OR PASS.""B"" PLLAR
OEM Horn: (92) BLUE/RED (-)/(93) GRAY OR BLUE/BLACK-STEERNG
COL.HARN.
Power Lock: BLACK/WHTE DRVER'S KCK PANEL **
Power Unlock: BLACK/RED DRVER'S KCK PANEL **
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) DRVER KCK PANEL OR PASS.""B"" PLLAR

NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 60 of 66

Make: Model: Year:
Honda PreIude 1994


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GRAY/WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT GNTER OR TEST CONNECTOR *
Parking Lights: RED/BLACK (+) GRAY 20 WAY CONNECTOR AT FUSE BOX
Headlights: BLUE/RED (-) HEADLGHT SW. OR RELAY N ENG
COMFUNCTON
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * Test Connector Located On Passenger Strut Tower. BLUE Tach Wire Also Found n
Blue 16 Pin Connector At Fuse Block n Driver Kick Panel.

Honda PreIude 1994

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AND GRN/BLK (+) @ SECURTY CONTROL
MODULE
Dome
Lights/Superv:
GREEN/BLUE (-) DRVER KCK PANEL BELOW CARPET **
OEM Horn: BLUE/BLACK (-) HORN RELAY N DRVER KCK PANEL
Power Lock: BLACK/WHTE N HARNESS BESDE GAS PEDAL ***
Power Unlock: BLACK/RED N HARNESS BESDE GAS PEDAL ***
Trunk Release: N/A
Alarm nput Wire: GREEN/BLUE (-) DRVER KCK PANEL BELOW CARPET **

NOTES: ** BLACK/WHTE (-) Wire n 14 Pin Connector n Driver Kick Panel Can ALso Be Used
For Dome Light. *** Door Lock Wires Also Found n 16 Pin Connector Taped To Harness Above
Steering Column With Blue Tape. See Note #201 - Negative Pulse Door Lock Diagram.



This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 61 of 66
Make: Model: Year:
Honda PreIude 1995


FUNCTON COLOR LOCATON
Start: BLACK/WHTE GNTON SWTCH HARNESS
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREN/WHTE (+) AT BRAKE PEDAL SWTCH
Tach Signal: BLUE
2 PN TEST CONN.DRV SDE OF ENG
COMP.
Parking Lights: RED/BLACK (+) GRAY 20 PN CONN.ABOVE FUSE BOX PN
1
Headlights: RED/GREEN (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES:

Honda PreIude 1995

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
BLACK/WHTE (-) GRAY 14 PN CONN.ABOVE DR. KCK
PANEL
OEM Horn: BLUE/BLACK (-) YELLOW 6 PN CONN.DRV SDE S/C PN 1
Power Lock: BLACK/RED (-) BROWN 8 PN CONNECTOR
Power Unlock: BLACK/WHTE (-) NEXT TO FUSE BLOCK *
Trunk Release: N/A
Alarm nput Wire: BLACK/WHTE (-) GRAY 14 PN CONN.ABOVE DR. KCK
PANEL

NOTES: * See Note #201 - Negative Pulse Door Lock Diagram.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 62 of 66

Make: Model: Year:
Honda PreIude 1998-2001


FUNCTON COLOR LOCATON
Start: BLACK/RED GNTON SWTCH HARNESS *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: YELLOW GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: WHTE/BLACK GNTON SWTCH HARNESS
Brake Light: GREEN/WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: BLUE AT COL MODULE
Parking Lights: RED/BLACK (+) STEERNG COLUMN HARNESS
Headlights: BLUE/RED (-) STEERNG COLUMN HARNESS FROM
LGHTSWTCH
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * This vehicle is equipped with a transponder immobilizer system. See nstallation Note
#144 - Bypassing Transponder Theft Systems.

Honda PreIude 1998-2001

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) NSDE OF DRVER'S DOOR
Dome
Lights/Superv:
WHTE/BLACK (-) DRVER'S KCK PANEL UNDER FUSE BOX
OEM Horn: BLUE/RED OR LT.
BLUE/GREEN (-)
STEERNG COLUMN HARNESS
Power Lock: BLACK/WHTE (-) PASSENGER KCK PANEL**
Power Unlock: BLACK/ORANGE (-) PASSENGER KCK PANEL
Trunk Release: N/A
Alarm nput Wire: WHTE/BLACK (-) DRVER'S KCK PANEL UNDER FUSE BOX

NOTES: **See Note #201 Negative Trigger Door Locks




This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 63 of 66

RIDGELINE 2006

KEY T-HARNESS MMOBLZER
N/A N/A NO NFORMATON AT THS TME!!!

FUNCTON COLOR LOCATON
12 VOLT CONSTANT WHTE (+) GNTON SWTCH HARNESS
STARTER BLACK/WHTE (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 BLACK/YELLOW (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
WHTE/BLACK (+) GNTON SWTCH HARNESS
KEYSENSE N/A
PARKNG LGHTS ( - ) BLUE (-) @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) RED/BLACK (+)
@ UNDERDASH FUSE/RELAY
BOX
POWER LOCK PNK/BLACK (TYPE B)
@ PASSENGER KCK PANEL
or MCU See NOTE *1
POWER UNLOCK PNK/BLUE (TYPE B)
@ PASSENGER KCK PANEL
or MCU See NOTE *1
DOOR TRGGER BLUE/RED (-)
@ NTEROR LGHT SWTCH
on DASH
DOMELGHT SUPERVSON GREEN/RED (-)
@ NTEROR LGHT SWTCH
on DASH
TRUNK RELEASE N/A
SLDNG POWER DOOR N/A

This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 64 of 66

HORN GREEN/YELLOW (-) @ HORN SWTCH in COLUMN


TACH
Any wire NOT BLACK/WHTE
or BLACK
@ Any GNTON COL
WAT TO START LGHT N/A
BRAKE WHTE/BLACK (+)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM WHTE (-)
@ DRVERS DOOR in DOOR
MODULE
ANT-THEFT No nformation at this time!!!

EXTRA NFORMATON
NOTE *1 the MCU (Multiplex ntgrated Control Unit) is part of the UNDERDASH FUSE/RELAY BOX.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 65 of 66

Make: Model: Year:
Honda S2000 2000-2002


FUNCTON COLOR LOCATON
Start: BLACK/WHTE HARNESS N DRVER'S KCK PANEL *
gnition #1: BLACK/YELLOW GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory: YELLOW GNTON SWTCH HARNESS
Brake Light: WHTE/BLACK AT SWTCH ABOVE
Tach Signal:
Parking Lights: RED/BLACK KEYLESS MODULE BEHND START
BUTTON
Headlights: BLUE/RED (-) STEERNG COLUMN HARNESS
Diesel Glow Plug:
Clutch Bypass Wire:

NOTES: * The Start Wire s Running From The Start Button. This vehicle may be equipped with
a transponder immobilizer system. See nstallation Note #144 - Bypassing Transponder Theft
Systems.

Honda S2000 2000-2002

FUNCTON COLOR LOCATON
Constant +12 Volts: WHTE GNTON SWTCH HARNESS
OEM Alarm Disarm: BLUE (-) AT SECURTY MODULE UNDER DRVER'S
SEAT
Dome
Lights/Superv:
GREEN/YELLOW (-) KEYLESS MODULE BEHND START
BUTTON
OEM Horn: ORANGE (-) STEERNG COLUMN HARNESS
Power Lock: SEE NOTES BELOW **
Power Unlock: SEE NOTES BELOW **
Trunk Release: BLACK/YELLOW KEYLESS MODULE BEHND START
BUTTON
Alarm nput Wire: GREEN/YELLOW (-) KEYLESS MODULE BEHND START
BUTTON

NOTES: ** THERE ARE TWO BLANK PLUGS ON THE KEYLESS MODULE. ONE S LOCK,
THE OTHER S UNLOCK.


This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Honda - Copyright 2004-2006 - 12 Volt Resource LLC Page 66 of 66

Make: Model: Year:
Honda S2000 2003-2006


FUNCTON COLOR LOCATON
Start: Blue/White (+) gnition switch harness
gnition #1: Black/Yellow (+) gnition switch harness*
gnition #2: Black/Red (+) gnition switch harness
gnition #3: N/A
Accessory: White/Red (+) gnition switch harness
Brake Light: White/Black (+) Brake pedal switch
Tach Signal: Blue (AC) Tach test connector**
Parking Lights: Red/Black (+) Keyless entry module***
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A

NOTES: *This vehicle is equipped with a Transponder Anti-Theft security system. Use a
universal alarm bypass module. **The tach connector is a 2 wire plug behind the fusebox on the
driver side of the engine compartment underneath the hood. ***The keyless entry module is on
the drivers side kick panel behind the start button.

Honda S2000 2003-2006

FUNCTON COLOR LOCATON
Constant +12 Volts: White (x2) (+) gnition switch harness
OEM Alarm Disarm: White (-) Keyless entry module***
Dome
Lights/Superv:
Black/White (-) Keyless entry module***
OEM Horn: Orange (-) Keyless entry module***
Power Lock: Pink/Black Keyless entry module****
Power Unlock: Yellow/Green Keyless entry module****
Trunk Release: Black/Yellow (+) Keyless entry module***
Alarm nput Wire: Black/White (-) Keyless entry module***

NOTES: ***The keyless entry module is on the drivers side kick panel behind the start button.
****This vehicle is equipped with reverse polarity door locks. See Note #203 - Reverse Polarity
Door Lock Diagram.

También podría gustarte