Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Test1 – Unit3
VALERIA SOSA
1) A sensor generates an information signal with frequency f =Your_number_list * 1000 [Hz]. Some
other equipment emits frequencies that contaminate the sensor’s signal.
1) What type of filter do you need? Design the required filter with active components. Justify your
design parameters. (4P)
Se necesita un filtro pasa banda, para permitir que solo pase la frecuencia de 26kHz y se atenúen las
demás frecuencias que no correspondan a esa.
La frecuencia de corte o central es de 26kHz, y el ancho de banda es 1kHz, mismo dato que se ubicó
en Bandwidth.
Se escoge Butterworth para que no existan oscilaciones en la banda de paso y el orden es de 4, es
decir va a tener orden 2 a cada lado.
Circuito diseñado:
Funcion de transferencia:
4.4 If the input is x(t) = 5 Sin (w t) at f = Your_number_list*1000 Hz, what will be the expression
for the output?
Show your measurements and answers in the frequency response plot.
3) Design a filter to "compensate" the phase shift caused by the filter of item 2 (4p) 5.1 What type
of filter do you need?
Se necesita un filtro que corrija el desfase negativo de -180 presentado arriba, por lo que se
requerida un filtro que produzca un desfasaje de 180 positivo.
5.2 Calculate the value of the components for frequency f = Your_number_list*1000
Hz. 5.3 Plot the frequency response of this filter and verify the phase shift.
5) Connect the output of circuit1(item1) to the input of circuit2 (item 4). (4p) 6.1 Input a signal x(t) =
5 cos (wt + 20) where f = Your_number_list*1000 Hz to circuit 1 6.2 Plot:
- x(t)
- the output of circuit1
- the output of circuit2