REAR BUMPER
< REMOVAL AND INSTALLATION >
REAR BUMPER
Exploded View
‘SEC. 850
1. Rear bumper side brackets (LH) 2.__-Rear bumper closing (LH) 3. Rear bumper fascia
4. Rear bumper closing (RH) 5. Rear bumper side brackets (RH) 6, Rear bumper reinforcement
A. Screw grommet
Removal and Installation wrovacomranoaeaes
REMOVAL
CAUTION:
Bumper
oil.
1. Remove rear combination lamps (LH/RH). Refer to EX\-109. "Removal and installation"
is made of resin. Do not apply strong force to it, and be careful to prevent contact with
Revision: April 2013 EXT-20 2014 Versa SedanREAR BUMPER
< REMOVAL AND INSTALLATION >
2. Remove clips (A) and screws (B) (LHRH).
3, Remove rear bumper fascia lower clips.
4, Remove rear bumper fascia end screws (A).
®S
5. Pull rear bumper fascia away as shown by the arrows in the
illustration and then disengage the rear bumper fascia from rear
bumper side brackets (LHIRH).
os Pawl
6. Remove rear bumper fascia
CAUTION:
When removing bumper fascia assembly, two people are required to avoid damaging.
7. Remove the following parts after removing rear bumper fascia.
+ Rear bumper side brackets (LH/RH)
8. Remove rear bumper reinforcement nuts and rear bumper reinforcement.
9. Remove rear bumper closing clips and rear bumper closings (LH/RH).
INSTALLATION
Installation is in the reverse order of removal.
NOTE:
+ The following table shows the specified values for checking normal installation specifications.
Revision: April 2013 EXT-21 2014 Versa SedanREAR BUMPER
< REMOVAL AND INSTALLATION >
+ Fitting adjustment cannot be performed.
Portion Clearance ‘Surface height difference
0.0—1.0 mm (1.7) - (+0.3) mm
Rear bumper ~ Rear fender | A ~ A {0.000 - 0.04 in) [(-0.07) - (+0.01) in]
Rear bumper—Rear combi-| 5 _ 0.0-3.5mm 01-39 mm
nation lamp {0.000 - 0.14) in (0.004 — 0.15 in)
i 5.0-9.0 mm
Rear bumper —Trunklid | C-C (o20-o35in) =
Revision: April 2013 EXT-22 2014 Versa Sedan