Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Primer Informe de Laboratorio PDF
Primer Informe de Laboratorio PDF
Universidad de Medellín
Facultad de Ingeniería
Ingeniería de Sistemas
2 de marzo de 2020
Colombia, Medellín
Telemática – Profesor: Alber Oswaldo Monto
TABLA DE CONTENIDO
1. INTRODUCCIÓN .............................................................................................. 1
2. OBJETIVOS ...................................................................................................... 1
3. ESPECIFICACIONES DE LA PRÁCTICA DE LABORATORIO ....................... 1
3.1 TOPOLOGÍA .............................................................................................. 1
3.2 TABLA DE DIRECCIONAMIENTO ............................................................ 2
3.3 ESPECIFICACIONES DE LA ASIGNACIÓN DE PUERTOS DE SWITCH 2
4. PROCEDIMIENTO ............................................................................................ 3
4.1 PARTE 1: ARMAR LA RED Y CONFIGURAR LOS AJUSTES BÁSICOS
DE LOS DISPOSITIVOS ....................................................................................... 3
4.2 PARTE 2: CONFIGURAR LOS SWITCHES CON LAS VLAN Y LOS
ENLACES TRONCALES....................................................................................... 6
4.3 PARTE 3: CONFIGURAR ROUTING ENTRE VLAN BASADO EN
ENLACES TRONCALES ...................................................................................... 9
Telemática – Profesor: Alber Oswaldo Monto
1. INTRODUCCIÓN
2. OBJETIVOS
3.1 TOPOLOGÍA
1
Telemática – Profesor: Alber Oswaldo Monto
2
Telemática – Profesor: Alber Oswaldo Monto
4. PROCEDIMIENTO
3
Telemática – Profesor: Alber Oswaldo Monto
Paso 3: Inicializar y volver a cargar los routers y switches, según sea necesario
Paso 4: Configurar los parámetros básicos para cada switch
Para la configuración inicial de cada Switch se utilizaron los siguientes comandos:
enable
config t
no ip domain-lookup
service password-encryption
enable secret class
line con 0
password cisco
login
logging sychronous
exit
line vty 0 15
password cisco
login
exit
hostname S1
exit
write mem
Para configurar la dirección IP que figura en la tabla de direcciones para VLAN 1 en
el switch, se utilizaron los siguientes comandos:
S1>enable
S1#config t
S1(config)#interface vlan 1
S1(config-if)#ip address 192.168.1.11 255.255.255.0
4
Telemática – Profesor: Alber Oswaldo Monto
5
Telemática – Profesor: Alber Oswaldo Monto
R1#write mem
Building configuration...
[OK]
6
Telemática – Profesor: Alber Oswaldo Monto
S2(config)# vlan 10
S2(config-vlan)# name Students
S2(config-vlan)# vlan 20
S2(config-vlan)# name Faculty
b. Para verificar que los nombres y números de las VLAN coincidan con los del
S1, se utilizaron el siguiente comando en ambos switch
7
Telemática – Profesor: Alber Oswaldo Monto
8
Telemática – Profesor: Alber Oswaldo Monto
R1(config-subif)#encapsulation dot1Q 1
9
Telemática – Profesor: Alber Oswaldo Monto
10
Telemática – Profesor: Alber Oswaldo Monto
5. CONCLUSIÓN
11
Telemática – Profesor: Alber Oswaldo Monto
12