Sheet SC7D-130-E10
aUurence 890815
Designers + Manatcius + Eoghears
em ELEGTPIC ANO PNEUMATIC PROCESS VALVES « MARINE VALVES + FIRE PROTECTION VALVES + ACTUATORS
INSTRUCTIONS tse m4
EXPLOSION PROOF SOLI-CON® ACTUATORS
Model Number $C7D- 130-610
Accomodates the Following Voltages:
+ 9 to 140) Volts, Direct Current, Continuous Duty
Coil Insulation Class H (Electronic components maximum temperature rating is 125°C)
Curent: 5.3 Amps Inrush, 0.01 Amps Holding
Laurence Explosion Proof actuators are Factory Mutual System Approved for use in hazardous
locations, mdoors and outdoors, specified in the National Lleettical Code a
* Class 1, Division 1, Groups B, C and D.
+ Class I, Division 1, Groups B, F and G.
CAUTION — To prevent ignition of acatJous atmospheres, this actuator should not be installed in
an area where vapors or gases have an ignition temperature less than the temperature
ating stated on the actuator label.
corrections:
The coil is
S°C ambient temperature, therefore,
ure Locations
cuit at 192°C.
Note: The rated temperature is based on a 2:
should be made for applications in higher ambient temp
equipped with a thermal cut-off, designed to interrupt the ci
‘O-
Note: f
Do not use full wave 12SV/DC/C
rectified AC,
Note:
Do not cycle more
than four (4) times
por minute
cagcur,
DIAGRAM
The actuator must be connected to the voltage sourve through rigid explosion proof conduit. Conduit
must be of un approved type. At least five full threads must be engaged in conduit connections
Electical supply line to actuator should be tused at 5 amps, “Fusetron” type. Select wire size
appropriate to fuse rating and length of run of wire, but in no case use less than 18 AWG.
Full inrush current at rated voltage must be delivered to the actuator w insure that it operates
properly. Green colored wire
for protective pronnd
No maintenance is required for this actuator. Any questions should be referred to our Tampa,
Florida, ULS.A., factory.
RG. LAURENCE COMPANY, INC.
12501 Telecom Drive « Tampa, FL 39857 1903 UA» Phone (83) 972.961 of (B13) 9770137 + Fax (819) 877-0174 «Toon 136445