Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Model:BL-WR2000
300Mbps Wireless N Router
1.Connecting the device
Note: Please use wired network connections only to configure the Router.
1 Connect the WAN port on your Router to the Modem's LAN port with an Ethernet cable.
(If there is no Modem, please use the incoming cable directly into the router's WAN port).
Internet
Cable/DSL Modem
1
Wireless N Router
2 Connect your computer to the Port labeled 1~4 on the Router with an Ethernet cable.
Internet
Cable/DSL Modem 2 PC
Wireless N Router
3 Plug the provided power adapter into the power jack on the back of the router and the
other end to a standard electrical wall socket.
Power
Internet outlet
Cable/DSL Modem PC
Wireless N Router
1
4 Check the router's LED indicator lights display status is the same as described.
SYS : Flashing
WPS: Flashing
WLAN: Flashing
Note: If the LED indicator light display abnormal, please check whether the
connection is correct.
2
2.Configuring the device
1 Login
User name:admin
Password: admin
Click OK
The web management page will Quick Setup Network Wireless Firewall Virtual Server QOS
display after a successful login
Status Password Time Zone Export/import Restore Firmware
System information
Run time 00:30:01
System time 07:32:24
Click Quick Setup
Software version v2.0.10.
3
2 Internet Paremeters Configuration
This page will then display Quick Setup Network Wireless Firewall Virtual Server QOS
Quick Setup
Qucik Setup
DHCP (Auto Config)
Select a connection type Static Mode (fixed IP)
PPPOE (ADSL)
Click Next
B Configuration for Static Mode Quick Setup Network Wireless Firewall Virtual Server QOS
This page will then display
Quick Setup
Qucik Setup
Click Next
C Configuration for PPPOE Quick Setup Network Wireless Firewall Virtual Server QOS
Click Next
4
3 Wireless Settings Configuration
This page will then display
Click Apply
Note: The basic setting for your Router is completed. You will be able to access to the
Internet, if not, please refer to the troubleshooting
5
3.Troubleshooting
FAQ1: What should I do if I forget the user name and password?
(How to restore the router 's configuration to its factory default settings.)
Answer: If you forget the user name and password, the only way to solve this problem is to
reset the router. Press and hold the RESET button on the rear panel for 5 to 8 seconds before
releasing it.
Clone MAC
Restore
Cancel Apply
6
For Windows XP OS
Click Network
Connections
Right-click Local
Area Connection
Click Properties
Double-click Internet
Protocol (TCP/IP)
7
For Windows XP OS
Select Obtain an IP
address automatically
Click OK
Click OK
8
For Windows 7 OS
Click Change
adapter settings
Right-click Local
Area Connection
Click Properties
9
For Windows 7 OS
Click OK
Select Obtain an IP
address automatically
Click OK
10
For Windows 7 OS
Click OK
11
For Windows 8 OS
Click Change
adapter settings
12
For Windows 8 OS
Right-click Ethernet
Click Properties
13
For Windows 8 OS
Select Obtain an IP
address automatically
Click OK
Click OK
14
is the registered trademark of Shenzhen BILIAN Electronic CO . ,Ltd.All the products and
product names mentioned herein are the trademarks or registered trademarks of their respective
holders 2012 All Rights Reserved.