Documentos de Académico
Documentos de Profesional
Documentos de Cultura
135
FALLAS Y DIACLASAS
136
FALLAS Y DIACLASAS
Diaclasas
• Diaclasas de descarga y de voladura: formadas por
trabajos de extracción y descarga de material en
minas y canteras.
• Diaclasas de enfriamiento en rocas volcánicas:
formadas por retracción de la roca al enfriarse.
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
69
137
FRACTURACION
138
FRACTURACION
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
70
139
FRACTURACION
140
FRACTURACION
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
71
141
FRACTURACION
Rocas de falla
0-10%
142
FRACTURACION
Extensión vs. acortamiento
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
72
143
FRACTURACION
Control de circulación de fluidos: también en superficial.
144
PLIEGUES
Geometría
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
73
145
PLIEGUES
146
1. CONTROLES DEL
DEPOSITO
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
74
147
148
G-T-(2)
En cambio, la situación es más compleja en el caso de las soluciones
hidrotermales, que por otra parte están también en interacción con
substancias gaseosas disueltas. Aquí aparecen variados mecanismos
de precipitación que, en último término, se relacionan con las
condiciones de estabilidad de los complejos.
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
75
149
G-T-(3)
Un ion complejo puede ser desestabilizado por diversos
mecanismos. En primer término, el elemento acompañante puede
pasar a la fase volátil. Por ejemplo: si disminuye la presión y se
pierde H2S, el ion Au (HS)2"se desestabilizará, precipitando Au. Sin
embargo,
b l mismo
lo i puede
d ocurriri por un aumentot de
d acidez,
id que
favorezca la forma H2S sobre la de bisulfuro HS", o por una mayor
alcalinidad, que haría pasar HS" a S2". A su vez, la pérdida de C02
al disminuir la presión puede conllevar a la disminución de acidez
(al pasar H+ + HC03" a H20 + C02, por lo quetambién se pierden
hidrogeniones).
Otro factor importante es el grado de oxidación. En el caso del oro,
si sellega a valores reductores de Eh,
Eh el Au precipitará.
precipitará En cambio,
cambio
valores muy oxidantes tendrán efecto sobre el HS-, al pasar el
azufre a S4+ o S6+, lo quetambién desestabilizará su complejo. En el
caso del uranio, soluble bajo laforma U022+ (vale decir con valencia
6+), el paso a condiciones reductoras implicará su precipitación
como U02.
Dr. Jorge Oyarzun Muñoz - joyarzun@expo.intercade.org ‐ Consultor Intercade
150
2-
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
76
151
G-T-(4)
Otra causal de desestabilización de complejos es su dilución. Por
ejemplo: un complejo metálico clorurado, estable en una salmuera
(brine), se puede romper si la salmuera se diluye por mezcla con
agua de baja salinidad. Aparte de las reacciones entre soluciones
hidrotermales o entre estas y aguas subterráneas o fluidos
derivados de sedimentos en etapa de diagénesis, las soluciones
hidrotermales pueden reaccionar con las rocas de caja a través de
las cuales se desplazan. Al respecto, los contrastes de composición
(y por lo tanto posibles reacciones químicas de neutralización o de
óxido reducción)) juegan un rol principal. Ello junto con los aspectos
estructurales (espacios abiertos por razones geométricas o medios
de elevada porosidad y permeabilidad) y los fuertes contrastes de
temperatura (como los que encuentran las soluciones hidrotermales
que acceden al fondo oceánico).
152
G-T-(5)
Naturalmente, el depósito de los minerales plantea problemas de espacio,
excepto cuando se realiza fuera de los macizos rocosos, como en el caso
de las chimeneas de sulfuros polimetálicos de las dorsales oceánicas. Una
primera respuesta a esos problemas es la creación de espacios a través
de mecanismos estructurales, facilitada por los cambios de rumbo o
inclinación de planos de falla, cuyos desplazamientos de bloques
generarán espacios aptos al relleno. También el plegamiento genera
espacios, así como lo generan los sistemas explosivos (brechas, stock
work).
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
77
153
G
1m‐
100m F
E
D
C2
B
0,01‐
Evolution of patterns in
1m Intrusive porphyry coppers
A
154
Roca
Traquitica
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
78
155
Cerro
156
EPITHERMAL Au-Ag DEPOSITS, N, GREAT BASIN, WESTERN UNITED STATES
A
FIG. 10. Model for the magmatic-tectonic setting of the western andesite assemblage. Along the western side of the Great Bassin, oblique subduction of oceanic lithosphere
(Farallon plate) beneath North America was occurring. Downgoing oceanic crust dehydrated, releasing volatiles that facilitated partial melting of the mantle wedge. These
volatile-rich mafic melts rose buoyantly to the lithosphere and ponded in the MASH zone (melting, assimilation, storage and homogenization; Hildreth and Moorbath, 1988),
where they extensively interacted with the lower crust and probably formed diffuse batholiths. Trasntensional zones and pull-apart basins developed locally due to strike-slip
faulting paralled to the are and allowed the hydrous magmas to rise buoyantly to shallow crustal levels and further fractionate and interact with the crust. Some of these
magmas erupted, forming polyugenetic stratovolcanoes directly over the shallow magma chambers. Modified from Tosdal and Richards (2001).
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
79
157
Llanura costera Plataforma continental
Playa
de arena
Nivel del mar
Placeres de oro y minerales
Petróleo &
Gas
Fosfatos
Sal
158
FIGURE 2. Hypothetical zoning patterns related to an idealized Eocene magmatic-hydrothermal system in the Great Basin physiographic province. United
Slates. A. Geology,emphasizing more favorable units based on higher permeability and/or reactivity. B. temperature and prograde flow regime, with fluids
derived from a large magma chamber at depth. C. Possible depositions environments for various deposit types, based on temperature and protolith. D.
Examples of Eocene gold deposittypes (deposit shapes modified from Babcock el al.. 1997: Settles, 2002; Clode et al„ 2002; Hortan et ai.. 2002, Jackson
et al., 2002. Norby and Orobona, 2002: Johnston, 2003). Scale bar in A applies to all cross sections; the scale bar in D applies only to the deposit outlines.
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
80
159
Ground surface
Funnel‐shaped
mass of basaltic
magma
Conduit from
magma source
FIGURE 13.15. Chromite that crystallizes from a melt is denser than the
surrounding melt and therefore will sink to the bottom and accumulate there in
a process called crystaal setting.
160
PORPHYRY
Cu, Mo
500
SKARN magmatic
Cu, Zn water
BRECCIA dominated
400 PIPE LMS, REPLAC.
Cu, Zn, Pb
ºC Cu, Mo,
W
VEIN
Cu, Zn, Pb, Ag
300
VEIN KUROKO
Ag, Au TYPE
200
Decreasing depth
Increasing distance from magmatic hearth
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
81
161
Figura 8.18. Zonación mineral desarrollada en un sistema de venas que se formó alrededor
de un stock granítico en Cornualles, Ing|aterra. Todas las vetas (como se muestra en la
figura 2.3 y en la lámina 39) están mineralizadas y contienen el mineral de estaño casiterita
(Sn02), minerales de cobre, de los que la calcopirita (CuFeS2) es la más importante, y
minerales de zinc y de plomo como galerita (ZnS) y galena (PbS). Se cree que esta
zonación se produjo por un descenso de la temperatura de las disoluciones hidrotermales
cuando fluían a través de las fracturas en las que ahora existen las venas.
162
50º
Cu
Cu +
QMP Mo
60º
Cu
90º
Metal Deposits on the Inner Sides of Prrincipal Arcs.
EXPLANATION
DISSEMINATED
PORPH ORE
OPEN PIT
CHALCOPYRITE + BORNITE;
MOLYBDENITE
No. 27 Bed DISSEMINATED
CHALCOPYRITE + BORNITE;
Cu ORE
PORPH ORE
CHALCOPYRITE + BORNITE;
ERGROUND
MAGNETITE + HEMATITE;
HIGH GRADE Cu ORE IN
Skarn
NON-P
UNDE
GALENA + SPHALERITE +
SCALE PYRITE; HIGH GRADE Pb-Zn-
0 1000 Ag ORE IN LIMESTONE QTZITE
AND QTZ MOZ.
METERS
Fig. 2.3. Zonal distribution of porphyry, skarn and limestone replacement ores centered
on the Bingham stock. Such district-wide zoning is characteristic of strongly
mineralized areas in inne-arc regions (fromAtkinson and Einaudi, 1978).
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
82
163
S
Hg
0
oro Zona de
Zona ebuillición
á id
ácido- plata
sulfato
metales básicos 1
km
pirita-
sericita
Zona de Cu
2
Zona de Mo
fuente post-
pre- de metales mineral
mineral
3
164
San Luis
Caldera
4
Soft tuffs Creede
Ore zone
Caldera
2
Creede
KILOMETERS
Ashflows Formation
‐2 Precambrian
NORTH
SOUTH
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
83
165
W E
OXIDIZED
100
UNOXIDIZED
0 100
FEET
EXPLANATION
Preble Formation (Cambrian) – Consists of:
Limestone
Shale
Outlines zone of g
gold ore
Fault
Figure 8.8. Schematic cross section of the main ore zone of the
Preble deposit. The ore horizon is restricted to a shear zone
associated with an east-dipping normal fault. The diagram is
modified from Kretschmer (1984).
166
CHUQUICAMATA
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
84
167
ORO
MERCURIO
168
O2 O2 B
C
water table Cool Ground Water
Self Seal D
-L F
E
1 km
A
200º
-H
Figure 11.1. Schematic diagram of a boiling hydrothermal system based in part on White et al.
(1971), Henley and Ellis (1983), Berger and Eimon (1983), and Steven and Eaton (1975).
Ascending hot waters begin to boil (indicated by circles) at the depth labeled H, if pressure is
hydrostatic or at some shallower depth between H and L if pressure exceeds hydrostatic but is
less than lithostatic. Boiling and various mixtures of boiled hot water and gases with near-
surface ground water and atmospheric oxygen produce hot-water compositions and ore-
forming environments labeled by letters A through F. These reaction features are identified by
letter and described in Figure 11.2 and in the text.
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
85
169
170
0.5 50
1 0 100
1.0
1.5 150
2.0 200
Point critique
2.5 250
km Bar
Profondeur Pression fluide
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
86
171
Espacios
172
Profondeur en km
20
Vers 900º, 35 km
15
hypothermal
5
mésothermal
leptothermal
épithermal xénothermal
0
sedimentaire Exhalatif Exhalatif 750 1000º
250 500
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
87
173
Thermally weakened
deformed zones 400ºC 400ºC
Fig. 3. Geometry of a magmatic arc formed at an obliquely Fig. 4. Fluid circulation in a porphyry copper deposit forming
convergent plate margin. Hydrous magmas are generated in in the cupola of a stock at depths in the range of 1 to 3 km.
the mantle wedge and intrude the lithosphere along broad Exsolution and trapping og magmatic fluids in a zone of
deformation zones undergoing varying amounts of strike-slip lithostatic fluid pressure (Pf) beneath an isotherm of 370º to
motion depending upon the degree of obliquity along the 400º C, which marks the brittle-ductile transition. Within this
convergent margin. Modified from de Saint Blanquart et al. zone, brine and “steam” interact with the country rocks
(1998). forming the potassic alteration stage.
A
S N S N 174
0 Cogenetic
volcanics
B
1
Succesive fractring dike
intrusion & upward flow
2 of high-density saline
Kelvin
Rising low- aqueous ore fluid Restored
density aqueous- view
3 salt fluid Potassic Tea Cup
alteration Granodiorite
Porphyritic phase
Graphic Non- & Cu-
Equigranular
border sulfides
4 magmatic phase
Tertiary
phase saline
dike
aqueous fluid
5
Magma &
Magma & high- high-density saliné-
6 density H2O – salt aqueous-Cu- bearing
Inward fluid fluid
Last magma
crystallization
7 Magma & crystals
C S N
Domes
Domes
Paleosurface
0
1 erosion
surface
2
Ann-
Mason
3
km
4
Mac
Blue Hill Arthur
area area
5
7 Pluton floor
(?)
Sedimentary and volcanic rocks (Tri. And Jur.) Granitic rocks (Middle Jr.)
Volcanics of Artesia Lake (Jur.) Granite porphyry dikes
Quartzite (jur.) Luhr Hill porphyritic granite
Silstone (Jur.) Border granite of Bear intrusion
Limestone (Tri.) Quartz monzonite of Bear intrusion
Sedimentary and volcanic rocks (Tri.) Quartz monzodiorite of McLeod Hill intrusion
Volcanic rocks (Tri.) Shamrock batholith
Fig. 5. Relationship between porphyry Cu deposits, porphyry stocks, and dikes to underlying parental magma chambers, which commonly lie at depths
of 6 km or greater. A. Evolutionary model for the exsolution of high-density saline aqueous fluid from tabular plutons and the upward escape of this fluid
into the roof zone where a porphyry Cu deposit forms (Dilles, 1987). The saline aqueous fluid trapped along the roof of a cooling batholith is channeled
upward along dikes or stocks that emanate from the inwardly crystallizing magma. B. The Kelvin porphyry Cu prospect in Arizona is associated with a
small porphyry stock that emanates from the apical part of the Tea Cup Granodiorite (modified from Cronwall and Krieger, 1975; Creasey, 1984). C. The
Ann-Mason porphyry Cu deposit in the Yerington batholith is associated with dikes emanating from successively deeper parts of the Luhr Hill
porphyritic granite (Dilles, 1987). Jur=Jurassic; Tri= Triassic.
INTERCADE www.intercade.org
CONSULTANCY & TRAINING
88
175
176
INTERCADE www.intercade.org
CONSULTANCY & TRAINING