Certificate of Conformance
Ref No.: 29116
Issued to
Equimed Gestion Teenologica
Pasaje Oe6A 82 Y San Gabriel
Quito, Ecuador
Identification
MODEL RGDM+MA RAPID-GOLD MA DIGITIZER S/N 49-1602
MODEL AGMS-D! MULTISENSOR, DIAG S/N 43-1279
The equipment identified above has been calibrated and tested using production acceptance procedure
‘44500005, Radcal Quality Manual PP1007, Radcal Policy and Procedure PP 1038, PI1035, PL10SS, and
‘other related documents. The equipment has been found to conform in all respects. These test
Procedures are designed to ensure that the tested equipment mects or exceeds all aspects of Radcal’s
Published product specifications and requirements. Radcal is an ACLASS accredited calibration lab
that meets the requirements of ISO 17025 and ANSUNCLS 2540-1, cert number AC-1553.
All measuren
ents performed during the acceptance testing employ equipment taceable to NIST or
another recognized national laboratory such as Physikalisch- Technische Bundesansalt (P18),
For additional information please refer to Radca's Product note: "Service Description"
Certificate Issue Date; 21-Aug-19 by
Authorized Representative
Raucal Corporation
426 W, Duarte Rd. Monrovia, CA 91016,
DI FAX: (626) 387.
163. email service radeal co“Monrovia. CA 91016-4501 USA.
Weezess7.7e21 F:68357 2063
Wimamadcal com vericw@redcal.com Xencoire
Report No: 291160AL,
Cer ate of Calibration
ued To: Equimed Gestion Tecnologica
Pasaje Oe6A 82 ¥ San Gabrel
Quito, Eovador
Status
Equipment Description Model sm Asset, AS Left
RAPIO-GOLD MA DIGITIZER RGOMeMA 49-1602 NA -
MULTISENSOR, DIAG AGMS.0+ —43:1279 NA InTolerance
NOTE: Pror to calibration, the equipment was examined and found to be in good condition and performed in
‘accordance with the manufacturers specifications wth the exceptions listed below
1. None
Status As Found/Lett refers to system performance with each distinct sensor or chamber defining the system
“The equipment ssentied above nas been calbraled and ested use stondard Radca!calbraton and acceptance procedures
Trecensdance wih Racca! Quelly Manual PP1CO7, 4600129 - Certal- Diag XLT Rev @ and technical reaurements
Contaved tne custome’’ order These procedutes are designed to ensure that retested equinment meets ar exceeds
the stated specications and the requements of ANSUNCLS 7540-1-1094 and 1SO 17025
‘An measurements performed dunng he tesing employ equbrrent traceable Yo NIST anotner recogn zed Nationa
Catorstony such as Phyaikaisch Technische Bundesansat (PTE), Al calraionresuts ince wi hs certicate
cae tecorded ot he tune of measurement and shall nat mply anything about the instrument's ute stability This
ust be determined trom previous historical dala
Calibration Date 21 August 2019
‘Date of Report 21 Aujust 2019
Interval, as defined by customer. 24 morths ater date of calbratin
Calibration Ove 21 August 202
Calibration Tech by
Tuihorzed Reviewers
E Macintosh /M. Bryant
‘Sensor EngineeringRAACADP covomnon
se wee Ose Rous
Mivera.cx biotease! usa
Peper Fetes ones
Wi immumtoaicon | sowengreceatcom
Report No: 291 16DAL
Certificate of Calibration
Measurement Test Conditions
‘An Electromed EDEC-80 X-ray generator equipped with an Eimac Model A192 tungsten target x
ray tube was used as the source of the required x-ray beam. The generator nipple is less than 0.5
KV. The inherent fitration was adjusted by the addition of aluminum to produce a total fitration of
2.5mm Al in accordance with IPSM Report No, 64 “Data for Estimating X-ray Tube Total Filtration”
‘The output of the generator was measured by a Rascal DynalyzerIlIU. The test instrument and the
Dynalyzer were monitored simultaneously by anaiog to digital converters with an uncertainty of +
0.1%. All reported voltage measurement results have an uncertainty of better thant 1% at the
‘95% confidence level, All dose measurements were performed using the substitution method and
‘normalized with a transmission chamber All reported dose and dose rate measurement results
hhave an uncertainty of better than 2 5% at the 95% confidence level
‘The descnption and traceabilty ofall standards and equipment used inthis calibration are found
in Appendix A of this report.
NOTE: At dose measurements were normalized 10 22°C, 101.9 kPa
"GF" = correction factor and True Reading » CF x Reading
‘All exposures were made with the DUT oriented perpendicular to the beam
‘The beams) were collmated to not excose the chamber stem
PagezeteReport No: 291 160AL
Mult rf n
A
DUT Reasings|
‘Standards Uncertainty(k2)
Published Uncertainty
‘TUR!
Standards Uncertainty(k=2)
Published Uncertanty
TuR|RAACAM conromnon
‘<8 Viet Doan Ras
(e489) USA,
eae serrate 3s7 200s
Wemmmadeacan € verdoegracestcom
DYNALYZER TANK REF
DEC 80 FILTER SET
‘Thermometer, 1927C
SETRA SIGNAL CONDITIONER
DYN. DISPLAY
APPENDIX -A-
Report No: 29176DAL,
358.041219
349.092718
768-111318
347-052819
369-042919
‘564604
112071519
345-032819
726073119
585-092818
703-100118
Note" Raden! poley 11634 proves up 30 eye pon cl uw at fr sada rcal ton
0 OF REPORT
31-4day-2020
30-Apr-7020
30-Jun-2020
3t-Ju2021
‘-btar-2020
31-Jul-2020
30-Se0-2019
31-04-2019
Paaw acta