ol: BASF
The Chemical Company
Safety data sheet
Page: 1/7
BASF Safety data sheet according to 91/155/EEC,
Date / Revised: 14.12.2006 Version: 5.0
Product: Latekoll* D
(30041410/SDS_GEN_GB/EN)
Date of print 22.01.2007
1. Substance/preparation and company identification
Latekoll* D
Use: Raw material, for industrial use only
Company:
BASF Aktiengesellschatt
67056 Ludwigshafen
GERMANY
Contact address:
BASF PLC
PO Box 4, Earl Road
Cheadle Hulme, Cheshire
GREAT BRITAIN
SKB 6QG.
Telephone: +44 161 485-6222
E-mail address: product-safety-north@basf.com
Emergency informatior
Telephone: +49 180 2273-112
Telefax number: +49 621 60-92664
2. Composition/information on ingredients
Chemical nature
‘Aqueous dispersion of a polymer based on: acrylic ester, carboxylic acids, unsaturated
3. Hazard identification
No particular hazards known,
[If the product adheres to skin, irritation may occur when it dries.Page: 2/7
BASF Safety data sheet according to 91/155/EEC.
Date / Revised: 14.12.2006 Version: 5.0
Product: Latekoll* D
(30041410/SDS_GEN_GB/EN)
Date of print 22.01.2007
4. First-aid measures
General advice:
Remove contaminated clothing.
if inhaled:
Keep patient calm, remove to fresh air, seek medical attention.
(On skin contact:
Wash thoroughly with soap and water.
(On contact with eyes:
Immediately wash affected eyes for at least 15 minutes under running water with eyelids held open,
consult an eye specialist.
(On ingestion:
Rinse mouth imme
tely and then drink plenty of water, seek medical attention.
5, Fire-fighting measures
Suitable extinguishing medi
water spray, dry extinguishing media, foam, carbon dioxide
6. Accidental release measures
Methods for cleaning up or taking up:
For small amounts: Pick up with suitable absorbent material (e.g. sand, sawdust, general-purpose
binder, kieselguhr). Dispose of absorbed material in accordance with regulations.
For large amounts: Pump off product.
For residues: Rinse away with water.
7. Handling and storage
Handle in accordance with good industrial hygiene and safety practice.
No special measures necessary provided product is used correctly.
Storag
Further information on storage conditions: Store protected against freezing,
8, Exposure controls and personal protectionCULL
‘018947001520305001070122,
Page: 3/7
BASF Safety data sheet according to 91/155/EEC
Date / Revised: 14.12.2006
Product: Latekoll* D
Version: 5.0
(30041410/SDS_GEN_GB/EN)
Date of print 22.01.2007
Personal protective equipment
Hand protection:
Suitable chemical resistant safety gloves (EN 374) also with prolonged, direct contact
(Recommended: Protective index 6, corresponding > 480 minutes of permeation time according to
EN 374): E.g. nitrile rubber (0.4 mm), chloroprene rubber (0.5 mm), butyl rubber (0.7 mm) and other
‘Supplementary note: The specifications are based on own tests, literature data and information of
glove manufacturers or are derived from similar substances by analogy. Due to many conditions
(@.g. temperature) it must be considered, that the practical usage of a chemical-protective glove in
practice may be much shorter than the determined permeation time.
Eye protection:
‘Safety glasses with side-shields (frame goggles) (e.g. EN 166)
General safety and hygiene measures:
Hands and/or face should be washed before breaks and at the end of the shift. Avoid contact with
skin and eyes.
9. Physical and chemical properties
Form:
Colour.
Odour:
PH value:
Information on: water
liquid
white
faintly aromatic
approx. 2.8 (DIN ISO 976)
Information on: water
boiling temperature:
Flash point:
Information on: water
Vapour pressure:
Density
Misciilty with water:
Viscosity, dynamic:
Solids content:
100°C
(1,000 hPa)
Not applicable
23 mbar
(20°C)
approx. 1.05 g/cm3
(20°C)
(IN 51757)
miscible
15-20mPas
(23°C, 100 1/s)
(IN EN ISO 2555)
approx. 25 %