Technical Service Information
SOLID TEFLON STATOR SEALING RINGS
SEAL
No.1
SEAL
No.2
SOLID TEFLON RING TOOLS FOR STATOR
J-39855-1 = INSTALLER FOR RING NO.1
3J-39855-2 = INSTALLER FOR RING NO.2
5J-39855-3 = RESIZER FOR BOTH RINGS
STATOR SHAFT coRRECTLY
SEALING RINGS INSTALLED
Figure 143
Continued from Page 76.
32. Install new "SOLID" Teflon sealing 5. Install the complete oil pump assembly
rings on stator shaft, using the into the transnission case using the
new installation and resizing tools alignment dovels as shown Figure 144.
shown in Figure 143. 6. Install of] pump retaining bolts, and
33. Install the of1 pump to case “o” remove the alignaent dowels, install
ring into the groove in the off the remaining bolts.
pump body. 7. Torque all of1 punp retaining bolts to
34, The chanfered edge of the "O" ring 18 fe.lbs.
should be facing out, and make sure 8. Install the proper “O" ring on turbine
that it is not twisted in groove. shaft AFTER end clearance is checked
35. Lubricate the "0" ring with TransJel and properly set (See Figure 146).
and also the sealing rings. cavttoN,
36. O11 punp assembly 1s now ready for There should be clearance between the
assembly into the transmission.
a7 eee sate Shy Eranamésston reverse input housing and the sun gear
resizing tool in place over the
solid Teflon seals until you are
ready to install the oil pump.
INSTALL OTL PUMP ASSEMBLY
1, Install off punp to case gasket into
the case and retain with TransJel
2, Install alignment dovels into the
transmission case as shown in Figure
1a,
3. Lubricate case pump bore where the
"o" ring rides with TransJel for ease
of installation.
4, Install new "0" rings onto the front
Punp retaining bolts.
shell, as shown in Figure 145.
7 ALGNMENT PIS
1 PUMP ASSEMBLY, OL
LS"
Figure 14a
AUTOMATIC TRANSMISSION SERVICE GROUP
78‘TURBINE SHAFT
"Oo" RING
Exo CLeanance OF APPROX. 3 8mm 380
@ CASE THaNGMSSION
25 ROUSING AND GMUNT ASSEMBLY, REVERSE INPUT
ewuren
670 SHELL, REACTION SUN
Figure 145
cAUTION:
‘There should be clearance between the
reverse input housing and the
shell, as shown in Figure 145.
installed these two parts have a normal
end clearance of approximately .150". Figure 146
DO NOT try to shim the internal parts
because of this clearance.
AUTOMATIC TRANSMISSION SERVICE GROUP
9Technical Service Information
‘TRANSMISSION END PLAY
WASHER SELECTION CHART
18719 mee (oe) o
204-214 mm 000" oo
221-231 mm (oar 09071 o
228-248 mm (one 0867 »
288-265 mm 900" 10071 n
272-282 mm Gora ”
269-298 mm Gene) n
206-316 mm Lo 20) u
Figure 148
‘A. 280mm TURBINE SHAFT fieraiceo
8 2asimm TURBINE SHAFT
Figure 147
‘A IALINDICATOR
8 226mm (199 BOLT
e toccnur
615 BEARING ASSEMBLY, STATOR SHAFT
Selective wasnen
616 WASHER, THRUST (SELECTIVE
G2) HOUSING AND SHAFT ASSEMBLY, INPUT
Figure 149 Figure 150
AUTOMATIC TRANSMISSION SERVICE GROUP
80