Documentos de Académico
Documentos de Profesional
Documentos de Cultura
com
Accessory Application Publications No.
AII 32951
INSTALLATION AUTOMATIC DAY/NIGHT
CR-V
MIRROR Issue Date
INSTRUCTIONS SEP 2006
Clip
Ground bolt
© 2006 American Honda Motor Co., Inc. – All Rights Reserved AII 32951 (0609) 08V03-SWA-1000-91 1 of 8
Illustration of the Day/Night MIirror 3. Carefully remove the right and left map light lens
Installed on the Vehicle from the roof console (four tabs for each lens).
MIRROR
DAY/NIGHT HARNESS
MIRROR ROOF
CONSOLE
RETAINING
TABS (4)
RETAINING
TABS (4)
LEFT MAP
LIGHT LENS
FUSE BOX RIGHT MAP
LIGHT LENS
6312070B
6308150Y
INSTALLATION 4. Remove the roof console (four bolts and unplug the
vehicle connectors).
Customer Information: The information in this
installation instruction is intended for use only by skilled
technicians who have the proper tools, equipment, and
training to correctly and safely add equipment to your
vehicle. These procedures should not be attempted by
“do-it-yourselfers.”
1. Make sure you have the anti-theft code for the radio, ROOF
CONSOLE
then write down radio station presets.
2. Disconnect the negative cable from the battery.
VEHICLE
CONNECTOR
SILVER
BOLTS BLACK
BOLTS 6313021Y
2 of 8 AII 32951 (0609) © 2006 American Honda Motor Co., Inc. – All Rights Reserved
5. Remove the cover from the left sunvisor (four 8. Remove the cover from the mirror (two retaining
retaining tabs). tabs). Lift up the mirror while pulling the base,
and remove the mirror.
RETAINING
TABS (2) COVER MIRROR
RETAINING
TABS (4) Lift up.
BASE Pull.
COVER
LEFT SUNVISOR
TORX
SCREWS
6311
MIRROR
BASE
6. Remove the two T-25 TORX screws, pull out the left
sun visor, and remove the sunvisor.
7. Remove the right and left sunvisor holders. Using a
flat-tip screwdriver, push in on the tab and rotate the MIRROR
holder.
6823040B
FLAT-TIP
SCREWDRIVER
RIGHT
Push. SUNVISOR
HOLDER
CAPS (2)
SUNVISOR LEFT FRONT
Turn. HOLDERS (2) GRAB RAIL
FLAT-TIP
SCREWDRIVER
6308170Y
LEFT FRONT
GRAB RAIL
CAP
6311161B
© 2006 American Honda Motor Co., Inc. – All Rights Reserved AII 32951 (0609) 3 of 8
10. Using needle nose pliers, remove the left front grab 12. Remove the left A-pillar trim (two clips).
rail (two clips).
CLIPS (2)
CLIPS (2)
LEFT FRONT
GRAB RAIL
NEEDLE
NOSE
PLIERS DOOR
OPENING
SEAL
LEFT A-PILLAR
TRIM
6311181B
LEFT FRONT
GRAB RAIL
6311170B 13. Remove the left front door sill trim (three clips).
11. Remove the front door opening seal around the
A-pillar trim. Using a rubber mallet, strike the top of CLIPS (3)
the A-pillar trim, in the area marked “SIDE CURTAIN
AIRBAG”, to release the clip. Remove the clip.
Pull.
VEHICLE VEHICLE
VEHICLE
BODY CLIP
Pushed deep BODY LEFT FRONT DOOR
behind the SILL TRIM
vehicle panel.
6303090B
PART MARKED AS
DOOR “SIDE CURTAIN AIRBAG”
OPENING
SEAL
VEHICLE
CLIP
LEFT FRONT
A-PILLAR TRIM
4 of 8 AII 32951 (0609) © 2006 American Honda Motor Co., Inc. – All Rights Reserved
14. Remove the front door opening seal from around the NOTE: If another accessory is already plugged into the 6-
left kick panel. Remove the left kick panel (two clips). pin connector opening of the fuse box, remove the dummy
connector from the 6-pin connector taped to the automatic
CLIPS (2) day/night mirror harness. Plug the 6-pin connector from
the other accessory harness into the
6-pin connector from the automatic day/night mirror har-
ness you just unplugged and plug the automatic day/night
DOOR OPENING mirror harness into the 6-pin connector opening of the
SEAL fuse box.
6-PIN CONNECTOR
OPENING of the OTHER ACCESSORY
FUSE BOX 6-PIN CONNECTOR
DUMMY
CONNECTOR
LEFT KICK
PANEL AUTOMATIC DAY/
6303100B
NIGHT MIRROR
HARNESS 6-PIN
15. Plug the automatic day/night mirror harness 6-pin CONNECTOR
connector into the empty 6-pin connector opening of
the fuse box.
AUTOMATIC DAY/
NIGHT MIRROR
FUSE BOX OPEN HARNESS
6-PIN CONNECTOR FUSE BOX OPEN
6-PIN CONNECTOR 16. Attach a piece of steel wire to the automatic day/
night mirror harness, and route it through the left
front pillar trim opening.
STEEL
WIRE
FUSE
BOX
AUTOMATIC DAY/NIGHT
MIRROR HARNESS
6627080B
© 2006 American Honda Motor Co., Inc. – All Rights Reserved AII 32951 (0609) 5 of 8
17. Route the automatic day/night mirror harness behind 19. Route the automatic day/night mirror harness above
the fuse box. the headliner from the left A-pillar to the middle of the
vehicle.
6311191B
18. Remove the steel wire. Route the automatic day/
night mirror harness along the vehicle harness as 20. Plug the automatic day/night mirror into the day/night
shown. Loosely secure the day/night mirror harness mirror 7-pin connector.
to the vehicle harness with the four wire ties.
AUTOMATIC DAY/
AUTOMATIC DAY/ NIGHT MIRROR
NIGHT MIRROR HARNESS 7-PIN
HARNESS CONNECTOR
AUTOMATIC DAY/
NIGHT MIRROR
HARNESS
VEHICLE MIRROR
HARNESS BASE
LEFT
A- PILLAR
AUTOMATIC DAY/
WIRE TIE Up. NIGHT MIRROR
LEFT FRONT
PILLAR TRIM TORX
OPENING SCREW 6311202B
682301
6 of 8 AII 32951 (0609) © 2006 American Honda Motor Co., Inc. – All Rights Reserved
22. Using isopropyl alcohol on a shop towel, thoroughly 25. Remove the vehicle bolt from the fuel lid opener.
clean the areas where the EPT sealer will attach. Attach the automatic day/night mirror harness
Secure the automatic day/night mirror harness to the ground terminal with the ground bolt supplied.
headliner with three EPT sealers.
FUSE
BOX
EPT SEALER
GROUND
BOLT
VEHICLE
BOLT
(Not used.)
AUTOMATIC DAY/
NIGHT MIRROR FUEL LID
HARNESS OPENER
HEADLINER AUTOMATIC DAY/
NIGHT MIRROR
HARNESS
AUTOMATIC DAY/NIGHT HARNESS
6311211B
GROUND TERMINAL 6823030B
AUTOMATIC DAY/
NIGHT MIRROR
HARNESS
HARNESS
COVER
FUSE
BOX
AUTOMATIC DAY/
NIGHT MIRROR
WIRE
TIE
AUTOMATIC DAY/
NIGHT MIRROR 6312062B
WIRE TIE
AUTOMATIC DAY/
NIGHT MIRROR
HARNESS 6312042B
© 2006 American Honda Motor Co., Inc. – All Rights Reserved AII 32951 (0609) 7 of 8
27. Remove and discard the upper vehicle clip from the 30. Check that all wire harnesses are routed properly
left A-pillar. and all connectors are plugged in.
31. Reinstall all removed parts.
32. Reconnect the negative cable to the battery.
VEHICLE
CLIP 33. Enter the customer’s audio and navigation system
Remove. (if equipped) anti-theft codes, and reset the XM radio
presets.
CLIP 34. Reset the clock.
NOTE: Check the operation of the automatic day/night
mirror according to the Operating Instructions supplied.
LEFT
A-PILLAR Place the Operating Instructions in the glove box for your
customer.
LEFT
A-PILLAR
TRIM PIN
6305010H
28. Check that the left A-pillar trim and the pin are not
damaged, then, install the new clip from the kit on the
pin.
29. Position the clip at right angles near the hole in the
left A-pillar. Install the clip by lightly pushing the left
A-pillar trim at the part marked as “SIDE CURTAIN
AIRBAG”. Check that the airbag is not pinched with
the clip, and be careful not to push the left A-pillar
trim excessively
LEFT CLIP
A-PILLAR
VEHICLE
PANEL
CLIP
PART MARKED AS
“SIDE CURTAIN AIRBAG”
LEFT A-PILLAR
TRIM 65190
8 of 8 AII 32951 (0609) © 2006 American Honda Motor Co., Inc. – All Rights Reserved