Documentos de Académico
Documentos de Profesional
Documentos de Cultura
0|
|*|Clifton Golf Estate - BOQ|
COUNTER|ISC|SECTION|BILL|PAGE NO|ITEM NO|PAY REF|DESCRIPTION|UNIT|QUANTITY|RATE|
AMOUNT
|||||||RATES Rates 21/03/02||||
1|3418|1|1|1|||BILL NO 1 |H1|0.0|
2|3419|1|1|1|||PRELIMINARIES |H1|0.0|
3|3420|1|1|1|||--------------------------------------- ||0.0|
|||||||
|||||||
6|3423|1|1|1|||PRELIMINARIES |H2|0.0|
11|3428|1|1|1|||Where any item is not relevant to this specific contract such item
is||0.0|
||||||| marked N/A (signifying "not applicable")
|||||||
|||||||
13|3430|1|1|1|||Tenderers shall allow opposite each clause for any cost involved
with||0.0|
||||||| complying with such clause. Any clauses left unpriced shall be deemed to
||||||| be covered by rates and prices elsewhere incorporated throughout these
||||||| Bills of Quantities.
|||||||
|||||||
15|3432|1|1|1|||Should 'Alternative A', as set out within clause 10.3 of the JBCC
2000||0.0|
||||||| Preliminaries, be used for the adjustment of preliminaries then each item
||||||| priced is to be allocated to one or more categories by the insertion of the
||||||| letter "F", "V" or "T", as the case may be, against the price in the rate
||||||| column. These letters shall indicate the relevant categories as follows :
|||||||
|||||||
17|3434|1|1|2|||---------------------------------------- ||0.0|
|||||||
|||||||
19|3436|1|1|2||| |H2|0.0|
|||||||
|||||||DEFINITIONS
21|3438|1|1|2|||OBJECTIVE |H2|0.0|
23|3440|1|1|2|||PREPARATION |H2|0.0|
36|3453|1|1|3|||EXECUTION |H2|0.0|
45|3462|1|1|3|||COMPLETION |H2|0.0|
54|3471|1|1|4|||PAYMENT |H2|0.0|
60|3477|1|1|5|||CANCELLATION |H2|0.0|
65|3482|1|1|5|||DISPUTE |H2|0.0|
67|4109|1|1|5||| ||0.0|
|||||||
|||||||
69|3485|1|1|5||| |H2|0.0|
|||||||
|||||||THE SCHEDULE
71|3487|1|1|5|||---------------------------------------- ||0.0|
|||||||
|||||||
73|3489|1|1|6|||Clause ||0.0|
|||||||
|||||||
88|3504|1|1|8|||41.2.6 Period for the commencement of the works after the ||0.0|
|||||||
||||||| contractor takes possession of the site
|||||||
|||||||
|||||||
||||||| Working days : Five (5)
|||||||
|||||||
94|3510|1|1|9||| ||0.0|
|||||||
|||||||41.3 INSURANCES
|||||||
|||||||
106|3522|1|1|10|||--------------------------------------- ||0.0|
|||||||
|||||||
108|3524|1|1|11||| |H2|0.0|
|||||||
|||||||1.0 DEFINITIONS AND INTERPRETATION
171|3587|1|1|14||| |H2|0.0|
|||||||
|||||||12.0 SCHEDULE OF VARIABLES
174|3590|1|1|14|||Clause ||0.0|
|||||||
|||||||(and reference)
|||||||
|||||||
196|3612|1|1|16|||--------------------------------------- ||0.0|
|||||||
|||||||
204|3620|1|1|17|||Dayworks |H3|0.0|
208|3624|1|1|17|||Hourly based rates for labour shall be the current market rates
for labour||0.0|
||||||| based upon standard working hours and shall be applied in respect of the
||||||| time spent by workers directly engaged on the particular dayworks
||||||| including any operators operating mechanical plant and transport and
||||||| erecting and dismantling other plant.
|||||||
|||||||
209|3625|1|1|18|||If a claim is made that individual workmen have been paid wages
and||0.0|
||||||| allowances in excess of the minimum legalised rates, then proof must be
||||||| furnished that such workmen had been so paid prior to the
||||||| commencement of the extra work referred to.
|||||||
|||||||
221|3637|1|1|19|A||As the windows are fixed they shall be glazed and prepared so
that each|Item|1|
||||||| window can be tested for watertightness with water sprayed on by means
||||||| of a 25mm hosepipe using adequate pressure. If the pressure proves to
||||||| be inadequate, in the opinion of the architect, then the pressure in the
||||||| hosepipe shall be boosted by means of compressed air or other
||||||| approved means. Each window section shall be tested under the
||||||| supervision of the clerk of works and approved before final acceptance.
|||||||
|||||||
|||||||
222|3638|1|1|19|||Guarantees |H3|0.0|
227|3643|1|1|19|||Overtime |H3|0.0|
|||||||
|||||||
229|3645|1|1|19|||GENERAL |H2|0.0|
230|3646|1|1|19|||Copyright |H3|0.0|
232|79|1|2|21|||BILL NO 2 |H1|0.0|
233|80|1|2|21|||EARTHWORKS |H1|0.0|
235|81|1|2|21|||--------------------------------------- ||0.0|
|||||||
|||||||
241|2346|1|2|21|||----------------------------------------- ||0.0|
|||||||
|||||||
244|84|1|2|21|A||Trenches |m3|192|00.00|0000.00
245|2077|1|2|21|B||Holes |m3|2|00.00|00.00
|||||||
|||||||
246|85|1|2|21|C||Trenches and holes for thickening under surface bed etc |m3|4|
00.00|000.00
250|89|1|2|21|E||Sides of trench and hole excavations not exceeding 1,5m deep |m�|
485|0.00|0000.00
251|90|1|2|21|||Keeping excavations free of water |H3|0.0|
261|99|1|3|24|||BILL NO 3 |H1|0.0|
264|101|1|3|24|||---------------------------------------- ||0.0|
|||||||
|||||||
268|2352|1|3|24|||Formwork |H3|0.0|
271|2355|1|3|24|||Concrete |H3|0.0|
273|2429|1|3|24|||---------------------------------------- ||0.0|
|||||||
|||||||
277|2078|1|3|24|B||Bases |m3|1|000.00|000.00
|||||||
|||||||
291|115|1|3|25|G||Making and testing 150 x 150 x 150mm concrete strength test cube
|No|10|00.00|000.00
295|2892|1|3|25|||FORMWORK |H1|0.0|
298|2593|1|3|25|J||Beams |m2|16|00.00|0000.00
301|120|1|3|25|M||Edges, risers, ends and reveals not exceeding 300mm high or wide
|m|106|00.00|0000.00
304|123|1|3|26|A||Slabs |m2|172|00.00|00000.000
305|122|1|3|26|B||Landings |m2|4|00.00|000.00
307|4072|1|3|26|D||Beams |m2|3|00.00|000.00
308|125|1|3|26|||Permanent formwork to soffits |H3|0.0|
318|127|1|3|26|||REINFORCEMENT |H1|0.0|
329|137|1|4|29|||BILL NO 4 |H1|0.0|
332|2430|1|4|29|||--------------------------------------- ||0.0|
|||||||
|||||||
335|142|1|4|29|A||Pyramid shaped capping size 470 x 470 x 140mm high extreme with|
No|4|000.00|000.00
||||||| 105mm thick base including bedding to top of brick pier in cement mortar
336|3361|1|4|29|B||Flat chimney cowl size 690 x 760mm with 85mm thick base,
including|No|1|000.00|000.00
||||||| bedding on top of chimney
|||||||
|||||||
337|3795|1|4|29|C||Flat chimney cowl size 860 x 690mm with 85mm thick base,
including|No|1|000.00|000.00
||||||| bedding on top of chimney
|||||||
|||||||
338|145|1|5|30|||BILL NO 5 |H1|0.0|
339|146|1|5|30|||MASONRY |H1|0.0|
341|2431|1|5|30|||--------------------------------------- ||0.0|
|||||||
|||||||
343|2361|1|5|30|||BRICKWORK |H2|0.0|
350|2432|1|5|30|||--------------------------------------- ||0.0|
|||||||
|||||||
351|148|1|5|30|||BRICKWORK |H2|0.0|
360|150|1|5|31|C||Steps |m3|0.3|000.00|000.00
361|152|1|5|31|D||Piers |m3|5|000.00|0000.00
362|151|1|5|31|E||Chimneys |m3|6|000.00|0000.00
380|178|1|5|32|B||Closing 50mm cavity of hollow wall along gable with one course
of|m|38|00.00|0000.00
||||||| brickwork including shaping gable
382|180|1|5|32|D||200 x 300mm Fibre cement flue liners built into chimney brickwork
|m|10|000.00|0000.00
|||||||
|||||||
383|3890|1|5|32|E||Extra over 200 x 300mm fibre cement flue liners for bend |No|2|
000.00|000.00
|||||||
|||||||
393|2099|1|5|32|M||30 x 1,6mm Wall tie 400mm long with both ends built into
brickwork over|No|430|0.00|0000.00
||||||| control joints
|||||||
|||||||
394|192|1|5|32|N||30 x 1,6mm Cramp 500mm long with one end fixed to wood and other|
No|264|0.00|0000.00
||||||| end built into brickwork
397|198|1|6|34|||BILL NO 6 |H1|0.0|
398|199|1|6|34|||WATERPROOFING |H1|0.0|
400|2433|1|6|34|||--------------------------------------- ||0.0|
|||||||
|||||||
402|2380|1|6|34|||Waterproofing |H3|0.0|
404|2434|1|6|34|||--------------------------------------- ||0.0|
|||||||
|||||||
416|3149|1|6|34|G||Side wall flashing strip, including sealing top edge into groove
with mastic |m|22|00.00|000.00
|||||||
|||||||
433|231|1|7|37|||BILL NO 7 |H2|0.0|
436|2435|1|7|37|||--------------------------------------- ||0.0|
|||||||
|||||||
439|236|1|7|37|A||Roof covering with pitch not exceeding 50 degrees with side laps
sealed|m2|79|00.00|0000.00
|||||||
|||||||
450|247|1|8|38|||BILL NO 8 |H1|0.0|
453|2436|1|8|38|||--------------------------------------- ||0.0|
|||||||
|||||||
459|2384|1|8|38|||Joinery |H3|0.0|
461|2386|1|8|38|||Fixing |H3|0.0|
465|2437|1|8|38|||--------------------------------------- ||0.0|
|||||||
|||||||
469|261|1|8|39|A||50 x 150mm Rafters exceeding 2,4m and not exceeding 3,9m |m|45|
00.00|0000.00
482|258|1|8|39|M||50 x 220 x 60mm Blocking pieces cut to fit under purlins |No|26|
00.00|000.00
483|2802|1|8|39|N||50 x 275 x 125mm Blocking pieces cut to fit under purlins |No|
13|00.00|000.00
|||||||
|||||||
493|332|1|8|40|||SKIRTINGS |H2|0.0|
494|3723|1|8|40|||Supawood |H3|0.0|
497|336|1|8|40|||DOORS |H2|0.0|
504|3177|1|8|40|H||Type GS, size 762 x 2032mm high consisting of 44mm solid single
panel|No|1|0000.00|0000.00
||||||| door with planted meranti panel and mouldings and 140 x 45mm twice
||||||| rebated and twice grooved framed lining
|||||||
|||||||
505|4035|1|8|40|J||Type KK, size 1200 x 1300mm high consisting of 44mm double
framed|No|1|0000.00|0000.00
||||||| and ledged doors and 95 x 70mm once rebated, once moulded and twice
||||||| grooved frame
|||||||
|||||||
509|356|1|8|41|||WINDOWS |H2|0.0|
523|3999|1|8|42|||Supawood |H3|0.0|
532|385|1|8|42|J||32 x 290mm Window cill, once rounded and once rebated |m|33|
000.00|0000.00
538|2553|1|8|42|M||75 x 75mm Posts with scalloped corners fixed with and including
10mm|m|8|000.00|0000.00
||||||| diameter x 200mm long galvanised mild steel threaded bar one end
||||||| drilled and epoxied into slab and the other end epoxied into post
|||||||
|||||||
548|3949|1|8|43|J||25 x 150mm Capping with shadow line to bottom edges plugged to|
m|5|00.00|000.00
||||||| brickwork
|||||||
|||||||
549|4053|1|8|43|K||35 x 260mm Capping with shadow line to bottom edges plugged to|
m|1|000.00|000.00
||||||| brickwork
|||||||
|||||||
550|388|1|9|45|||BILL NO 9 |H1|0.0|
553|2438|1|9|45|||--------------------------------------- ||0.0|
|||||||
|||||||
555|2390|1|9|45|||Descriptions |H3|0.0|
557|2439|1|9|45|||--------------------------------------- ||0.0|
|||||||
|||||||
562|4096|1|9|45|B||19mm Scotia|m|21|00.00|000.00
|||||||
|||||||
563|392|1|9|45|||Supawood |H3|0.0|
580|2630|1|10|48|||BILL NO 10 |H1|0.0|
583|2632|1|10|48|||--------------------------------------- ||0.0|
|||||||
|||||||
588|408|1|11|49|||BILL NO 11 |H1|0.0|
589|409|1|11|49|||IRONMONGERY |H1|0.0|
591|2440|1|11|49|||--------------------------------------- ||0.0|
|||||||
|||||||
597|3903|1|11|49|||--------------------------------------- ||0.0|
|||||||
|||||||
603|4062|1|11|49|D||100 x 38mm Brass hasp and staple (W&B product code B1469) |No|
1|00.00|00.00
|||||||
|||||||
610|1719|1|11|50|||"Hallmark" |H3|0.0|
612|1721|1|11|50|||LOCKS |H2|0.0|
618|1726|1|11|50|||HANDLES |H2|0.0|
635|1737|1|11|51|||SUNDRIES |H2|0.0|
639|490|1|12|53|||BILL NO 12 |H1|0.0|
640|491|1|12|53|||METALWORK |H1|0.0|
642|2441|1|12|53|||--------------------------------------- ||0.0|
|||||||
|||||||
644|2394|1|12|53|||Descriptions |H3|0.0|
646|2442|1|12|53|||--------------------------------------- ||0.0|
|||||||
|||||||
649|501|1|12|53|A||Bolts |kg|3|00.00|000.00
650|521|1|12|53|B||8mm Threaded rod 150mm long one end epoxied into brickwork and
the|No|2|00.00|00.00
||||||| other end epoxied into timber
|||||||
|||||||
651|523|1|12|53|C||10mm Diameter threaded bar 450mm long one end epoxied into|No|2|
00.00|00.00
||||||| brickwork and the other end epoxied into timber
|||||||
|||||||
652|2714|1|12|53|D||10mm Diameter treaded bar 850mm long with one end flanged and
cast|No|4|00.00|00.00
||||||| 600mm deep into column and the other end fixed through timber,
||||||| including nut and 40mm diameter spacer washer
|||||||
|||||||
656|4058|1|12|54|A||Panel pivot door 1000 x 1800mm high with fixed side panel 1000
x|No|4|0000.00|00000.00
||||||| 1800mm high with 700 x 1000mm cut-out
657|509|1|12|54|||FIREPLACES |H2|0.0|
658|510|1|12|54|||"FireJack" |H3|0.0|
661|517|1|12|54|||Sundries |H3|0.0|
663|525|1|13|56|||BILL NO 13 |H1|0.0|
664|526|1|13|56|||PLASTERING |H1|0.0|
666|2443|1|13|56|||--------------------------------------- ||0.0|
|||||||
|||||||
667|529|1|13|56|||SCREEDS |H2|0.0|
703|565|1|13|57|Q||3 x 32mm Flat section galvanised mild steel water bar embedded
in floor|m|5|00.00|000.00
||||||| finish
704|567|1|13|57|||SUNDRIES |H2|0.0|
707|569|1|14|59|||BILL NO 14 |H1|0.0|
708|570|1|14|59|||TILING |H1|0.0|
710|2444|1|14|59|||--------------------------------------- ||0.0|
|||||||
|||||||
712|1630|1|14|59|||Descriptions |H3|0.0|
714|2445|1|14|59|||--------------------------------------- ||0.0|
|||||||
|||||||
724|2624|1|14|59|||Extra over ceramic tiles for inset tiles size 200 x 200mm (PC
Sum|H3|0.0|
||||||| R100,00/No excluding VAT, delivered to site) tile fixed with suitable
||||||| adhesive to manufacturers recommendations to plaster (plaster
||||||| elsewhere) and flush pointed with tinted jointing compound
725|2625|1|14|59|F||On walls |No|5|000.00|000.00
|||||||
|||||||
742|2622|1|14|60|||Extra over floor tiles for tile inserts size 80 x 80mm (PC Sum|
H3|0.0|
||||||| R100,00/No excluding VAT, delivered to site) fixed with suitable
||||||| adhesive to manufacturers recommendations to bedding (bedding
||||||| elsewhere) and flush pointed with tinted waterproof jointing
||||||| compound
746|677|1|15|62|||BILL NO 15 |H1|0.0|
749|2446|1|15|62|||--------------------------------------- ||0.0|
|||||||
|||||||
757|1772|1|15|63|||Excavations ||0.0|
|||||||
|||||||
|||||||
|||||||No claim for rock excavation will be entertained unless the contractor has
||||||| timeously notified the quantity surveyor thereof prior to backfilling
|||||||
|||||||
|||||||
|||||||"Soft rock" and "hard rock" shall be as defined in "Earthworks"
|||||||
|||||||
762|2447|1|15|63|||--------------------------------------- ||0.0|
|||||||
|||||||
763|1778|1|15|63|||DRAINAGE |H2|0.0|
781|1795|1|15|64|||Sundries |H3|0.0|
786|3322|1|15|64|P||Cutting into existing drain pipe for and forming junction with
110mm pipe |No|1|000.00|000.00
|||||||
|||||||
787|1798|1|15|64|||Testing |H3|0.0|
789|1679|1|15|65|||PLUMBING |H2|0.0|
792|2810|1|15|65|A||250 x 100mm Box gutters with and including hail guard over |m|
7|000.00|0000.00
|||||||
|||||||
793|2811|1|15|65|B||Extra over 250 x 100mm box gutter for stopped end |No|2|00.00|
000.00
|||||||
|||||||
794|2812|1|15|65|C||Extra over 250 x 100mm box gutter for outlet for 100mm pipe |
No|1|00.00|00.00
|||||||
|||||||
799|1685|1|15|65|G||Extra over gutter for outlet for 75mm uPVC downpipe |No|5|
00.00|00.00
|||||||
|||||||
801|2825|1|15|65|H||50mm Overflow pipe 300mm long with one end splay cut |No|1|
00.00|00.00
|||||||
|||||||
809|4007|1|15|65|Q||Single inset wash trough (PC Sum R575,00 each excluding VAT,|
No|1|000.00|000.00
||||||| delivered to site) set in joinery fitting, including sealing all round wash
||||||| trough with silicon sealant
|||||||
|||||||
810|3220|1|15|65|R||Double end bowl sink, (PC Sum R700,00 each excluding VAT,
delivered|No|1|0000.00|0000.00
||||||| to site) set in joinery fitting, including sealing all round sink with
silicon
||||||| sealant
|||||||
|||||||
811|4085|1|15|65|S||Vanity basin with one taphole (PC Sum R360,00 each excluding
VAT,|No|5|000.00|0000.00
||||||| delivered to site), including sealing between rim of basin and vanity slab
||||||| with silicon sealant
|||||||
|||||||
813|3836|1|15|66|B||600 x 400 x 200mm Deep laboratory sink (PC Sum R850,00 each|No|
1|0000.00|0000.00
||||||| excluding VAT, delivered to site) fixed underneath counter, including
||||||| sealing between sink and counter with silicon sealant
|||||||
|||||||
814|1807|1|15|66|C||Close coupled wall mounted wash down suite and 9 litre top
flush cistern|No|5|0000.00|00000.00
||||||| with double flap seat, including cast iron cradle bracket (PC Sum
||||||| R2200,00 each excluding VAT, delivered to site)
|||||||
|||||||
816|3830|1|15|66|E||1 800 x 800mm Bath (PC Sum R1100,00 each excluding VAT,
delivered|No|2|0000.00|0000.00
||||||| to site), including sealing edges of bath with silicon sealant
|||||||
|||||||
819|1813|1|15|66|F||38mm 316-40 CP Bath or sink waste union with plug and chain |
No|4|00.00|000.00
|||||||
|||||||
822|1815|1|15|66|||uPVC |H3|0.0|
824|2783|1|15|66|J||40 x 300mm Sink combination for double bowl with deep seal "P"
trap |No|1|00.00|00.00
828|3839|1|15|66|M||32 x 40mm 365 CP bidet bottle trap with outlet for 40mm uPVC |
No|1|000.00|000.00
830|1823|1|15|66|||Brass |H3|0.0|
838|2774|1|15|67|E||15mm Underwall stop tap (PC Sum R180,00 each excluding VAT,|No|
7|000.00|0000.00
||||||| delivered to site)
|||||||
|||||||
839|1838|1|15|67|F||15mm Single taphole sink mixer with swivel spout outlet and
angle|No|2|0000.00|0000.00
||||||| regulating valves (PC Sum R780,00 each excluding VAT, delivered to
||||||| site)
|||||||
|||||||
840|3907|1|15|67|G||15mm Single taphole tubular sink mixer with swivel spout outlet
with|No|1|0000.00|0000.00
||||||| 290mm throw, including angle regulating valves (PC Sum R920,00 each
||||||| excluding VAT, delivered to site)
|||||||
|||||||
842|3381|1|15|67|J||15mm Wall type bath mixer, including hand shower attachment (PC
Sum|No|2|0000.00|0000.00
||||||| R1150,00 each excluding VAT, delivered to site)
|||||||
|||||||
844|4017|1|15|67|L||15mm Built-in shower mixer with round cover plate (PC Sum
R515,00|No|4|000.00|0000.00
||||||| each excluding VAT, delivered to site)
|||||||
|||||||
845|3833|1|15|67|M||15mm Overhead shower arm with sliding wall flange (PC Sum
R35,00|No|4|000.00|0000.00
||||||| each excluding VAT, delivered to site)
|||||||
|||||||
850|2952|1|15|67|S||20mm Kent water meter in and including cast iron valve box |
No|1|000.00|000.00
|||||||
|||||||
870|1877|1|15|68|||Testing |H3|0.0|
886|3337|1|15|69|||Sundries |H3|0.0|
893|1899|1|15|69|K||1 700 x 650mm Drip tray with 100mm high upstand with top edge
bent|No|4|201.00|804.00
||||||| over all around including 50mm diameter overflow pipe 1 000mm long
||||||| approximately 5m above ground level
|||||||
|||||||
894|1900|1|15|69|||Testing |H3|0.0|
896|1902|1|15|69|||SLEEVES |H2|0.0|
901|2980|1|15|70|A||110mm Bend|No|5|00.00|000.00
|||||||
|||||||
905|2984|1|15|70|C||450 x 600mm x 68kg Type 9D cast iron single seal manhole cover
and|No|1|000.00|000.00
||||||| frame
908|1903|1|15|70|||PVC sleeves for pipes exceeding 100mm and not exceeding 200mm|
H3|0.0|
||||||| diameter
910|826|1|16|72|||BILL NO 16 |H1|0.0|
911|827|1|16|72|||GLAZING |H1|0.0|
913|2448|1|16|72|||--------------------------------------- ||0.0|
|||||||
|||||||
922|841|1|16|72|||MIRRORS |H2|0.0|
924|845|1|17|73|||BILL NO 17 |H1|0.0|
925|846|1|17|73|||PAINTWORK |H1|0.0|
927|2449|1|17|73|||--------------------------------------- ||0.0|
|||||||
|||||||
930|852|1|17|73|||One coat "Pliolite Based" masonry primer and two coats Pure|H3|
0.0|
||||||| Acrylic 240 S.C. paint
932|854|1|17|73|||One coat "Pliolite Based" masonry primer and two coats Acrylic
220|H3|0.0|
||||||| paint
934|856|1|17|73|||One coat "Pliolite Based" masonry primer and two coats Acrylic
200|H3|0.0|
||||||| S.C.
944|864|1|17|74|B||On backs of frames, linings, etc not exceeding 300mm wide |m|
823|0.00|0000.00
945|2755|1|17|74|||One coat white wood primer, one coat universal undercoat and
two|H3|0.0|
||||||| coats "Thixogel" satin enamel paint
951|865|1|17|74|||One coat white wood primer, one coat universal undercoat and two|
H3|0.0|
||||||| coats high gloss enamel paint
961|4091|1|17|74|||Two coats universal undercoat and two coats Acrylic 220 paint |
H3|0.0|
974|901|1|18|77|||BILL NO 18 |H1|0.0|
977|2450|1|18|77|||--------------------------------------- ||0.0|
|||||||
|||||||
979|3008|1|18|77|||EARTHWORKS |H2|0.0|
995|1935|1|18|78|A||Trenches |m3|30|00.00|000.00
|||||||
|||||||
996|2535|1|18|78|B||Holes |m3|2|00.00|00.00
|||||||
|||||||
1008|2536|1|18|78|G||Bases |m3|1|000.00|000.00
|||||||
|||||||
1010|1967|1|18|78|J||Steps |m3|0.1|000.00|00.00
|||||||
|||||||
1017|2537|1|18|79|||REINFORCEMENT |H3|0.0|
1023|1993|1|18|79|||MASONRY |H2|0.0|
1025|2540|1|18|79|D||Piers |m3|2|000.00|0000.00
1033|2526|1|18|79|J||30 x 1,6mm Wall tie 400mm long with both ends built into
brickwork over|No|115|0.00|000.00
||||||| control joints
|||||||
|||||||
1036|2529|1|18|80|||WATERPROOFING |H2|0.0|
1041|2007|1|18|80|||GATES |H3|0.0|
1046|2012|1|18|80|||IRONMONGERY |H2|0.0|
1047|2013|1|18|80|||HINGES, BOLTS, ETC |H3|0.0|
1048|2014|1|18|80|||Brass |H3|0.0|
1051|2017|1|18|80|||Brass |H3|0.0|
1053|2019|1|18|80|||PLASTERING |H2|0.0|
1061|2036|1|18|81|||PAINTWORK |H2|0.0|
1064|2039|1|18|81|||One coat Acrylic 200 high cover (2m2 per litre), fill
imperfections|H3|0.0|
||||||| with external filler mixed with aggregate, one coat masonry primer
||||||| to filled areas and two coats Acrylic 200 high cover (5m2 per litre)
1070|2498|1|18|81||| ||0.0|
|||||||
|||||||
|||||||
|||||||
1086|2921|1|18|82|||Sundries |H3|0.0|
1093|3015|1|18|82|L||230 x 230mm x 6kg Cast iron dished grating and frame |No|16|
000.00|0000.00
|||||||
|||||||
1094|3298|1|18|82|M||450 x 450mm x 26kg Cast iron dished grating and frame |No|2|
000.00|000.00
|||||||
|||||||
1095|2963|1|18|82||| ||0.0|
|||||||
|||||||
|||||||
|||||||
1108|2480|1|18|83|||Grassing |H3|0.0|
1111|2001|1|18|83|||PAVING |H1|0.0|
1126|3308|1|18|84|||Grey cement cobble paving with butt joints on 25mm thick river|
H3|0.0|
||||||| sand bed with sand and cement mixture swept into joints and
||||||| hosed down, including preparation of ground or filling
1134|2848|1|18|84|||Grey Inca "K" grass blocks 600 x 400 x 90mm thick |H3|0.0|
1136|2465|1|18|84|||Precast paving slabs 450 x 450 x 50mm thick laid with 50mm
wide|H3|0.0|
||||||| exposed aggregate joints on 50mm thick river sand bed
1145|955|1|19|87|||BILL NO 20 |H1|0.0|
1148|2452|1|19|87|||--------------------------------------- ||0.0|
|||||||
|||||||
1182|3233|1|19|89|A||Allow the sum of R10 000,00 (Ten Thousand Rand) NET for the
gas|Item|1||10000.00
||||||| installation, including gas cylinders to be executed by a sub-contractor
1208|3417|1|20|92|1||PRELIMINARIES |Page|20|0|143400.00
1209|1613|1|20|92|2||EARTHWORKS |Page|23|0|34391.60
1212|1606|1|20|92|5||MASONRY |Page|33|0|186123.40
1213|1615|1|20|92|6||WATERPROOFING |Page|36|0|17033.85
1218|1617|1|20|92|11||IRONMONGERY |Page|52|0|20222.30
1219|1609|1|20|92|12||METALWORK |Page|55|0|36383.40
1220|1618|1|20|92|13||PLASTERING |Page|58|0|103894.60
1221|1610|1|20|92|14||TILING |Page|61|0|65231.00
1223|1611|1|20|92|16||GLAZING |Page|72|0|18799.70
1224|1620|1|20|92|17||PAINTWORK |Page|76|0|59871.80