Documentos de Académico
Documentos de Profesional
Documentos de Cultura
S W I T C H E S & S Y S T E M S
Technical Characteristics
Passive Infrared Detector - 1M (101210) 101210
The Passive Infrared Detector is an energy saving Auto Switch. It turns ON when a person enters the
detection field and turns OFF when the person leaves. The unit is designed with adjustable light
threshold sensors & time delay cycles. Equipped with micro controller chip, this device is designed to save
electrical energy and reduce electrical bills.
B C
Smart Passive Infrared Detector - 2M (102212)
This infrared device is a new generation smart motion sensor switch with adjustable light threshold sensors
& time delay cycles. This unit is designed with selectable ON, OFF & Auto Function switch. Equipped with
micro controller chip, this device is designed to be used as an energy-saving switch.
Specifications 102212
• Relay output
• Detection (view) angle: 1200 A
Installation
1. Choose installation position according to your need. The sensitivity of the device is greater when movement is across the switch instead of
when a person is moving towards it. So, for optimum response, install the product in such position that people move across the sensor.
2. Avoid installing the device where it gets exposed to direct sunlight.
3. Avoid installing it near a heat source, e.g. air conditioning, heating duct or stove.
Operations
Light Settings
The Passive Infrared Detector and Smart Passive Infrared Detector both have settings for light detection and time delays. The light detection option
allows you to decide the light intensity at which the associated device should be switched ON. If you move the Light Setting dial to its maximum
position in a clock-wise manner, the device will get activated only when it detects movement when there is daylight. It will also switch on during
Twilight and Dark conditions. If you keep the Light Setting dial at the center, the device will get activated only when it detects the presence of a
person during Twilight or total Darkness. If you move the dial to its maximum position in an Anti-clockwise direction, the presence detector will
activate the device only if it detects a person in total darkness.
Example of use
Installation Notes
• Do not install in boxes where there are thermostats.
• Do not exceed the rated power level.
• On completing installation, power up the appliance and check its operating status.
• Can be installed on normally flammable surfaces. F
• Do not install the unit behind any obstruction.
• Avoid sun rays or direct light beam falling directly on the unit.
Safety instruction
• Electrical equipment must be installed and fitted by a qualified electrician only.
• The electronic switches are single pole switches and disconnect only one pole when they are OFF.
• Before working on the appliance, to prevent electric shock, disconnect both the poles of the main supply.
• Failure to observe any of the installation instructions may result in fire and other safety hazards.
Warranty
All electronic devices are warranted against manufacturing defects for two years from the date of purchase. In the event of defects, Goldmedal
will repair or, at its discretion, replace the warranted product if delivered to a Goldmedal authorized dealer along with a duly stamped guarantee
card or sales receipt that shows the date of purchase along with the serial no. of the product. This warranty excludes defects due to abnormal
load, abuse, or failure to use the product in accordance with the instructions. Goldmedal shall not be liable for any other damages, whether
incidental, consequential or otherwise.
Wiring Diagram
L L
N N
Load Load
Cu ve
102212
240V~ 50-60Hz
: 1000 W F
UP
: 1000 VA
: 700 VA
: 300W (Max)
N L1 L N L1 L
101210 102212
Dimensions (mm) Side view shows overall dimensions & flush depth.
53.40 53.40
33.45 33.45
101210 102212
Version 1.10 dt. 22/11/14
© Copyright 2003 by
Goldmedal Unless otherwise specified, the products illustrated in this Leaflet have been designed X
F
by Goldmedal and are covered by one or more international patents.