Documentos de Académico
Documentos de Profesional
Documentos de Cultura
TK-2000
SERVICE MANUAL
REVISED © 2012-4 PRINTED IN JAPAN
B51-8937-10 (Y) PDF
CONTENTS
Knob(Selector)
(K29-9488-03)
GENERAL ....................................................2
Knob (Volume) SYSTEM SET-UP .........................................3
Helical antenna (K29-9487-03)
(T90-1094-05) REALIGNMENT ...........................................3
DISASSEMBLY FOR REPAIR .....................6
CIRCUIT DESCRIPTION .............................7
SEMICONDUCTOR DATA .........................10
COMPONENTS DESCRIPTION ................11
PARTS LIST ...............................................12
EXPLODED VIEW ......................................17
Knob (PTT)
(K29-9489-13) ADJUSTMENT ...........................................18
Button knob (Side) PC BOARD
(K29-9490-13)
TX-RX UNIT (X57-8093-00) ....................22
SCHEMATIC DIAGRAM ............................26
BLOCK DIAGRAM .....................................30
LEVEL DIAGRAM ......................................32
Plastic cabinet assy
SPECIFICATIONS ......................................33
(A02-4135-13)
This product complies with the RoHS directive for the European market. This product uses Lead Free solder.
TK-2000
B51-8937-10
TK-2000 136~174 *1 K, M From B2200631 J79-0362-09
(This service manual)
GENERAL
INTRODUCTION PERSONAL SAFETY
SCOPE OF THIS MANUAL The following precautions are recommended for personal
This manual is intended for use by experienced techni- safety:
cians familiar with similar types of commercial grade com- • DO NOT transmit until all RF connectors are verified
munications equipment. It contains all required service secure and any open connectors are properly terminated.
information for the equipment and is current as of the pub- • SHUT OFF and DO NOT operate this equipment near
lication date. Changes which may occur after publication electrical blasting caps or in an explosive atmosphere.
are covered by either Service Bulletins or Manual Revisions. • This equipment should be serviced by a qualified techni-
These are issued as required. cian only.
2
TK-2000
SYSTEM SET-UP
Merchandise received
Delivery
REALIGNMENT
1. Modes 2. How to Enter Each Mode
Mode Operation
User mode
User mode Power ON
PC mode Received commands from PC
PC mode Data programming mode
Clone mode [PTT]+[Side]+Power ON (Two seconds)
3. PC Mode
3-1. Preface
Mode Function
The transceiver is programmed by using a personal com-
User mode For normal use. puter, a programming interface (KPG-22A/22U) and FPU
Used for communication between the trans- programming software (KPG-137D : ver.2.20 or later).
PC mode The programming software can be used with a PC. Fig-
ceiver and PC.
ure 1 shows the setup of a PC for programming.
Data programming Used to read and write frequency data and
mode other features to and from the transceiver.
3-2. Connection Procedure
Used to check the transceiver using the PC. 1. Connect the transceiver to the personal computer with
PC test mode
This feature is included in the FPU. the interface cable.
Used to transfer programming data from Note:
Clone mode
one transceiver to another. • You must install the KPG-22 driver in the computer to use
the USB programming interface cable (KPG-22U).
3
TK-2000
REALIGNMENT
2. When the POWER is switched on, user mode can be No. Frequency (MHz)
entered immediately. When the PC sends a command, 11 172.79375
the transceiver enters PC mode. 12 172.79500
When data is read from the transceiver, the red LED 13 172.80000
lights.
14 172.80500
When data is written to by the transceiver, the green LED
15 172.80625
lights.
Note:
• The data stored in the personal computer must match 3-6. Programming with PC
Model Name and Model Type when it is written into EE- If data is transferred to the transceiver from a PC with the
PROM. FPU, the data for each set can be modified.
• Do not press the [PTT] key during data transmission or Data can be programmed into the EEPROM in RS-232C
reception. format via the SP/MIC jack.
In this mode the PTT line operate as TXD and RXD data
3-3. KPG-22A Description lines respectively.
(PC programming interface cable: Option)
The KPG-22A is required to interface the transceiver with
the computer. It has a circuit in its D-sub connector (KPG-22A: PC KPG-22A or KPG-22U or
9-pin) case that converts the RS-232C logic level to the TTL Illustration is KPG-22A.
level.
The KPG-22A connects the SP/MIC connector of the
transceiver to the RS-232C serial port of the computer.
Gray +
3-5. Programming Software KPG-137D Description SP
Gray/Black –
The KPG-137D is the programming software for the
1.5D-XV Lead wire +
transceiver supplied on a CD-ROM. This software runs un- MIC
1.5D-XV Shield wire –
der windows XP, Vista or 7 on a PC. The software on this
disk allows a user to program the transceiver via Program-
ming interface cable (KPG-22A/22U). Tuning cable
(E30-3216-05)
Note:
• Use the FPU that matches the market when you first set
the market code and model name/frequency data to the
service unit. The unit set by mistake cannot be restored.
• Receive frequencies listed below may result in the in-
terference of reception due to the harmonics of internal
oscillators. Enter a frequency not listed in the table.
4
TK-2000
REALIGNMENT
4. Clone mode Note:
Programming data can be transferred from one trans- • The Model name and Market codes must be the same in
ceiver to another by connecting them via their SP/MIC con- order to clone the transceiver.
nectors. • If the transceivers clone mode is configured as “Disabled”,
Cloning can be performed as described below (the trans- the transceiver cannot enter clone mode.
mit transceiver is the source and the receive transceiver is • If the Read authorization password is set to the trans-
the target). ceiver, the transceiver cannot enter to the clone mode.
• Cannot be cloned if the password (overwrite password) is
The following data cannot be cloned. programmed to the target.
• Tuning data
• Model name data
• ESN data
Cloning cable
(E30-3410-05)
1. Turn the source transceiver and target transceiver power
OFF.
2. Turn the source transceiver power ON while pressing the
[PTT] and [Side] keys, to enter clone mode.
3. Connect the cloning cable (part No. E30-3410-05) to the
SP/MIC connectors on the source and target transceiv-
ers.
4. Turn the target transceiver power ON.
5. Press the [Side] key on the source transceiver. The data of
the source is sent to the target. While the source is send-
ing data, red LED will light. While the target is receiving
the data, green LED will light. When cloning of data is
completed, the source red LED turned off, and the target
automatically operates in the User mode.
6. Additional targets can be continuously cloned. When
the [Side] key on the source is pressed, the data of the
source is sent to the target again. Repeat steps 3 to 5 to Fig. 2
clone additional transceivers.
5
TK-2000
DISASSEMBLY FOR REPAIR
1. Separating the Case Assembly from the 2. Removing the TX-RX unit from the
Chassis Chassis
1. Remove the two knobs (a). 1. Remove the packing (e).
2. Remove the two screws (b). 2. Remove the 13 screws (f).
3. Expand the right and left sides of the bottom of the case 3. Remove the packing (g) and two hexagon nuts (h).
assembly, Iift the chassis, and remove it from the case 4. Remove the solder from the antenna terminal using a
assembly (c). soldering iron then lift the unit off (i).
Note:
When reassembling the unit in the chassis, be sure to
b a solder the antenna terminal.
a
b i
Antenna terminal
g
c f
h
4. Taking care not to cut the speaker lead (d), open the
chassis and case assembly.
e
Note:
Solder the speaker wire back in its original position if you
have removed it.
–
3. Removing the Rear Panel
1. Raise the rear panel on the chassis (j).
d BRN
+
GRN
6
TK-2000
CIRCUIT DESCRIPTION
1. Frequency Configuration
The receiver utilizes double conversion. The first IF is
38.85MHz and the second IF is 450kHz. The first Local os-
cillator is supplied from the PLL circuit.
The PLL circuit in the transmitter generates the neces-
sary frequencies.
CF
TX/RX: 136~174MHz 450kHz
ANT
MIC
TX RF PLL MIC
AMP AMP VCO AMP
136~174MHz
2. Receiver System
The receiver system is shown in Figure 2.
CF200
ANT
Q204 Q203 Q202 IC303 IC302
BPF RF AMP BPF 1st MIX XF200 IF AMP AFfilter VR500 AF PA SP
ANT IC200
SW IF,MIX,DET
MCF
7
TK-2000
CIRCUIT DESCRIPTION
2-3. IF Amplifier Circuit 3. Transmitter System
The first IF signal is passed through a four-pole mono-
lithic crystal filter (XF200) to remove the adjacent channel 3-1. Microphone Amplifier Circuit
signal. The signal from microphone amplified by IC301 and goes
The filtered first IF signal is amplified by the first IF ampli- through mute switch (IC300).
fier (Q202) and then applied to the lF system IC (IC200). IC304 is composed of high-pass filter, low-pass filter and
The IF system IC provides a second mixer, second local pre-emphasis/IDC circuit.
oscillator, limiting amplifier, quadrature detector and RSSI The output signal from the DAC IC (IC300) goes to the
(Received Signal Strength Indicator).The second mixer VCO modulation input.
mixes the first IF signal with the 38.4MHz of the second lo-
cal oscillator output (TCXO X1) and produces the second IF MIC IC300
signal of 450kHz. VCO
The second IF signal is passed through the ceramic filter IC301
(CF200) to remove the adjacent channel signal. The filtered BUFF DAC X1
second IF signal is amplified by the limiting amplifier and
demodulated by the quadrature detector with the ceramic LSDO TCXO
discriminator (CD201).The demodulated signal is routed to MIC
the audio circuit. AMP
LSDO
IC304
2-4. Audio Amplifier Circuit
The demodulated signal from IC200 is amplified by
IC305, IC303 and goes to AF amplifier through IC302. Fig. 3 Microphone amplifier circuit
The signal then goes through an volume control (VR500),
and is routed to an audio power amplifier (IC302) where it is 3-2. Driver and Final Amplifier Circuit
amplified and output to the speaker. The signal from the T/R switch (D100 is on) is amplified
To output sounds from the speaker, IC400 sends a high by the pre-drive amplifier (Q100) to 30mW.
signal to the SPMUT line and turns IC400 on through Q300, The output of the pre-drive amplifier is amplified by the
Q301, Q302 and Q306. drive amplifier (Q101) and the RF final amplifier (Q102) to
5.0W (1W when the power is low).
The drive amplifier and the RF final amplifier consist of
two MOS FET stages.
The output of the RF final amplifier is then passed
through the harmonic filter (LPF) and antenna switch (D101
and D102) and is applied to the antenna terminal.
ANT
CURDET
8
TK-2000
CIRCUIT DESCRIPTION
4. Frequency Synthesizer Circuit Note:
The EEPROM stores tuning data (Deviation, Squelch,
4-1. Frequency Synthesizer etc.).
The frequency synthesizer consists of the TCXO (X1), Realign the transceiver after replacing the EEPROM.
VCO, PLL IC (IC1) and buffer amplifiers.
The TCXO generates 19.2MHz. The frequency stability is
5.0 ppm within the temperature range of –30 to +60°C.
The frequency tuning and modulation of the TCXO are
6. Signaling Circuit
done to apply a voltage to pin 1 of the TCXO. The output of 6-1. Encode
the TCXO is applied to pin 1 of the PLL IC. ■ Low-speed data (QT, DQT)
The VCO consists of 1VCO and covers a dual range of Low-speed data is output from pin 49 (LSDO) of the MCU
the 136.00~174.00MHz and the 174.85~212.85MHz. The (IC400). The signal passes through a low-pass CR filter. The
VCO generates 174.85~212.85MHz for providing to the first signal is mixed with the audio signal and goes to the VCO
local signal in receive. and TCXO (X1) modulation input after signal processing in
The PLL IC consists of a prescaler, reference divider, the DAC IC (IC300).
phase comparator, charge pump (The frequency step of the
PLL circuit is 5 or 6.25 kHz). ■ High-speed data (DTMF)
PLL data is output from DATA (pin 19), CLOCK (pin 18) High-speed data (HSD) is output from pin 50 (HSDO) of
and PLDL (pin 20) of the MCU (IC400). The data are input to the MCU.
the PLL IC when the channel is changed or when transmis- The signal passes through a low-pass CR filter. TX devia-
sion is changed to reception and vice versa. A PLL lock con- tion making an adjustment by MCU is applied to the DAC IC
dition is always monitored by the pin 22 (PLUL) of the MCU. (IC300). The signal is mixed with the audio signal and goes
When the PLL is unlocked, the PLUL goes low. to the VCO and TCXO.
50 18 19
HSDO VCO
Fig. 5 PLL block diagram MOD
12
BEEP AF
AMP
5. Control Circuit
The control consists of the MCU (IC400) and its peripher-
Fig. 6 Encode
al circuits. It controls the TX-RX unit. IC400 mainly performs
the following;
1) Switching between transmission and reception by PTT
signal input. 7. Power Supply
2) Reading channel information, frequency, and program There are five 5V power supplies for the MCU:
data from the memory circuit. 5M is always output while the power is on.
3) Sending frequency program data to the PLL. 5C is a common 5V and is output when SAVE is not set
4) Controlling squelch on/off via the DC voltage from the to ON.
squelch circuit. 5R is 5V for reception and output during reception.
5) Controlling the audio mute circuit via the decode data 5T is 5V for transmission and output during transmission.
input. 5MS is 5V for the SP/MIC connector and the DAC IC
6) Transmitting tone and encode data. (IC300).
9
TK-2000
SEMICONDUCTOR DATA
MCU: F2136ACNKDRB (TX-RX unit IC400) Pin No. Signal Name I/O Function
Pin No. Signal Name I/O Function 45 NC O NC
1 NC O NC 46 NC O NC
2 VREF - Reference voltage input 47 VOXIN I VOX level input
3 MODE I Mode select for MCU 48 CVDET I VCO voltage detection
4 NC O NC 49 LSDO O Low speed data output
5 NC O NC 50 HSDO O DTMF/beep output
6 RESET I Reset signal input 51 BATT I Battery voltage input
7 XOUT O Oscillation circuit 52 RSSI I RSSI input
13 NC O NC 58 5VC O 5V control
14 NC O NC 59 NC O NC
10
TK-2000
COMPONENTS DESCRIPTION
TX-RX unit (X57-8093-00) Ref. No. Part Name Description
Ref. No. Part Name Description Variable capaci-
D2 Frequency control/ VCO
tance diode
IC1 IC PLL system
Variable capaci-
IC200 IC FM IF system D3 Frequency control/ VCO
tance diode
IC300 IC DAC D4 Diode TX/RX RF switch
IC301 IC LSD buffer Variable capaci-
D5 Modulator /TX VCO
IC302 IC AF power AMP tance diode
Variable capaci-
IC303 IC AF filter D6 Frequency control/ VCO
tance diode
IC304 IC MIC AMP
D7 Diode Ripple filter
IC305 IC QT/DQT filter
D100 Diode TX/RX RF switch
IC400 IC MCU
D101 Diode ANT switch
IC401 IC EEPROM
D102 Diode ANT switch
IC500 IC Voltage detector/RESET
D103 Diode ANT switch
IC501 IC Voltage regulator/5V
D200 Diode TX/RX RF switch
IC503 IC Voltage regulator/5V Variable capaci-
D201 RX BPF tuning
Q1 Transistor DC switch tance diode
Q2 Transistor TX/RX RF switch Variable capaci-
D202 RX BPF tuning
tance diode
Q3 Transistor Ripple filter
Variable capaci-
Q4 FET VCO D203 RX BPF tuning
tance diode
Q5 Transistor RF buffer AMP Variable capaci-
D204 RX BPF tuning
Q6 Transistor RF AMP tance diode
11
TK-2000
PARTS LIST
✽ New Parts. indicates safety critical components. L : Scandinavia K : USA P : Canada
Parts without Parts No. are not supplied. Y : PX (Far East, Hawaii) T : England E : Europe
Les articles non mentionnes dans le Parts No. ne sont pas fournis. C : China X : Australia M : Other Areas
Teile ohne Parts No. werden nicht geliefert.
TK-2000
TX-RX UNIT (X57-8093-00)
New
Ref. No. Address parts Parts No. Description Desti- New
Ref. No. Address parts Parts No. Description Desti-
nation nation
C 1A,2A N83-2005-48 PAN HEAD TAPTITE SCREW(X57) C33 CC73HCH1H470J CHIP C 47PF J
28 1B T07-0787-05 SPEAKER C34 CK73HB1H102K CHIP C 1000PF K
C35 CC73HCH1H150J CHIP C 15PF J
C36 CC73HCH1H120G CHIP C 12PF G
C37 CC73HCH1H150J CHIP C 15PF J
12
TK-2000
PARTS LIST
TX-RX UNIT (X57-8093-00)
13
TK-2000
PARTS LIST
TX-RX UNIT (X57-8093-00)
New
Ref. No. Address parts Parts No. Description Desti- Ref. No. New
Address parts Parts No. Description Desti-
nation nation
C360 CK73HB1A104K CHIP C 0.10UF K L212 L40-8281-86 SMALL FIXED INDUCTOR(0.82UH)
C397 CK73HB1H102K CHIP C 1000PF K L213 L40-5681-86 SMALL FIXED INDUCTOR(0.56UH)
C400 CK73HB1A104K CHIP C 0.10UF K L215 L41-8278-14 SMALL FIXED INDUCTOR(82NH)
C401 CK73HB1H102K CHIP C 1000PF K X1 L77-3074-05 TCXO(19.2 MHZ)
C402 CC73HCH1H120J CHIP C 12PF J X400 L77-2974-05 CRYSTAL RESONATOR(11.0592MHZ)
14 If a part reference number is listed in a shaded box, that part does not come with the PCB.
TK-2000
PARTS LIST
TX-RX UNIT (X57-8093-00)
R207 RK73HB1J562J CHIP R 5.6K J 1/16W R347 RK73HB1J103J CHIP R 10K J 1/16W
R208 RK73HB1J101J CHIP R 100 J 1/16W R348 RK73HB1J183J CHIP R 18K J 1/16W
R209 RK73HB1J470J CHIP R 47 J 1/16W R350 RK73HB1J471J CHIP R 470 J 1/16W
R210 RK73HB1J334J CHIP R 330K J 1/16W R351 RK73HB1J561J CHIP R 560 J 1/16W
R211 RK73HB1J272J CHIP R 2.7K J 1/16W R352 RK73HB1J104J CHIP R 100K J 1/16W
R212 RK73HB1J184J CHIP R 180K J 1/16W R353 RK73HB1J102J CHIP R 1.0K J 1/16W
R213 RK73HB1J102J CHIP R 1.0K J 1/16W R354 RK73HB1J334J CHIP R 330K J 1/16W
R214 RK73HB1J681J CHIP R 680 J 1/16W R355 RK73HB1J473J CHIP R 47K J 1/16W
R215 RK73HB1J331J CHIP R 330 J 1/16W R356 RK73HB1J183J CHIP R 18K J 1/16W
R216 RK73HB1J470J CHIP R 47 J 1/16W R357 RK73HB1J564J CHIP R 560K J 1/16W
R229 RK73HB1J152J CHIP R 1.5K J 1/16W R371 RK73HB1J822J CHIP R 8.2K J 1/16W
R230 RK73HB1J820J CHIP R 82 J 1/16W R372 RK73HH1J473D CHIP R 47K D 1/16W
R231 RK73HB1J471J CHIP R 470 J 1/16W R373 RK73HB1J000J CHIP R 0 J 1/16W
R232,233 RK73HB1J104J CHIP R 100K J 1/16W R374 RK73HH1J473D CHIP R 47K D 1/16W
R234 RK73HB1J184J CHIP R 180K J 1/16W R375 RK73HB1J103J CHIP R 10K J 1/16W
R236,237 RK73HB1J105J CHIP R 1.0M J 1/16W R376 RK73HH1J473D CHIP R 47K D 1/16W
R260 RK73HB1J273J CHIP R 27K J 1/16W R377 RK73HB1J393J CHIP R 39K J 1/16W
R264 RK73HB1J394J CHIP R 390K J 1/16W R378 RK73HB1J102J CHIP R 1.0K J 1/16W
R267,268 RK73HB1J000J CHIP R 0 J 1/16W R379 RK73HB1J104J CHIP R 100K J 1/16W
R300 RK73HB1J152J CHIP R 1.5K J 1/16W R386 RK73HB1J392J CHIP R 3.9K J 1/16W
R301 RK73HB1J101J CHIP R 100 J 1/16W R388 RK73HB1J822J CHIP R 8.2K J 1/16W
R302 RK73HB1J102J CHIP R 1.0K J 1/16W R389 RK73HB1J102J CHIP R 1.0K J 1/16W
R303 RK73HB1J471J CHIP R 470 J 1/16W R390 RK73HB1J000J CHIP R 0 J 1/16W
R304 RK73HB1J473J CHIP R 47K J 1/16W R392,393 RK73HB1J102J CHIP R 1.0K J 1/16W
R305-308 RK73HB1J102J CHIP R 1.0K J 1/16W R394 RK73HB1J000J CHIP R 0 J 1/16W
R317 RK73HB1J334J CHIP R 330K J 1/16W R408 RK73HB1J101J CHIP R 100 J 1/16W
R318 RK73HB1J274J CHIP R 270K J 1/16W R409,410 RK73GB2A221J CHIP R 220 J 1/10W
R321 RK73HB1J474J CHIP R 470K J 1/16W R411,412 RK73HB1J472J CHIP R 4.7K J 1/16W
R322 RK73HB1J105J CHIP R 1.0M J 1/16W R413 RK73HB1J102J CHIP R 1.0K J 1/16W
R323 RK73HB1J562J CHIP R 5.6K J 1/16W R414 RK73HB1J474J CHIP R 470K J 1/16W
15
TK-2000
PARTS LIST
TX-RX UNIT (X57-8093-00)
New
Ref. No. Address parts Parts No. Description Desti- Ref. No. New
Address parts Parts No. Description Desti-
nation nation
R505 RK73HB1J473J CHIP R 47K J 1/16W Q501 SSM3J05FU-F FET
R508 RK73HB1J473J CHIP R 47K J 1/16W Q502 RT1P237U-T111 TRANSISTOR
R509 RK73HB1J104J CHIP R 100K J 1/16W TH100 B57331V2104J THERMISTOR(100K)
R511 RK73HB1J334J CHIP R 330K J 1/16W
R512 RK73GB2A271J CHIP R 270 J 1/10W
D1 DA2S101 DIODE
D2 ,3 1SV325F VARIABLE CAPACITANCE DIODE
D4 HSC277 DIODE
D5 ,6 HVC350B VARIABLE CAPACITANCE DIODE
D7 DA2S101 DIODE
Q1 RT1N141U-T111 TRANSISTOR
Q2 RT1N436U-T111 TRANSISTOR
Q3 2SC5383-T111 TRANSISTOR
Q4 MCH3914(7)-H FET
Q5 2SC5488A-H TRANSISTOR
Q6 2SC5636 TRANSISTOR
Q7 2SC5383-T111 TRANSISTOR
Q100 2SC4926YD TRANSISTOR
Q101 RFM01U7P FET
Q102 RD07MUS2BT112 FET
16 If a part reference number is listed in a shaded box, that part does not come with the PCB.
TK-2000
EXPLODED VIEW
A B
23
24
25 22
28
20
9 18
8
11
S400
Cx13
4
MIC300 J301
J300
2
VR500
101 CF200
S402
CD200 10
TX-RX unit 13
7
16
A
19
3
B 15
14 B
3
701
A : N09-2438-05
700 12 B : N30-2606-48
26 C : N83-2005-48
Parts with the exploded numbers larger than 700 are not supplied.
17
If a part reference number is listed in a box on the exploded view of the PCB, that part does not come with the PCB.
These parts must be ordered separately.
TK-2000
ADJUSTMENT
Test Equipment Required for Alignment
Test Equipment Major Specifications
Frequency Range 136 to 174MHz
1. Standard Signal Generator (SSG) Modulation Frequency modulation and external modulation
Output –127dBm/0.1µV to greater than –47dBm/1mV
Input Impedance 50Ω
2. RF Power Meter Operation Frequency 136 to 174MHz
Measurement Range Vicinity of 10W
3. Deviation Meter Frequency Range 136 to 174MHz
Measuring Range 10mV to 10V DC
4. Digital Volt Meter (DVM)
Input Impedance High input impedance for minimum circuit loading
5. Oscilloscope DC through 30MHz
6. High Sensitivity Frequency Range 10Hz to 1000MHz
Frequency Counter Frequency Stability 0.2ppm or less
7. DC Ammeter 5A
Frequency Range 50Hz to 10kHz
8. AF Volt Meter (AF VM)
Voltage Range 1mV to 10V
Frequency Range 50Hz to 5kHz or more
9. Audio Generator (AG)
Output 0 to 1V
Capability 3% or less at 1kHz
10. Distortion Meter
Input Level 50mV to 10Vrms
11. Spectrum Analyzer Measuring Range 10kHz to 1GHz or more
Center frequency 50kHz to 600MHz
12. Tracking Generator
Output Voltage 100mV or more
13. 8Ω Dummy Load Approx. 8Ω, 3W
5V to 10V, approx. 3A
14. Regulated Power Supply
Useful if ammeter equipped
BATT+ (7.5V)
– +
BATT– (GND)
18
TK-2000
ADJUSTMENT
Frequency and Signaling Preparations for Tuning the Transceiver
The transceiver has been adjusted for the frequencies Before attempting to tune the transceiver, connect the
shown in the following table. When required, re-adjust them unit to a suitable power supply.
following the adjustment procedure to obtain the frequencies Whenever the transmitter is tuned, the unit must be con-
you want in actual operation. nected to a suitable dummy load (i.e. power meter).
The speaker output connector must be terminated with a
■ Test Frequency (MHz) 8Ω dummy load and connected to an AC voltmeter and an
audio distortion meter or a SINAD measurement meter at all
CH RX Frequency TX Frequency
times during tuning.
1 155.05000 155.10000
2 136.05000 136.10000 ■ Adjustment frequency (MHz)
3 173.95000 173.90000 Tuning point RX TX
4 155.00000 155.00000 Low 136.05000 136.10000
5 155.20000 155.20000 Center 155.05000 155.10000
6 155.40000 155.40000 High 173.95000 173.90000
7~16 - -
■ Signaling
No. RX (Decode) TX (Encode) Adjustment Points
1 None None TX-RX UNIT
Component side view
2 None 100Hz Square Wave
3 QT 67.0Hz QT 67.0Hz
4 QT 151.4Hz QT 151.4Hz CV ‒+
MIC300 ANT
5 QT 210.7Hz QT 210.7Hz CV: VCO Lock Voltage
6 QT 254.1Hz QT 254.1Hz
7 DQT D023N DQT D023N BATT+
S401
S400 Side KEY
PTT
J301
SP
J300
MIC
19
TK-2000
ADJUSTMENT
Common Section
Measurement Adjustment
Item Condition Test- Specifications / Remarks
Unit Terminal Unit Parts Method
equipment
1. Setting 1) BATT terminal voltage: 7.5V
2) SSG standard modulation
[Wide]
MOD: 1kHz, DEV: 3kHz
[Narrow]
MOD: 1kHz, DEV: 1.5kHz
2. VCO Lock 1) Adj item: High Power TX-RX ANT FPU 4.1V ±0.1V
Voltage meter (CV)
Transmitter Section
Measurement Adjustment
Item Condition Test- Specifications / Remarks
Unit Terminal Unit Parts Method
equipment
1. Frequency 1) Adj item: High f. counter TX-RX ANT FPU 173.900MHz ±50Hz
Press [Transmit] button.
2. High 1) Adj item: Low, Center, High Power FPU 4.8W ±0.1W
Transmit (3 points) meter 2.0A or less
Power and BATT terminal voltage: 7.5V Ammeter
Protective Press [Transmit] button.
Current
*Note
3. Low 1) Adj item: Low, Center, High 1.0W ±0.1W
Transmit (3 points) 1.0A or less
Power BATT terminal voltage: 7.5V
Press [Transmit] button.
4. DQT 1) Adj item: Low, Center, High Power TX-RX ANT FPU Make the modulation
Balance (3 points) meter SP/MIC wave into square
[Wide] (Signaling Square Wave) Deviation connector waves.
Deviation meter filter meter
LPF: 3kHz Oscilloscope
HPF: OFF AG
Press [Transmit] button. AF VM
6. Battery 1) BATT terminal voltage: 5.9V DVM TX-RX BATT FPU Write BATT terminal voltage: 5.9V
Warning terminal
Level
7. Battery 1) BATT terminal voltage: 5.7V Power ANT Check LED blinks
Detection PTT: ON meter BATT No transmit power
Check DVM terminal
(User mode) 2) BATT terminal voltage: 7.5V LED does not blink
PTT: ON
• It is not necessary to adjust the fixed values for the DTMF-DEV, DQT-DEV, QT-DEV, and MIC sensitivity.
• The TX-DEV Narrow setting uses the Wide calculated adjustment level value.
*Note: Please do not adjust High Transmit power without connecting TX Power meter or 50 ohm dummy load to the ANT terminal.
20
TK-2000
ADJUSTMENT
Receiver Section
Measurement Adjustment
Item Condition Test- Specifications / Remarks
Unit Terminal Unit Parts Method
equipment
1. Sensitivity 1) Adj item: Low, High (2 points) SSG TX-RX ANT Check 12dB SINAD or more
Check SSG output: –115dBm DVM SP/MIC
[Narrow] (0.4µV) Oscilloscope connector
SSG DEV: 1.5kHz AF VM
21
A B C D E F G H I J
1 TK-2000 PC BOARD
2
TX-RX UNIT (X57-8093-00) Component side view (J79-0362-09)
C322
Q304
R367
C333
C332
R392
3 C523 C329
R360 C345
C342
R355 C336
R393 C134
1 8
R347
C340 R356
R357 R358
IC304
CN3
CV
C139
4 5
C330
R334
R344
C517 C353
C321 C323
C355
R386
R332
D301
R120
C326 C316 R136
4 R340
1 8 R329
IC301
C158
Q103
R328
R377 C319
C313
R325
C354 C317
4 5
R324
R327
C124
CN404
R389 C360
R396
C309
5 R116
R18 C6
CN202
CN403
R400
19 12
C311
R313
R473
Q502
C516
R316 IC300
R370
C350 R315
CN401
R323
R372 R322 24 7 C310
CN508
1 6
C524 D402
6
R305
R306
R307
R455
R374
C352
R376
R433
R375
C349
R373
Q305
R388
R371
Q400
7
R414
R413
64 49
C400 R401
CN2
48
C401
C403
X400
CN1
C402
IC400
C406
8 C407
CN201
CN200
C408 R438
1 8
IC401
R411
4 5
R412
9
Note : for service unit
J79-0362-09
10
13
22
14
J K L M N O P Q R S
PC BOARD TK-2000 1
CN506
C411
Q501
D
R407
R408
CN507
3
S
C507
C506
C514
C409
R406
– + R509
CN504
C515 1 5
C503
IC500 Q301
4
1 4 ANT
IC501
3 4
C306
C312
Q300
2 3
R321
4
3
R508 C513 C308
C522
C505 R502
R317
C504
C511
CN510
Q306
R330
R505 D501
S
R511
C124
C145
S
D
G
R410 5
R121
R122
R123
CN511
Q500 R409
Q302
G
S
C315
CN505
C159
C314 R326
F500
BATT+
CN500
CN503
CN502
R318
R323
D500
6
10
6
C501
IC302
5
CN501
BATT–
Q303
D D
D D
S G
C324 SP–
C414 C412
C346 R350 (BRN) 7
R395
C320
F300
R336
C318
SP+
(GRN)
R331 R345 C325
4
R308
R312
C397
IC303
CF200
C358
D401
D400
R311
5
R378 R304
8
R379
C303
R310
R351
C337
C500
R340
CN303
R337 R302
CN302
R301
R309
C301
CN300 CN301
C304
D380
C335
R303
C305
CD200
9
10
Component side
Layer 1
Layer 2 11
Layer 3
Layer 4
Foil side
12
13
23
14
A B C D E F G H I J
1 TK-2000 PC BOARD
S401
S400 Side
R300
PTT
3 C300
C121
R119
R117
C129
C125
C123
C128
C126
C138 C136 C132
L109
L108
C122
L107
L106
C135 L105
4
C137
C127
L112
D101
D102
L104
C131
L111 R139
C146
L110 C250
C130
L210
L209
C119
TH100
D103
R115
C116
C120
C249
5 C117
R268
D203
R236
C248
C413 C415
Q204
L208
C247
G S
C243
R230
R229
6 G D
D202
R228
R232
R233
C246
R264
C245
R231
C302 + R234 C244 C256
S402
C357
R364
C343
C328 R390 R353
R363
C334
C341
Q401
R365
R361
C208
8
5
R
IC305
4
Q402
C212
8
C338
R369
R354 C344
R352 R366
J300
MIC
C347
J301
C339
VR500 SP
C202
C205
Q200
9
10
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address
IC1 8P Q7 9P Q401 7C D100 5N
11 IC200 8K Q100 4M Q402 8C D101 4F
IC305 8I Q101 5L D1 4P D102 4F
Q1 7P Q102 4K D2 4O D103 5G
Q2 4O Q200 9J D3 4O D200 6O
Q3 5O Q201 9N D4 4N D201 6K
12
Q4 5P Q202 8L D5 4O D202 6J
Q5 5P Q203 6M D6 4O D203 5I
Q6 6O Q204 6I D7 5O D204 6L
13
24
14
J K L M N O P Q R S
PC BOARD TK-2000 1
3
C43
C104 L101
R23
C9 L3
R12
R106
R105
C107
C113 L11 C13
R108 C152
R104
C105 C7
R111 R112
R113
D3
L1
C110 C108
L2
R22
D4
C114
R107
C109
C106
L102 R102
L4
C12
D5 D1
R101 R155
C2
C17
D2
C
E
Q100
D Q102 G R114 C112 C44 C8
D6
L5 R1
4
B
E
L104
R11
R109
Q2
L103
C53
R13
C21
C103
R103
C102
G
D
S Q101
C101 C22
L100
C111
C119 S
TH100
Q4
C20
C28
R30
R15
C18
C100 C11
F101
C116 G
D
L6
R100 + C25
C120
R42 C19 R27 5
C29
C117
C24
R29
R222 C262 D100 Q5
Q3
D7
R33
Q203
R45
C236
G S
R221 R223
D200
C42
C237 C232 R40 R39
G D
C32 L7
C242
C240 R226
C238
R32
L208
C253
C254
C234 L206
R38
C226
C230
C225
D201
D202
D204
C37
C35
R228 C39
R237
R219
C244 C256 C239 C227 R216 R37
C207 R203
C206
C210
C201
R206
C200 7
Q1
R9
R202
R201
R43
R2
C1
C223
C224
R361
C208
R214
8
R260
R26
R209
XF200 R19
R3
9
IC200 Q202 R21
C212
R17
L212
+ C5 8
16
R267
R34
C31 R16
C216
R212
R211
C26
R204
1
R28
R207 C209
C23
C211
C213
C27
R210 R208
R205
Q201
X1
C217
C215
C214
R44
R213
L213
C202
C205
C219
Q200 C220
9
R51
R50
C38
Q7
J79-0362-09
10
Component side
Layer 1
Layer 2 11
Layer 3
Layer 4
Foil side
12
13
25
14
TK-2000 SCHEMATIC DIAGRAM
TX-RX UNIT(X57-8093-00)
7 S3_A EN2
8 S3_C
9 S3_G
4 S2_A EN1
5 S2_C
6 S2_B EN3
1 S1_A
2 S1_C
3 S1_B EN4
S402
SELECTOR S60-0447-05 DATA DATA DATA
CLOCK CLOCK CLOCK
EN2 EN2
EN1 EN1
D A2 S1 0 1
EN3 EN3
S70-0414-05
EN4 EN4
D1
R1
1M
1000p
C409
LEDR
LEDG
R313
S400
10k
LSDO LSDO
PTT
R314
CURRENT
10k
STEERING T0 T0
5MS
LED DC SW LED DC SW
GREEN RED
R324
IC301
47k
LTC014YEBFS8 LTC014YEBFS8
NJM12904RB1 D400 Q401 D401 Q402
Side
C316
0.1u
Vref
24
23
22
21
20
19
1 8
R325
47k
V+
B30-1782-05 B30-1779-05
S70-0514-05
VIN1
VIN8
VoUT2
VoUT1
VoUT8
VoUT7
2 7
1000p
C411
18 - +
S401
R410
1
R409
VIN7
220
R328
220
VIN2 3 6
+ -
2 GND 1 7 680k
VDD D/A CONVERTER 4 5
RED LED
C313
GREEN LED
0.1u
GND
R305 1k 3 16
0.01u
C319
0.01u
ON:5.0V ON:5.0V
C317
R 2 A 2 0 1 7 8 N P RESET
R327
820k
LD
R306 1k 4 IC300 VDAREF2 1 5
LEDR
CLK LSD BUFFER
R307 1k 5 VDAREF1 14 LEDG
DI LSDO
13
C309
6 VIN6 C311
0.1u
R316 T0
VoUT3
VoUT4
VoUT5
VoUT6
VIN3
VIN4
VIN5
0 1u
R322
VREF
5MS
11
7
12
10
8
1M
VOXIN
R367 HSDO
47k
POWC
T91-0651-15
MIC MIC300
1000p
C300
R315
10k
R300 VREF
C336 R355
1.5k
C305 C323 0.01u 47k
1000p
C310
C345
DC SW
R309
0.01u 0.1u
R329
0.047u
R323
1.8k
10k
5.6k
1000p
C301
R303 CURRENT
R 3 96
D 3 0 1 STEERING 5VC
0
C304
1k 1u LTA023JEBFS8
C354
R377
0.22u
39k
C360
0.1u
180k
R332
R360
PTTSW KDR731
C322
1000p
R304 R311 2.7k
0.01u
C321
R386
3.9k
CN302
47k 47k
0.01u
C342
1 PTT/RXD R310
3 MIC R312
R302 1k 1k
1 1 IM
1 0 OPTDET 2.2k MIC AMP/LIMITER
2 5MS IC304
C303 R357
J300 R301 NJM12904RB1
0.033u
R392
C329
E11-0484-05 1 0 0 560k
1k
SP/MIC RXD 1 8
0.047u V+
PTT
R337
JACKS E11-0717-05
J301 2 7 C340
0
1 SPG R378 - +
OPTDET
3 TXD R334 R344 R347 3 6 10p
4 SPK
R379
1k + -
100k
GND
C330
8200p
C326
R340
10k
R358
R393
R356
47k
C332
18k
1k
R308 TXD
1k 0.01u
C355
1u
C333
CN303
1000p
SP+
SP VREF
SP-
1000p
C397
RXD RXD
PTT PTT
TXD TXD
OPTDET OPTDET
7.5V
F53-0372-05 CURRENT BPF BPF
F500 STEERING
+B +B +B
+BATT
(3.15A) SB SB SB
5MS 5MS 5MS
GN1G
1000p
D500
C501
BATTERY 5M 5C 5C
TERMINAL I C 5 0 1 XC6209B502P-G
D501
1 NC 5 F300
RB521S-30 SB
-BATT VoUT
2 VSS DC SW SSM6J08FU(F)
VOL OUT
C507
1000p
F53-0467-05
R505
C506
10u
PROTECT Q303
47k
100p
4.7u
C503
5.0V
47k
VOLTAGE 9 PW-GND 2
VR500 100u VCC
R330
REGULATOR/5V 6.3
R318
10k
270k
R511 8 PRE-GND 3 DC SW
LTC044EEBFS8 NC2
R502 330k C314 100p 7 4 C320 R335 R345
Q300 PHASE
0.22u
VIN
C306
DC SW
330k C315 R326 6 0.1u 0 560
XC6120N302N-G
5
C511
NF
1000p
R321 RIPPLE
3
VIN 4
0.015u
CN510
C325
1 0 u 10 0
VoUT
R31-0684-05 470k
0.047u
220p
C318
C308
C312
IC500
1u
C504
C505
POWER SW Q301
1u
DC SW OFF: 0V
C502
LTC044EEBFS8
1000p
2 VSS
NC
5MSC 5MSC
VOLTAGE INT INT
DETECTOR/RESET RESET RESET
VOL OUT
26
X57-809 1/4
SCHEMATIC DIAGRAM TK-2000
TX-RX UNIT(X57-8093-00)
DATA DATA
CLOCK CLOCK
DACLD DACLD
PFKEY PFKEY
CURDET CURDET
EN2 EN2
EN1 EN3
EN3 EN1
EN4 EN4
LEDR LEDR
R408
100
LEDG LEDG
LSDO WID/NAR
W/N SW
R371
T/RSHF
8.2k
T0 WID: 0V SQL
NAR:5.0V
WID/NAR VDCSW
RSSI
Q305 PFKEY
LTC014YEBFS8
THDET
CVDET
INT PTT
VOXIN 5MSC
RXD 5TC
TXD 5CC
R373 R375 LSDO
T/RSHF
0 10k
CV DET 4 8
VOX IN 4 7
NC 4 6
NC 4 5
TXD 4 4
RXD 4 3
WID/NAR 4 2
VDCSW 4 1
INT 4 0
39
38
37
36
5CC 3 5
5TC 3 4
33
PTT
DACLD
0.047u
PFKEY
5MSC
NC
C349
R388
8.2k
49 32 SPMUT
LSDO SPMUT
HSDO 50 31
HSDO LEDG WID/NAR
BATT 51 30
BATT LEDR RSSI
52 29
RSSI OPTDET SQL
VOXIN VOXIN 53 28
HSDO HSDO SQL NC
54 27
LSDIN EN1
POWC 55 26
THDET MCU EN2
R374 56 25 CURDET
CURDET EN3
4 7 k (D) D402 IC400 THDET
57 24
T/RSHF EN4
R376
F2136ACNKDRB
1000p
1000p
C352
C415
1000p
C413
VDCSW
47k
DA2S101 58 23
5VC NC
R455 59 22 CVDET
NC PLUL
1000p
1000p
5.6k
C414
C412
60 21
NC PLPS
61 20
NC PLDL
5VC 62 19
TYPE2 DATA
R433 63 18
CLOCK
TYPE1 PFKEY
0 5RC 6 4 E2CLK 17
RESET
5RC
1 6 E2DAT
MODE
XOUT
E2WP
VREF
BSFT
VCC
VSS
XIN
NC
NC
NC
NC
NC
NC
CN401 CLOCK
DATA
1
10
11
12
13
14
15
RESET
PLUL
( 1 1 .0 5 92 M H z)
E2WP
SB R370
5CC
47k
X400
C403
CN402
R372
C350
1000p
SPMUT
OPTDET
1p (B)
47k
5MSC
R400
5TC
PTT
12p
4.7k
SB 4
C406
3
BSFT
VIN
12p
CE
C522 1000p
47k
C402
CN404 2
R413 VSS
C513
1u
5C 5 1
R508
Q 4 0 0 1k VoUT NC
470k
R414
CN403 2 SC 4 919 - S
R:4.93V
C514
4.7u
1u
T: 0V XC6209B502P-G
5RC VOLTAGE
5R REGULATOR/5V
RXD
PTT PTT
TXD LSDIN
OPTDET OPTDET
BPF BPF
POWC POWC
+B +B
SB SB
5MS
5M 5M
5R 5C 5C
QT/DQT FILTER R369
AF FILTER SSM3J05FU-F
C357
0.1u
5T 5T
IC303 R350 10k Q501
C337
C358
IC305
0.18u
0.1u
5R 5R
0.1u
N JM 1 2 90 4 R B1 R354
R394
470
R509
8 1
C339
100k
VDD oUT1 DC SW
0
330k
CN506
C338
CN504
CN507
8 V+
CN503
330p
CN505
CN502
7 2
CN508
1
5MS
oUT2 IN1-
5C
5M
SB
5T
1000p
5R
+B
C515
VSS - +
R364 5 4
GND
1000p
BU7442FVM 470
C523
C347
1000p
R366
C524
R348 R342
C343 R363 100k 1u
R:2.49V 56k 15k BPF
0.027u
Q502
1000p
C516
LTA023JEBFS8 5TC
T0 T0 T0
LSDI LSDI
SPMUT SPMUT
5MSC 5MSC
VREF
27
X57-809 2/4
TK-2000 SCHEMATIC DIAGRAM
TX-RX UNIT(X57-8093-00)
PRI DRIVE
R102
R:1.03V R: 0V
T:1.69V T:1.14V 2.2k
2SC4926YD
RF AMP TX/RX SW Q100
C42 D100 C100 C102 R155
RF BUFFER
R104
330
100n
L101
0.75V
15p HSC277 22p 1000p 18
VCO
R37
5.6k
CN3 D2,3,4,6 1.82V R:0V R: 0V
3.3k
R40
82n
R33
L9
T:4.27V
HSC277
T:0.57V
R100
R101
L100
FREQUENCY
68n
4.7k
D3 MCH3914(7)-H
1k
D200
CONTROL 47k 2SC5636
1SV325F
3.3k
Q4
R42
L1 C7 2SC5108(Y)F C33 C39 Q6
C29 Q5
1000p
C104
1000p
R103
R105
C103
4.7u
18
5 6 p (G)
18
47p 12p 1stLO
22n
1 2 p(G)
L3
0.5p
6 p (B)
0.18u
C21
C17
(B)
120n
0 . 5 p (B)
C2
1000p
L7
R45
3.3k
R38
C41
R512 C9
0
C12
R200
10k
270 0.1u
1SV325F
1000p
L5
R27
R41
C40
R39
180
330
180n
10
22n
D2
L2
12p(G)
L4
R30
220
10u
0.01u
C22
R32
1k
C25
HVC350B
1000p
4.17V
HSC277
C32
0.1u
HVC350B
C44
D4
D5
1000p
C43
10u
D6
1stLO
L6
1000p
1000p
C30
C28
R22
10k
5T
5C
5R
D5
C6 R18 MOD R23 MODULATOR 2SC5383-T111
5T
DA2S101
1u 10k 100k Q3
Q2 5.0V R: 0V
2.7k R13
1000p
1000p
C59
R15 680
R52 RT1N436U-T111
R29
C24 T:4.86V
4.7k
D7
C19
1000p
1000p
1000p
C101
0.1u
C107
C105
C8
C18
1u
1u 6.3
0.033u 1k
100k
100k
R12
R11
C13
C11
10u 16
1u
C20
RIPPLE FILTER
TX/RX SW CURDET
POWC
R:4.93V
T/RSHF SHIFT T: 0V
5C 5C
5R 5R VDCSW
5T 5T
THDET
WID/NAR WID/NAR WID/NAR
CURDET CURDET
THDET THDET
VDCSW VDCSW
CVDET CVDET
R3 C36
2.2k 1 2 p (G)
820
R5
0 . 6 8 u 20
L8
0.15u
C5
C1
27n
6.8u 10
C4
15p
C37
15p
R26
CLOCK CLOCK
3.9k 5.0V
DATA DATA
PLUL
REGULATOR/3V
10
PLDL 10k
C23
10k
R9
5M 9 CLoCK 8
R407
5.0V FIN
47k
10 D A T A 7 C16 1000p
C407 XFIN 5R
1000p
R28
1000p
R51
10k
56
33k
R2
11 L E 6
GND
C408 0.01u 1 2 PS Do 5 3.0V
IC401 13 ZC 4
VCC Q7 BPF
EX24016ATAS0A
R 4 11
2SC5383-T111
R 4 38
14 LD/FoUT
4.7k
3
47k
0.01u
100k
VP
0.01u
R50
C14
C15
1 A0 8
VCC 15 P 2 2ndLO
oSCoUT
R 4 12
7 C27
4.7k
2 A1 1
WP Q1 16 R
oSCIN
3 A2 6 LTC014EEBFS8 22p
SCL
DC SW
4 VSS 5 IC1
SDA R19
PLDL M B1 5 E0 3 SL - E1
10k
EEPROM R20
10k
E2CLK E2CLK R21
E2WP E2WP
POWC
R17
R14
R16
+B
5M 5M
5C TCXO
R34
10
5T L 7 7 - 3 0 7 4 - 0 5 (19.2MHz)
X1
5R
1000p
0.01u
C34
C31
T0 VCoNT VCC
1000p
C26
R44 C38
GND
oUTPUT
0 22p
+B +B
5R 5R
WID/NAR
T0 T0
LSDI LSDI LSDI RSSI
SQL
POWC POWC POWC
28
X57-809 3/4
SCHEMATIC DIAGRAM TK-2000
TX-RX UNIT(X57-8093-00)
10p (C)
6p (B)
C121
C136
C128
C125
C122
C123
C132
C138
47p
33p
27p
27p
12p
12p
0
L104
9T
DRIVE
R112
L109
2.2u
Hi:1.67V
47
C112
Q101 Lo:1.37V
RFM01U7P 56p
C108 L102
L103
R109
D101,102,103
82n
47
1000p 33n
ANT SW R: 0V
R107
R117
10
R119
Hi:1.49V
1000p
C129
270
270
T:0.8V
9p (B)
C106
Lo:1.22V
C109
1000p
15p
C116
R113
1000p
C114
C119
R115
0.01u
R111
56k
68k
0
L110 R139
0.01u
C111
Temp compensation
9T
C110
1000p
R108
C152
0
R106
100k
82k
0.1u
F101
RN142S
D103
C130
C146
1stLO
22p
18p
F53-0287-05
Hi:3.71V
TH100
R116
100k
1000p
C120
1000p
C117
Lo:3.04V
39k
2.2u
C124
1000p
-t
C113
R: 0V
T:4.86V
5T 5T
C234
100p
1000p
C139
C134
2.2u
C228
R120
330
CURDET 1 0 p (B)
C225
L206
120n
C230
5p
5p
1000p
C145
POWC R136
1.8k R:5.0V LTC014EEBFS8
R121
1stLO
R122
R123
0.39
0.39
0.39
T: 0V Q103
VDCSW
1000p
C158
THDET
1000p
C159
7.5V
V.D.C SW
+B +B
R222
100k
1st IF (38.85MHz)
1k
MIXER R:2.43V
XF200
L71-0669-05 Q203 T: 0V
R214 R215 C224 R217 3SK318
RF AMP
680 330 0.01u 0 Q204
C251 R225 C237 C240 R230 C247 R268
3SK318
C231
820n
22p
L204
R219
3.3k
0 1p (B)
HVC350B 39p(G)
1000p 0.75p(B) 82 47p(G) 0
C242
39p(G)
39p(G)
C254
L209
68n
C238
L215
8p (B) C223
R221
6p (B)
82n
L208
L207
R229
R224
82n
82n
82k
82k
1.5k
R233
100k
39p (G)
C249
1000p
C246
C253
1p (B)
2p (B)
330 C235
C243
1000p
C222
HVC350B
HVC350B
D202
D204
D201
R232
C250
100k
1000p
C226
R216
R220
R228
R264
R234
390k
1000p
R223
180k
1000p
47
C244
82k
R231
47
C245
47p
470
R236
L210
18n
1M
HVC350B
R237
R227
R226
D203
1M
1M
1M
0.01u
C227
1000p
C236
D201,202,204
1000p
C239
1000p
C248
BPF TUNING
5R 5R
1000p
C256
R:4.93V
T: 0V
BPF
2ndLO
CF200
L72-1046-05
( 4 5 0 k H z)
R:4.76V
C212
C208
0.1u
0.1u
T: 0V
DOUBLER
220p 0.01u
R206
5p
Q201
L213
560n
C215
560n
L211
22p
C210
C219
22p
0.1u
C 2 07 R213
220p 1k
R203
8
R202
1
3.9k
33k
KTC4080E-P
oSCoUT
FILoUT
MIXoUT
DEC
oSCIN
FILIN
IFIN
V+
NJM2591V
R260
1000p
R208
C220
100
FM IF SYSTEM
IC200
27k R:0.73V
SEREC
SEDET
AFoUT
QUAD
IFoUT
MIXIN
330p
T: 0V
C203
RSSI
GND
IF AMP
R 2 11 C216 R212
16
9
820n
C341
L212
C204
C213
C211
0.1u
Q202
0.18u
C334
SQL
KTC4080E-P
R207
5.6k
R209
R201
0.01u
R267
C218
47
47
0.01u
C200
C202
C205
10u
0.1u
CN200 CN201
R:4.93V
5R 5R T: 0V
W/N SW
LSDI LSDI Q200
5R LTA023JEBFS8
WID/NAR
RSSI
SQL
Note : The components marked with a dot (•) are parts of layer 1. 29
X57-809 4/4
TK-2000
BLOCK DIAGRAM
X57-8093-00
IC1
MB15E03SL-E1
LPF VHF:174.85
PLPS 136M
PLDL PLL
IC
DATA Q4 :MCH3914(7)-H Q5
D2,3:1SV325F 2SC5108(Y)F
CLOCK DO
LPF RF BUFFER
Q1 VCO
Q7 MOD AMP
RT1N141U-T111
D5:HVC350B
INV 3.3V REG
D6:HVC350B
2SC5383-T111 Q3:2SC5383-T111
FUSE TUNE Q2:RT1N436U-T111 D7:DA2S101
PLUL X1 D4:HSC277
F500 3.15A 19.2MHz 5M
L77-3074-05 RIPPLE
BATT+ +B SHIFT SW 5C
TCXO FILTER
7.5V ASSIST
5M
PROTECT
SHIFT
D500 SB
GN1G
BATT- FADJ LSDO
VR500
R31-0684-05 IC501
D501
RB521S-30 XC6209B502PR
SB AVR
PROTECT 5M
VOLIN
Q500 MCH3309-H
AFOUT
DC SW 5MS
5MSC
IC500
XC6120N302N-G
1 TXD LEDR
RESET RESET 5CC LEDG
5TC DATA
2 5RC CLOCK
S402 IC503 5VC DACLD
S60-0447-05 3 XC6209B502PR 5MSC SPMUT
EN4
5C BSFT VDCSW
4 AVR
EN1 LSDO T/RSHF
5 HSDO WID/NAR
5CC
PLDL PLPS
6 Q501 SSM3J05FU-F
EN3
7 DC SW 5T
EN2 5M
8 5TC
EN4 BATT
Q502 RT1P237U-T111 Q400 EN3 RESET
9 MCU EN2 VOXIN
DC SW 5R 2SC4919-S
EN1 PFKEY
5RC SW PTT CVDET
5MS BSFT RXD LSDIN
Q402 IC400 SQL THDET
XOUT INT OPTDET
RT1N144U-T111 F2136ACNKDRB
PLUL CURDET
D401 LED DC XIN RSSI
LEDR
B30-1779-05 (Red) SW
X400
L77-2974-05
11.0592MHz E2CLK E2WP E2DAT
Q401
RT1N144U-T111
D400 LED DC
(Green) SW LEDG
B30-1782-05 EEPROM
IC401
EX24016ATAS0A
S400
S70-0414-05 5M
PTT
PTT
S401
S70-0514-05
PFKEY
SIDE
30
TK-2000
BLOCK DIAGRAM
VHF:136MHz~
174MHz
VHF:174.85MHz~212.85MHz (RX)
136MHz~174MHz (TX)
5T
Q6 D100,D200 Q100 Q101 Q102 D101,102:HVC131
2SC5636 HSC277 2SC4926YD RFM01U7P RD07MUS2BT112 D103:RN142S
TX/RX ANT
RF AMP PRE DRIVE DRIVE AMP FINAL AMP ANT SW LPF
RF SW
POWC
5C 5R 5T F101
-T111
-t
5T
FUSE 0.5A
VDCSW VDC SW CURDET THDET
Q103
RT1N141U-T111 +B
1st Local
VHF:174.85MHz~212.85MHz LPF
Q201 5R
KTC4080E-P 2nd Local
38.4MHz IC200
DOUBLER
NJM2591V
RSSI
Q202 XF200 Q203 D201,D202,D204 Q204 D203
KTC4080E-P L71-0669-05 3SK318 HVC350B 3SK318 HVC350B
CF200 SQL
L72-1046-05 IF AMP MCF MIXER BPF RF AMP BPF
CF FM IF IC 1st IF
450kHz 5R 38.85MHz
CD200
L79-1914-05 5R 5R
CD DC Q200 BPF
SW RT1P237U-T111
DETAF
5C IC305
NJM12904RB1 WID/NAR
LSDIN QT/DQT 5R
FILTER
IC303 J301
NJM12904RB1 E11-0717-05
AF SPG
VOLIN 5R
FILTER TXD TXD
SPK
AFO
AST
FADJ POWC
BPF SP
DAC
CLK 5MS IC302 Q302 Q306
DAT IC300 TA7368PL 2SK3577-A 2SK3577-A
DALD R2A20178NP MIC
AF POWER RXD
MUTE MUTE
AFOUT
AMP SW SW
LSDO MIC2
IC301
NJM12904RB1
MOD Q301 PTT
LSD J300
BUFF 5MS Q303 DC
E11-0484-05
SSM6J08FU(F) SW RT1N441U-T111
PTT/RXD
DC MIC
SW Q300 IM
IC304 RT1N141U-T111 OPTDED
OPTDET
NJM12904RB1 DC 5MS 5MS
FUSE
F300
MIC SW
AMP HSDO
MIC300
Q304 SPMUT T91-0674-05
RT1P237U-T111 SB
DC
5VC SW MIC
5MS
31
32
Receiver Section
IF2
RF (CENTER FREQUENCY) IF1 (38.85MHz) 450kHz AF (1kHz)
TK-2000
–58.0dBm –74.8dBm –67.6dBm –55.0dBm –52.6dBm –47.5dBm –60.8dBm –33.47dBm 174mVrms 71mVrms 1.9Vrms 1.9Vrms 1.9Vrms
SP
500mW
SG ANT
+
–53dBm FM IF AF
DAC
SYSTEM AMP
50Ω C250 C247 C240 C237 C224 C221 C216 C328 C320 C302
Q204 MIXER XF200 Q202 IC200 IC300 IC302 Q302 Q306
Q203
Transmitter Section
LEVEL DIAGRAM
15.1mVrms 216mVrms –11.2dBm 5.2dBm 2.2dBm 3.0dBm 11.8dBm 18.5dBm 36.2dBm 38.2dBm
MIC
ANT
DAC VCO
D100 50Ω
R313 C29 C33 C42 C100 C108 C112 C127
IC300 Q4 Q5 Q6 D200 Q100 Q101 Q102
RXLo
AG is set to the MIC input becomes 1.5kHz Dev, at 1kHz MOD. (Narrow)
To make measurements in the AF section, connect the AC level meter.
In the RF section, use a 1000pF coupling capacitor.
TK-2000
SPECIFICATIONS
General
Frequency Range ................................................. 136~174MHz
Number of Channels ............................................ Max. 16
Channel Spacing .................................................. 25kHz (Wide) / 12.5kHz (Narrow)
PLL Channel Stepping ......................................... 5kHz, 6.25kHz
Operating Voltage .................................................. 7.5V DC ±20%
Battery Life ............................................................ More than 10 hours at 5 watts (5-5-90 duty cycle with KNB-63L battery)
Operating Temperature Range ............................. –20°C to +60°C (–4°F to +140°F)
Frequency Stability ............................................... ±5.0ppm
Channel Frequency Spread .................................. 38MHz
Dimensions and Weight (Dimensions not including protrusions)
Radio Only ....................................................... 54 (2.13) W x 113 (4.45) H x 14 (0.55) D mm (in), 130g (4.6oz)
With KNB-63L battery (1130mAh battery) ....... 54 (2.13) W x 113 (4.45) H x 24.9 (0.98) D mm (in), 203g (7.2oz)
33
TK-2000
A B C D E F G H I J K L M N O P Q R S
2
TX-RX UNIT (X57-8093-00) Component side view (J79-0362-09) TX-RX UNIT (X57-8093-00) Component side view (J79-0362-09) 2
C322
Q304
CN506
C411
R367
Q501
D
C333
C332
R392
R407
R408
CN507
3 R360 C345 3
S
C523
C507
C329
C506
C514
C409
R406
C342
R355 C336
R393 C134 – + R509
CN504
1 8
R347
C340 R356
R357 R358
IC304
CN3
1 5
CV
C515
C139
4 5 MIC300 C502 IC503
C503
C330
IC500 Q301
R334
R344
C517 C353
C321 C323
4
C355 1 4 ANT
IC501
3 4
R386
R332
C306
D301
R120
C326 C316 R136 C312
Q300
4 2 3
R321
4
3
R340 R508 C513
1 8 R329 C308
C522
C505 R502
IC301
C158
Q103
R328
R317
R377 C319
C313
R325
C317 C504
C511
C354
CN510
4 5
Q306
R330
R324 D501
R505
S
R327 R511
C124
CN404
C309
5 R116
R18 C6 G
R410 5
CN202
CN403
R400
R121
R122
R123
CN511
R52 C59 Q500 R409
R218
Q302
G
S
R314 18 13 C315
CN402
D
19 12
CN505
C159
C311
R313
R473
Q502
C516
R316 C314 R326
IC300
R370
C350 R315 F500
BATT+
CN500
CN401
CN503
CN502
R318
R323
R372 R322 24 7 C310
CN508
1 6 D500
C524 D402
6 6
10
6
C501
R305
R306
R307
R455
R374 IC302
C352
R376
R433
R375
C349
R373
Q305
5
R388
CN501
BATT–
R371
Q303
D D
D D
S G
Q400 C324 SP–
C414 C412
7 (BRN) 7
R414
R413
64 49 C346 R350
R395
C320
C400 R401
CN2
F300
R336
48
R335
R342 R394
C318
C401
SP+
(GRN)
C403
1
X400
R308
R312
C397
CN1
C402 IC303
IC400
CF200
C358
D401
D400
C406 R311
8
R378 R304
8 C407 8
CN201
R379
C303
R310
R351
C337
CN200
C408 R438
C500
R340
CN303
R337 R302
CN302
1 8
R301
R309
C301
IC401
CN300 CN301
C304
D380
C335
R411
4 5
R303
R412
C305
CD200
9 9
Note : for service unit
J79-0362-09
10 10
Ref. No. Address Ref. No. Address Ref. No. Address Component side
IC300 6I Q103 4I Q501 3N Layer 1
11 IC301 4H Q300 4O Q502 6F Layer 2 11
IC302 6P Q301 4P D301 4F Layer 3
IC303 8L Q302 5P D400 8R Layer 4
IC304 3H Q303 7P D401 8R Foil side
IC400 8H Q304 3H D402 6G
12 12
IC401 8F Q305 7I D500 6K
IC500 4M Q306 5P D501 5O
IC501 4M Q400 7F
IC503 4O Q500 5M
13 13
14 14
A B C D E F G H I J K L M N O P Q R S
2 TX-RX UNIT (X57-8093-00) Foil side view (J79-0362-09) TX-RX UNIT (X57-8093-00) Foil side view (J79-0362-09) 2
S401
S400 Side
R300
PTT
3 C300 3
C43
C104 L101
R23
C9 L3
R12
C121
R106
R105
C107
L11 C13
R119
R117
C129
C113 R108 C152
R104
C105 C7
R111 R112
C125
R113
D3
L1
C110 C108
L2
R22
C123
D4
C114
R107
C109
C106
L102
R102
L4
C128
C126
C138 C136 C132 C12
L109
L108
D5 D1
C122
R101 R155
L107
L106
C2
L105 C17
D2
C
E
C135
Q100
4 D Q102 G R114 C112 C44 C8
D6 4
C137
C127
L112
L5 R1
D101
D102
B
E
L104
R11
C131
R109
Q2
L103
L111 R139 C53
R13
C146
C21
C103
R103
L110 C250 C102
C130
G
D
S Q101
C22
L210
C101
L100
L209
C111
C119 S
TH100
D103 Q4
C20
C28
R30
R15
C18
R115
C100 C11
F101
C116 G
D
L6
R100 + C25
C120
C249 R42 C19 R27
5 5
C29
C117
C24
R29
R268
D203 D100
R222 C262 Q5
Q3
D7
R33
R236
C248
Q203
C413 C415 R45
C236
G S
R221 R223
R217 R41 C41
D200
C42
Q204 C237 C232 R40 R39
G D
C32 L7
C242
C240 R226
C238
R32
L208
C253
C254
C247
C234 L206
G S R225 L204 C228 L9 C40 C36
C243
R230
R229
L203 C30 C33
L207
C251 R220 L205
G D Q6 L8
6 6
R227
R224
R38
C226
C235 C231 R200
L215
C230
C225
D201
D202
D204
C37
C35
R228 C39
R237
R232
R233
C246
R264
C245
R231
R219
C302 + R234 C244 C256 C239 C227 R216 R37
S402
C207 R203
C206
C210
C201
7 7
C357
R364
C343
C328 R390 R353 C200
R206 Q1
R363
C334
C341
Q401
R9
R202
R201
R43
R365
R2
C1
C223
C224
R361
C208
8
5
R214
1
R260
R26
R209
XF200 R19
R3
IC305 C221 R215 + C4 R14
C218 R5
16
C405
C404
9
IC200 R21
4
Q202
Q402
C212
R17
L212
8 + C5 8
16
C222 C34 IC1 R20
9
C203
C204
C338 R267
R34
C31 R16
R369
R354 C344
R352 R366
C216
R212
R211
J300
C26
R204
8
MIC
R28
R207 C209
C23
C211
C213
C347
J301 C27
R210 R208
C339
R205
Q201
X1
C217
C215
C214
R44
VR500
R213
SP
L213
C202
C205
C219
R25 C14 C16
C15
L211
Q200 C220
9 9
R51
R50
C38
Q7
J79-0362-09
10 10
Ref. No. Address Ref. No. Address Ref. No. Address Ref. No. Address Component side
IC1 8P Q7 9P Q401 7C D100 5N Layer 1
11 IC200 8K Q100 4M Q402 8C D101 4F Layer 2 11
IC305 8I Q101 5L D1 4P D102 4F Layer 3
Q1 7P Q102 4K D2 4O D103 5G Layer 4
Q2 4O Q200 9J D3 4O D200 6O Foil side
Q3 5O Q201 9N D4 4N D201 6K
12 12
Q4 5P Q202 8L D5 4O D202 6J
Q5 5P Q203 6M D6 4O D203 5I
Q6 6O Q204 6I D7 5O D204 6L
13 13
14 14
TX-RX UNIT(X57-8093-00)
7 S3_A EN2
8 S3_C
9 S3_G PRI DRIVE
4 S2_A EN1
5 S2_C R102
6 S2_B EN3 R:1.03V R: 0V
1 S1_A T:1.69V T:1.14V 2.2k
2 S1_C 2SC4926YD D101 L111 L112
3 S1_B EN4 FINAL L108
RF AMP TX/RX SW Q100 9T 9T
Q102 HVC131
S402 C42 D100 C100 C102 R155 ANT
SELECTOR DATA DATA DATA DATA DATA RF BUFFER RD07MUS2BT112 L105 L106 L107 C126 C127 D102 C131 C135 C137
R104
330
100n
L101
S60-0447-05 0.75V
CLOCK CLOCK CLOCK CLOCK CLOCK 15p HSC277 22p 1000p 18 3T 5T 5T
VCO 5p (B) 1000p HVC131 1000p 6p (B) 6 p (B)
R37
5.6k
CN3 D2,3,4,6 1.82V R:0V R: 0V R114
3.3k
R40
1 0 p (C)
6 p (B)
82n
R33
C121
L9
C136
C128
C125
C122
C123
T:4.27V
C132
C138
47p
33p
27p
HSC277
27p
12p
12p
T:0.57V
R100
R101
L100
FREQUENCY 0
68n
4.7k
D3 MCH3914(7)-H
1k
L104
DACLD DACLD DACLD
D200
DACLD DACLD CONTROL 47k 2SC5636
9T
PTTSW 1SV325F DRIVE
R112
3.3k
L109
Q4
R42
2.2u
L1 C7 2SC5108(Y)F C33 C39 Q6 Hi:1.67V
47
PFKEY PFKEY PFKEY PFKEY PFKEY C112
C29 Q5
1000p
Lo:1.37V
C104
1000p
Q101
R103
R105
C103
4.7u
18
CURDET CURDET 56p (G)
R406
18
47p 12p 1stLO
22n
RFM01U7P 56p
1 2 p(G)
100
L3
0.5p C108 L102
6p(B)
EN2 EN2 EN2 EN2
L103
R109
0.18u
D101,102,103
C21
82n
C17
(B)
120n
47
0 . 5 p (B)
C2
1000p
33n
L7
EN1
R45
EN3
3.3k
EN1 EN1 1000p
R 38
C41
R512 C9 ANT SW R: 0V
R107
0
C12
R200
R117
10
R119
Hi:1.49V
1000p
C129
DA2S101
EN3
10k
EN1
270
EN3
270
EN3 T:0.8V
9 p (B)
C106
Lo:1.22V
C109
S70-0414-05
1000p
270
15p
EN4 0.1u
C116
EN4
R113
EN4
1000p
C114
C119
EN4
R115
0.01u
R111
D1
56k
R1
1SV325F
68k
1M
1000p
L5
R27
1000p
R41
0
C40
R 39
C409
LEDR
180
330
180n
LEDR LEDR
10
22n
D2
L2
R408
1 2 p(G)
L4
R30
220
10u L110 R139
100
0.01u
0.01u
LEDG LEDG
C111
C22
R313
LEDG
R32
1k
C25
S400
10k
Temp compensation
HVC350B
9T
C110
1000p
1000p
R108
C152
4.17V 0
R106
100k
82k
0.1u
HSC277
F101
C32
0.1u
HVC350B
LSDO LSDO LSDO
C44
WID/NAR
RN142S
D4
D5
1000p
W/N SW
D103
C43
C 1 30
10u
C146
D6
1stLO 1stLO
L6
22p
18p
PTT
R371
1000p
1000p
R314
CURRENT T/RSHF F53-0287-05
C30
8.2k
C28
10k
Hi:3.71V
R22
TH100
STEERING T0 T0
10k
T0
R116
100k
1000p
C120
1000p
WID: 0V
C117
SQL
5T
Lo:3.04V
39k
2.2u
C124
5C
5R
1000p
-t
NAR:5.0V
C113
5MS
LED DC SW LED DC SW WID/NAR VDCSW D5 R: 0V
GREEN RED T:4.86V
RSSI MODULATOR
R324
IC301 C6 R18 2SC5383-T111
47k
LTC014YEBFS8 LTC014YEBFS8 MOD R23
D401 5T 5T 5T
Side NJM12904RB1 D400 Q401 Q402 Q305 PFKEY
C316
DA2S101
1u 10k 100k Q3
0.1u
Vref
LTC014YEBFS8 Q2 5.0V R: 0V L203 L205 C232
24
23
22
21
20
19
THDET
2.7k R13
1000p
1000p
1 8 C59
R325
R15 680
R52
47k
R29
RT1N436U-T111
C24
T:4.86V
4.7k
D7
V+
C19
1000p
1000p
1000p
C101
0.1u
B30-1779-05
C107
B30-1782-05
S70-0514-05
2.7n 22n
C105
C8
C18
VIN1
VIN8
3p (B)
VoUT2
VoUT1
VoUT8
VoUT7
1u
CVDET
1u 6.3
2 7
1000p
0.033u 1k
C411
C234
- +
100k
100p
100k
18
S401
R12
R410
R11
1
R409
VIN7 INT PTT
C13
220
R328
220
1000p
6
C139
C134
2.2u
VIN2 3 C228
C11
10u 16
1u
+ -
R120
GND 17 5MSC
C20
2 VOXIN RIPPLE FILTER
330
VDD D/A CONVERTER 4 5 680k
GREEN LED RED LED
C313
0.1u
R305 1k 3 16 GND
TX/RX SW CURDET CURDET 10p (B)
0.01u
RXD 5TC
C319
0.01u
C225
L206
120n
ON:5.0V ON:5.0V
C230
C317
R 2 A 2 0 1 7 8 N P RESET
R327
820k
LD
5p
5p
1000p
C145
R306 1k 4 IC300 VDAREF2 15
LEDR TXD 5CC POWC POWC R136
CLK LSD BUFFER R373 R375 LSDO R:4.93V
T/RSHF T/RSHF SHIFT T: 0V 1.8k R:5.0V LTC014EEBFS8
R307 1k 5 14 LEDG
R121
1stLO
R122
R123
0.39
VDAREF1
0.39
10k
0.39
0 5C 5C
CV DET 48
VOX IN 47
NC 46
NC 45
TXD 44
RXD 43
WID/NAR 42
VDCSW 41
INT 40
39
38
37
36
5CC 35
5TC 34
33
DI LSDO T: 0V Q103
13 5R VDCSW
C309
PTT
DACLD
0.047u
PFKEY
R316
5MSC
NC
C349
T0
VoUT3
VoUT4
VoUT5
VoUT6
VIN3
R388
8.2k
5T 5T
1000p
VIN4
VIN5
49 SPMUT
C158
0 1u 32
THDET THDET
LSDO SPMUT
1000p
R322
C159
VREF
5MS HSDO 50
11
31
7
12
10
8
R218
R222
100k
POWC POWC 55 26 1st IF (38.85MHz)
1k
MIXER R:2.43V
T91-0651-15 THDET MCU EN2 XF200
R374 56 25 CURDET CURDET CURDET L71-0669-05 Q203 T: 0V
MIC MIC300 R215
CURDET EN3 R214 C224 R217 3SK318
4 7 k (D) D402 IC400 THDET THDET THDET RF AMP
1000p
57 24
C300
T/RSHF EN4 0
R376
F2136ACNKDRB
1000p
R315
680 0.01u
1000p
330
C352
C415
1000p
Q204
C413
10k
VDCSW VDCSW
47k
VREF DA2S101 58 23 VDCSW C251 R225 C237 C240 R230 C247 R268
R300 5VC NC 3SK318
C231
C336
820n
22p
R355
L204
R219
3.3k
CVDET CVDET CVDET 0 1p (B)
H V C 3 5 0 B 39p(G)
R455 59 22 1000p 0.75p(B) 82 47p(G) 0
C242
1.5k
39p(G)
39p(G)
C254
L209
68n
PLUL
C238
L215
NC
8 p (B) C 2 2 3
R221
6 p (B)
82n
C305 0.01u 47k C36
L208
L207
R229
R224
82n
C323 R3
82n
1000p
82k
1000p
82k
1000p
C310 5.6k
1.5k
C414
C412
60
C345
21
DC SW
R233
NC PLPS
100k
39p (G)
R309
C249
0.01u
1000p
C246
C253
R329 0.1u
1 p (B)
820
0.047u
2 p (B)
R323
1.8k
61
10k
R5
330 C 2 3 5
C243
20
5.6k
1000p
C222
1000p
PLDL
0 . 6 8 u 20
NC
C301
HVC350B
HVC350B
L8
D202
R303 CURRENT 62
R 3 96
0.15u
5VC 5VC 19
D204
D201
R232
D 3 0 1 STEERING C250
100k
1000p
C5
C1
TYPE2 DATA
C226
R216
R220
27n
0
R228
R264
6.8u 10
R234
390k
1000p
R223
180k
R433
1000p
47
C244
82k
C304
R231
470 C353 63 18
47
C245
R389
C4
CLOCK 47p
470
Q304
10u
C35
15p
C37
0
15p
R236
1k LTA023JEBFS8 5RC 64 E2CLK 17
L210
1u
18n
C354
R377
1M
0.22u
39k
RESET
5RC
1 6 E2DAT
MODE
C360
XOUT
E2WP
VREF
0.1u
BSFT
180k
R332 R26
VCC
R360
KDR731
VSS
PTTSW
XIN
C322
NC
NC
NC
NC
NC
NC
1000p
CN401 CLOCK CLOCK CLOCK
R304 5.0V
HVC350B
R311 2.7k
0.01u
3.9k
C321
DATA
R386
DATA
R237
DATA
R227
R226
3.9k
9
CN302
10
11
12
13
14
15
D203
1M
1M
1M
47k 47k RESET
0.01u
PLUL PLUL
C342
1 R310
0.01u
PTT/RXD
C227
1000p
C236
3 MIC R312
R302 1k 1k
11 IM C400 C405 R43 VOLTAGE
10 OPTDET 2.2k MIC AMP/LIMITER PLPS PLPS PLL SYSTEM
R25
REGULATOR/3V
10
L77-2974-05
2 5MS PLDL D201,202,204
1000p
IC304 0.1u 1000p PLDL 10k
C239
C303 R357
J300 R301 NJM12904RB1 C401 C404 C23 BPF TUNING BPF
10k
0.033u
R9
8
R392
E2CLK 5M 9 CLoCK
R407
5M
5.0V
C329
47k
RXD 5R
1000p
SP/MIC
C248
( 1 1 .0 5 9 2 M H z)
0.047u 1 8 7.5V 1000p 0.1u E2DAT C16 1000p
R401
PTT V+ 10 D A T A 7 BPF TUNING
R337
1k
JACKS E11-0717-05 C407 1000p XFIN 5R
J301 7 C340 E2WP 5R 5R
R28
2
0
1000p
R51
R370
10k
56
33k
R2
1 SPG R378 OPTDET - + SB 1 1 LE 6
GND
3 TXD R334 R344 R347 6 10p 5CC
1000p
3 47k C408 0.01u
C256
X400
4 SPK C403 5
R379
1k + - 12 PS Do 3.0V
100k
R372
C350
1000p
SPMUT
OPTDET
4 5 1p (B) 4 T: 0V
47k
2 AFO IC401 13 ZC Q7 BPF
560p
GND BPF
5MSC
VCC
C330
R400
5TC
PTT
12p
8200p
4.7k
EX24016ATAS0A
C326
R340
R 4 11
2SC5383-T111
R 4 38
10k
14 LD/FoUT
4.7k
3
47k
SB 4
0.01u
C406
R358
100k
3 VP
0.01u
R393
R356
R50
C14
47k
BSFT
C332 VIN
12p
C15
8
18k
CE
1k
R308 1 A0
C522 1000p
TXD 15 P
47k
VCC 2 2ndLO 2ndLO
C402
CN404 2 oSCoUT
R 4 12
0.01u R413 VSS C27
C513
7
4.7k
1k 2 A1 1
C355
Q1
1u
5C 5 WP 16 R CF200
1 oSCIN
R508
Q 4 0 0 1k
1u
470k
R414
CN303 CN403 2SC4919-S SCL ( 4 5 0 k H z)
DC SW
1000p SWITCH 4 VSS 5 IC1 R:4.76V
5.0V IC503 SDA R19
C212
C208
C517
R:4.93V
0.1u
C514
0.1u
PLDL
4.7u
MB15E03SL-E1 T: 0V
1u
SP+
SP VREF T: 0V X C 6 2 0 9 B 5 0 2 P -G DOUBLER
10k
SP- 5RC VOLTAGE R20
EEPROM 2nd-LO (38.4MHz) R210
5R REGULATOR/5V
10k R:0.62V
1000p
1000p
C201
330k
C397
220k
220p 0.01u
R206
TXD E2DAT E2DAT 10k 5p
TXD
10k
10k
TXD LSDIN
10k
Q201
L213
560n
C215
560n
L211
22p
C210
C219
22p
0.1u
OPTDET OPTDET OPTDET OPTDET E2WP E2WP C 2 07 R213
7.5V
F53-0372-05 CURRENT BPF BPF BPF BPF
STEERING POWC 220p 1k
R203
POWC POWC
8
R202
1
F500
3.9k
33k
R17
R14
R16
+B +B +B +B +B +B KTC4080E-P
oSCoUT
FILoUT
MIXoUT
DEC
oSCIN
FILIN
IFIN
V+
+BATT
SB SB
NJM2591V
(3.15A) SB SB SB R260
1000p
R208
C220
5MS 5MS 5MS 5MS
100
FM IF SYSTEM
GN1G
IC200
1000p
D500
C501
5M 5C 5C 5M 5M 5M 5M 27k R:0.73V
BATTERY
SEREC
SEDET
AFoUT
I C 5 0 1 XC6209B502P-G
QUAD
IFoUT
MIXIN
330p
T: 0V
C203
RSSI
TERMINAL
GND
D501 5R 5C 5C 5C IF AMP
TCXO
R34
1 NC 5 F300
10
RB521S-30 SB R369 R 2 11 C216 R212
16
QT/DQT FILTER
9
AF FILTER SSM3J05FU-F L77-3074-05 (19.2MHz)
C357
VoUT
0.1u
-BATT 5T 5T 5T
DC SW Q501 C328 R390 R353 R365 R361 R204
2 VSS SSM6J08FU(F) IC303 10k
VOL OUT
R350 X1
C337
C507
1000p
C358
F53-0467-05 2.7k 180k
R505
IC305 0.01u
C506
0.18u
10u
Q303
0.1u
PROTECT 5R C209
47k
5R 560
1000p
5R
0.01u
4 0.39u 0 1k 0 270 R205
0.1u
Q500
0.033u
0.022u
3300p
N J M 12904R B 1 R354
R394
3 CE 470
R509
820n
C34
8
C341
1
C339
L212
100k
C31
AF AMP ON:3.3V AF AMP T0
R317
330k
C204
IC302 TA7368PL
C213
SP MUTE SW DC SW VCoNT
C211
0.1u
MCH3309-H VDD oUT1 VCC Q202
0.18u
0
VIN
C334
OFF: 0V 330k 6.8k 22p
Q306 Q302 ON:7.5V C221
CN506
C500
C338
CN504
CN507
8 V+
CN503
330p
CN505
CN502
7 2
CN508
100p
1000p
4.7u
C503
C302 10
5MS
1 OFF: 0V oUT2 CD200
C26
2SK3577-A 2SK3577-A IN1-
5C
5M
SB
5T
1000p
5R
+B
PoUT NC1
C515
C346 C324 C38 L79-1914-05
R336
RSSI
VOLTAGE 100u + - oUTPUT
SQL
VR500 VCC 100k KTC4080E-P
R207
R330
5.6k
REGULATOR/5V 6.3 4 0.18u 6 DC SW 22p
R318
3
10k
270k
DC SW
R209
R201
0.01u
3 INT2+
CN511
R511 8 PRE-GND VSS
R267
- +
C218
47
47
0.01u
NC2
C200
C202
LTC044EEBFS8
C205
10u
R364
0.1u
5
0
R502 330k C314 100p 7 4 C320 R335 R345 GND
4 +B +B
Q300 PHASE CN200 CN201
0.22u
VIN
C306
1000p
BU7442FVM 470
C523
DC SW C347
1000p
R366 R:4.93V
C524
330k C315 R326 6 0.1u 0 560 R342 5R 5R 5R 5R
XC6120N302N-G
5 R348 T: 0V
C511
NF
1000p
CN510
C325
0.027u
R31-0684-05 470k
0.047u
220p
C318
Q502
1000p
C516
T:2.45V VREF 0.18u 5.6k
C344
C308
C312
5R LTA023JEBFS8
IC500
LTA023JEBFS8
1u
C504
C505
POWER SW Q301
1u
LTC044EEBFS8 T0 T0 T0 T0
1000p
T0
2 VSS
NC
SQL SQL
5MSC 5MSC 5MSC 5MSC
POWC POWC POWC
VOLTAGE INT INT VREF
DETECTOR/RESET RESET RESET
VOL OUT
X57-8093-00
VHF:136MHz~
IC1 174MHz
MB15E03SL-E1
-t
2SC5383-T111 Q2:RT1N436U-T111 5T
FUSE TUNE D7:DA2S101
PLUL X1 D4:HSC277 FUSE 0.5A
F500 3.15A 19.2MHz 5M
L77-3074-05 RIPPLE VDCSW VDC SW CURDET THDET
BATT+ +B SHIFT SW 5C
TCXO FILTER
7.5V ASSIST Q103
5M RT1N141U-T111 +B
PROTECT
SHIFT
D500 SB
GN1G
BATT- FADJ LSDO
1st Local
VR500 VHF:174.85MHz~212.85MHz
R31-0684-05 IC501 LPF
D501
RB521S-30 XC6209B502PR 5R
Q201
SB KTC4080E-P 2nd Local
PROTECT AVR 5M
38.4MHz IC200
DOUBLER
VOLIN NJM2591V
Q500 MCH3309-H RSSI
AFOUT Q202 XF200 Q203 D201,D202,D204 Q204 D203
DC SW 5MS KTC4080E-P L71-0669-05 3SK318 HVC350B 3SK318
CF200 SQL HVC350B
5MSC L72-1046-05 IF AMP MCF MIXER BPF RF AMP BPF
IC500 CF FM IF IC 1st IF
XC6120N302N-G 450kHz 5R 38.85MHz
CD200
1 TXD LEDR L79-1914-05 5R 5R
RESET RESET 5CC LEDG DC
CD Q200 BPF
5TC DATA SW RT1P237U-T111
2 5RC CLOCK DETAF
S402 IC503 5VC DACLD 5C IC305
S60-0447-05 3 XC6209B502PR 5MSC SPMUT NJM12904RB1 WID/NAR
EN4
5C BSFT VDCSW QT/DQT
4 AVR LSDIN 5R
EN1 LSDO T/RSHF FILTER
5 HSDO WID/NAR
5CC
PLDL PLPS IC303 J301
NJM12904RB1 E11-0717-05
6 Q501 SSM3J05FU-F
EN3 AF SPG
DC SW 5T VOLIN 5R
7 FILTER TXD TXD
EN2 5M SPK
8 5TC AFO
EN4 BATT
Q502 RT1P237U-T111 EN3 RESET AST
Q400 MCU
9 5R 2SC4919-S EN2 VOXIN
DC SW EN1 PFKEY FADJ POWC
5RC SW PTT CVDET
5MS BSFT BPF SP
RXD LSDIN DAC
Q402 IC400 SQL THDET CLK
XOUT 5MS IC302 Q302 Q306
RT1N144U-T111 F2136ACNKDRB INT OPTDET DAT
PLUL CURDET IC300 TA7368PL 2SK3577-A 2SK3577-A
DALD R2A20178NP MIC
D401 LED DC XIN RSSI AF POWER RXD
LEDR MUTE MUTE
B30-1779-05 (Red) SW AFOUT
X400 AMP SW SW
L77-2974-05 LSDO MIC2
11.0592MHz E2CLK E2WP E2DAT IC301
Q401 NJM12904RB1
RT1N144U-T111 MOD Q301 PTT
LSD J300
LED DC BUFF 5MS Q303 DC
D400 E11-0484-05
(Green) SW LEDG
SSM6J08FU(F) SW RT1N441U-T111
B30-1782-05 EEPROM PTT/RXD
IC401 DC MIC
EX24016ATAS0A SW Q300 IM
S400 IC304 RT1N141U-T111 OPTDED
OPTDET
5M NJM12904RB1 DC
S70-0414-05 5MS 5MS
FUSE
F300
PTT MIC SW
PTT AMP HSDO
MIC300
Q304 SPMUT T91-0674-05
S401 RT1P237U-T111 SB
S70-0514-05
PFKEY DC
SIDE 5VC SW MIC
5MS