Documentos de Académico
Documentos de Profesional
Documentos de Cultura
3. Click Run.
1
4. Click Install Printer Drivers and click Next.
2
6. Specify the Port and click Next.
7. Specify Printer Name. Just click Next. (Note: Do not mark printer to be the default
printer).
3
8. Click Finish.
9. Click Close.
4
10. Turn-on Printer and go to the TSC TTP-247 Printer Properties and click on Preferences.
11. Go to Page Setup and click on Edit. Width = 2.50 Height = 0.75
5
12. Click on Advanced Options. Vertical Offset = -0.10
13. Go to Stock.
Method = Thermal Transfer
Type = Continuous
Post-Print Action = Tear Off
6
14. Go to Options
Print Speed = 2.00 in/sec
Darkness = 15
7
16. In GIMS-SE, go to Setup -> Company Information. In the Device Options tab, select
Thermal for Employee Label Printer.
17. Your printer is now properly configured and ready for use.
8
How to Share the Label Printer:
1. Test the printer on the local PC and make sure it is printing correctly in GIMS.
2. Right-click on the printer, select
the printer properties and go to
the Sharing tab. Give the printer
a name that is easily
remembered.
3. Go to the PC that the printer is going to be shared to, and install the Monarch driver.
4. Use the Add Printer wizard and
add a Local Printer and uncheck
the option to automatically
detect.
5. Select LPT1 as the port to use
and hit next.
6. Select the Monarch 9416 (203 dpi) driver from the list or select the Have Disk option and
navigate to the Seagull directory and select the Monarch.ini.
7. Select “Keep existing driver” and hit next.
8. Do not use this printer as the default printer, and hit next.
9. Do not share this printer, and hit next.
10. Do not print a test page, and hit next.
11. Press finish and install the monarch
driver. A security warning may pop
up, but always click continue
installation.
12. Right click on the installed printer and
hit properties.
13. Go to the Ports tab and hit add port.
14. Select Local Port from the list and hit
New Port.
9
15. Type in the PC name and the printer name
for the port name like the screen shot to
the right and press ok.
16. Close the printer screen and the printer
should now show as a networked printer
like the screen shot below.
17. Print a test label to confirm installatio
{I,A,0,0,0,0,0 |
B,1,1,0,0,0 |
C,156,,,20,0 |
G,0,,|}
{F,138,A,R,E,075,325,"FMT138" |
T, 50,30,V, 20,160,2,50,10,10,A,B,0,2,850 |
T, 100,25,V, 47,160,0,50,24,22,A,B,0,2,850 |
T, 200,35,V, 65,160,0,50,14,18,B,B,0,2,850 |}
{B,138,N,2| E,0,0,1,1,0,1 |
50,"INVOTECH" |100,"1321" |200,"1321231" |}
10