Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Wahab
Exercise 3: Neurophysiology of Nerve Impulses: Activity 3: The Action Potential: Threshold Lab Report
1. Axons are
You correctly answered: d. long, thin structures that extend from a neuronal cell body.
03/07/18 page 1
Experiment Results
Predict Question:
Predict Question: How will the action potential at R1 (or R2) change as you continue to increase the stimulus voltage?
Your answer : c. The action potential will not change.
An increase in extracellular K+ would depolarize a neuron. This depolarization would occur if neurons were damaged. From
what you have just learned about generating an action potential, what effect would this have on nearby axons? The nearby
axonal membranes will ___________.
You correctly answered: b. be depolarized to values near or above threshold voltages.
Experiment Data:
Stimulus Voltage (mV) Peak Value at R1 (µV) Peak Value at R2 (µV) Action Potential
10 0 0 No
20 100 100 Yes
30 100 100 Yes
40 100 100 Yes
50 100 100 Yes
03/07/18 page 2
03/07/18 page 3
03/07/18 page 4
03/07/18 page 5
Post-lab Quiz Results
You scored 100% by answering 3 out of 3 questions correctly.
2. If a graded receptor potential made the resting membrane potential of the axon more negative (for example, -70 mV
changes to -75 mV), you would expect
You correctly answered: d. it to be more difficult for this axon to reach the threshold voltage.
3. Failure to reach the threshold voltage in the axon of a sensory neuron could be caused by
You correctly answered: d. all of the above.
03/07/18 page 6
Review Sheet Results
1. Define the term threshold as it applies to an action potential.
Your answer:
Threshold, when applied to action potentials, is the minimum stimulus required for an action potential to occur.
3. How did the action potential at R1 (or R2) change as you increased the stimulus voltage above the threshold voltage?
How well did the results compare with your prediction?
Your answer:
The magnitudes of depolarization recorded at R1 and R2 did not change as the stimulus voltage was increased aboce the
threshold voltage. The results showed that stimulus voltages of 30, 40, and 50 mV all had the same values at R1 and R2.
03/07/18 page 7