Documentos de Académico
Documentos de Profesional
Documentos de Cultura
ARCHITECTURAL COATINGS
TOUCHWOOD
www.asianpaints.com/oman NC Thinner
PRODUCT DESCRIPTION
BERGER Touchwood NC Thinner is a special thinner used primarily in NC system, where better finish is required. It gives
very good gloss & surface finish, when used in NC Gloss Lacquer, NC Colour Top Coats , AC Clear and Pigmented Top
Coats.
TECHNICAL DATA
Composition Nominal : Homogenous mixture of several low boiling solvents
APPLICATION DATA
Thinning ratio (by vol.) : As recommended in the individual data sheet of NC topcoat / AC Products.
APPLICATIONS DETAILS
It gives desired application viscosity when mixed with various suitable paints (as recommended in the individual Product
Data Sheet) and as per existing market practices.
However, due to its slower drying compared to universal thinner, it may create problem in drying on poor quality MDF
substrate. Hence it should be carefully used in Primer and Sealer.
Special instruction:
This thinner is available in three variants of drying : Fast drying / Medium drying / Slow drying.
Select the most appropriate type as per prevailing weather conditions.
Do not use 'Fast Drying' type during high humidity conditions.
RECOMMENDED PAINT SYSTEM
Not applicable.
* For detailed system recommendation based on specific requirements please contact Berger representative.
DISCLAIMER
The information provided in this data sheet is not intended to be complete. It is the responsibility of the user to ensure that the product used is suitable for the purpose it is meant to serve.
In view of various factors affecting the performance of the coating, we cannot assume responsibility for the product performance, nor do we accept any liability arising from use of this
product, unless specifcally agreed to in writing by us. The information provided in the datasheet may be modifed by us without notice.
This Technical Data Sheet supersedes those previously issued with immediate effect.
Version: 02/2007