Documentos de Académico
Documentos de Profesional
Documentos de Cultura
BN9603775A
Method:
1/ Attach an Isolated Mains Supply to the Live & Neutral Connector CN801. (Fig 1)
3/ At CNM801 Pin 2 check for the Standby +5V. This is an EVER voltage used to Power the
Main PCB in Standby mode. (Fig 2)
4/ Turn off the Isolated Mains supply. At CNM801, Pin 1, attach the Variable Power Supply.
This is the ON/OFF pin used by the micro to turn ON the Power Supply. (Fig 3)
6/ Turn on the Variable Power Supply and apply approx. 1V. (Fig 3)
This method allows you to check your supply rails before returning the Power Board into the
TV for final checking.
Fig 1 CN801 Mains I/P Fig 2 CNM801 Pin2, +5V Stby
Fig 3, CNM801 Pin 1 O/O switching Fig 4, CNM801 Pins 6-8, +12V
Fig 5, CNM801, Pins 12-14, +5V Fig 6, CMN801, Pin 16, +12V
Fig 7, CNM802 Pins 10-14, +24V Fig 8, CNM803, Pins 10-14, +24V
NOTES
When this board is faulty, I test it before replacing the F9222L to make sure that the board is at fault.
Usually this board is stuck in Standby and I check it by reading the O/P voltages at CNM802 / CNM803.
As shown above they should read +24V. When faulty these read approximately +15V. The switched
+12V rail at CNM801 Pins 6-8 also reads low around +7V.