Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Page 1 of 2
Shutdown SIS
Previous Screen
Product: EXCAVATOR
Model: 320D EXCAVATOR BZP
Configuration: 320D Excavator BZP00001-UP (MACHINE) POWERED BY C6.4 Engine
i01650751
Removal Procedure
Table 1
Required Tools
Tool Part Number Part Description Qty
A 6V-9120 Socket (1) 1
(1)
Tool (A) is a 46 mm socket.
Start By:
A. Remove the engine oil pan. Refer to Disassembly and Assembly, "Engine Oil Pan - Remove
and Install".
B. Remove the oil supply tube. Refer to Disassembly and Assembly, "Crankshaft - Remove".
NOTICE
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 5/24/2017
320D Excavator BZP00001-UP (MACHINE) POWERED BY C6.4 Engine(SEBP5228 - ... Page 2 of 2
Illustration 1 g00534937
1. Use Tool (A) to rotate the crankshaft until two of the pistons are at the bottom center. Remove
connecting rod nuts (1) from the connecting rod. Remove connecting rod cap (2) for one
connecting rod.
2. Remove the lower half of the connecting rod bearing from connecting rod cap (2) .
3. Remove the upper half of the connecting rod bearing from the connecting rod. Push the
connecting rod away from the crankshaft, if necessary.
Note: Use tape or rubber tubing on connecting rod bolts to protect the crankshaft journals. The
sharp edges of the connecting rod bolts could damage the crankshaft journals.
Note: Ensure that identification marks are on the connecting rod, the connecting rod cap and
the connecting rod bearing. The identification marks must be on the bearing tab side for
installation purposes.
Copyright 1993 - 2017 Caterpillar Inc. Wed May 24 13:10:54 UTC+0700 2017
All Rights Reserved.
Private Network For SIS Licensees.
https://127.0.0.1/sisweb/sisweb/techdoc/techdoc_print_page.jsp?returnurl=/sisweb/sisweb/... 5/24/2017