Documentos de Académico
Documentos de Profesional
Documentos de Cultura
The Modbus/TCP server will plug in to any slot on the Microtech 2000 series integrators
but the end plate is tight and may need to be nibbled out. Set up is same as MT3000
series.
Reference the appropriate Serial Communications manual for your Microtech Integrator
for the Modbus Data address registers.
Model Manual
MT2100, MT3100 REC 3948
MT2001, MT2101, MT2201. MT2301, MT3101 REC 3949
MT2102 REC 4037
MT2104 REC 3951
MT2105, MT2305, MT3105 REC 3952
MT2106, MT3106 REC 3953
MT2107, MT3107 REC 3987
00-20-4A-74-05-52 OR 00:20:4A:74:05:52
Every device connected to an IP network must have a unique IP address.
This address is used to reference the specific unit.
A destination IP address and a port number define every TCP connection and
every UDP datagram. For example, a Telnet application commonly uses port
number 23. A port number is similar to an extension on a PBX system.
The units serial channel (port) can be associated with a specific TCP/UDP
port number. Port number 9999 is reserved for access to the units Setup
(Configuration) Mode window.
Setting the units IP address to 0.0.1.0 can disable AutoIP. This setting
enables DHCP but disables AutoIP.
A90875
A90876
A90877
A90878
A90879
Confirm the Reply received messages display in the window indicating the IP address has
been entered successfully.
Note: If you do not receive Reply received messages, make sure the unit is
properly attached to the network and that the IP address assigned is valid for
the particular network segment you are working with. If you are not sure,
check with your systems administrator.
Click Back to return to the DeviceInstaller main window.
A90880
Red Diagonstics
Green Channel 1 (blinks green when active)
3 1
2 4 Green Network Status (solid green)
Yellow Channel 2 (not used)