Está en la página 1de 11

D EUTSCHE NORM October 1999

Rubber Tolerances for products {


Part 1: Dimensional tolerances
(ISO 3302-1 : 1996) ISO 3302-1
ICS 83.140.01 Supersedes DIN 7715-2,
February 1977 edition,
Gummi Toleranzen fr Fertigteile Teil 1: Matoleranzen and DIN 7715-3,
(ISO 3302-1:1996) November 1983 edition.

This standard incorporates International Standard


ISO 3302-1 Rubber Tolerances for products Part 1: Dimensional tolerances.

A comma is used as the decimal marker.

National foreword
This standard has been prepared by ISO/TC 45.
The responsible German body involved in its preparation was the Normenausschu Kautschuktechnik (Rub-
ber Technology Standards Committee).
The DIN Standards corresponding to the International Standards referred to in clause 2 of the ISO Standard
are as follows:
ISO 48 DIN ISO 48
ISO 471 DIN ISO 471
ISO 2230 DIN 7716

Amendments
DIN 7715-2, February 1977 edition, and DIN 7715-3, November 1983 edition, have been superseded by the
specifications of DIN ISO 3302-1.

Previous editions
DIN 7715: 1958x-12, 1970-08; DIN 7715-2: 1977-02; DIN 7715-3: 1977-02, 1983-11.

National Annex NA
Standard referred to
(and not included in Normative references)
DIN 7716 Requirements for storage, cleaning and maintenance of rubber products

ISO Standard comprises 9 pages.

No part of this standard may be reproduced without the prior permission of Ref. No. DIN ISO 3302-1 : 1999-10
DIN Deutsches Institut fr Normung e. V., Berlin. English price group 07 Sales No. 0407
Beuth Verlag GmbH, D-10772 Berlin, has the exclusive right of sale for German Standards (DIN-Normen).
03.00
Page 1
ISO 3302-1 : 1996

Rubber Tolerances for products


Part 1: Dimensional tolerances
Page 2
ISO 3302-1 : 1996
Page 3
ISO 3302-1 : 1996
Page 4
ISO 3302-1 : 1996
Page 5
ISO 3302-1 : 1996
Page 6
ISO 3302-1 : 1996
Page 7
ISO 3302-1 : 1996
Page 8
ISO 3302-1 : 1996
Page 9
ISO 3302-1 : 1996

También podría gustarte