AASHTOIAWS D1.5WWD1.5:2015,
Annex L (Informative)
Weld Quality Requirements for Tension Joints
This annex is not part of AASHTO/AWS D1.SM/D1.S:2015 Bridge Welding Code,
but is included for informational purposes only.
oe 206) 10 8 1 (92)1N6 [V8] >]
EDGE OF MATERIALS
A, STOEOR ROT OF ~
FLANGE-T0-WEB WELD EDaE oF
MATERIAL
x4 x; X
wei
20
Ey
alone L (34)
1 (5792) 1N 25
58 2-44 a a2 sve) 38159)
a a a ALLDIMENSIONS
ervey steel} fn} IN mm i
Note:
‘A—minimum clearance allowed between edges of porosity or fusion-ype discontinuities 2 mm [1/16 in] or larger. Larger of adjacent
‘iscontinuties governs.
X;—largest allowable porosity or fusionype dicantinuly for 20 mm [3/4 in] joint thickness (see Figure 68),
X2, %, Xi porosity oF fusion-type discontinuity 2 mm [1/16 in] or larger, but less than maximum allowable fr 20 mm [3/4 in] joint
thickness.
Xs, Xs porosity or usion-type discontinuity loss than 2 mm [1/16 in}
Diccontnuly size indicated ie assumed tobe ts greatest mension,
Prosiy or fusion-ypa discontinaty X« isnot acceptable because tis within the minimum clearance alowed between edges of such
siscontinuties (see 6 26.2.1 and Figure 6.8). Remainder of welds acceptable.
263