BRIDON
BRIDON International Ltd
Willington Quay.
Quality Standard =WQTI.55_—_Edition.1_ Page 3 of 11
Annex A
Ferrule Selection and Process criteria
Flemish | Superioop | Pressure Ferrule Diameter:
Product | EyeCore | DieLiner | Release load | ‘After Pressing’
Code ‘Status Code = 7 am
Gomes) | Go | NOGo
damm | tae | ssosea | our | a4ntic 850 ts15_ | 7457
| 48mm” | 134% | ssosa4 IN 48 MLC 850 82.90 81.68
somm | 2 | ssoss2 | iN | s2muc | 850 | 995s | 8829
somm | 210 | ssosse | our | some ‘00 9595 | 94064
‘6omm | 2.8" N 950 oss | 103.27
~eimm | 2.02” our 1150 10807 | 10668
om | 2304" our 1300 11926 | 11775
tomm | 3” | s50s76 | IN | Tome 1350 13003 | 12842
wamm | 3° | ss0s76 | our | t6mic 1400 r2003 | 12802
aomm | 31m” | soso | our | 89M 1600) 146.56 | 143.00
Note Pressure Release load settings serve to protect the des from damage and are for indication. Completion of
correct pressing is indicated by complete die closure.
Note ® Inthe case ofthe 1.3/4” ferrale fitted to 48mm dia rope, I is necessary to increase the rope hole atthe nose of
the ferrule in order to pass over the 48mm dia rope. This is achieved by cuting a ataximum of 15min in length
from the front ofthe nose cone.
The Difference is BRIDON—~
BRIDON international Limited Part of the # FKI. Group of Companies
‘Garr Hil Baty Doncaster South Yorkshire NA 8G United Kingdem Tol +44 0) 1902 344010 Fax +44 (0) 01302 360006 wor bridon.com
Registered foe: Faleon Works, PO Boe 7712, Meadow Lane, Lovghborough, Leveetershire LETT 1ZP