‘A chain deve using bush soler chain transmits 5.6 KW of povver. The diving staf oa 2a electric
‘motor nuns at 1440 rpm. and velocity sai is 5. The centre distance ofthe drive issestrcied to 550 =
24 aa and allowable presure onthe pivot joint isnot to exceed 10'N‘mun?. The drive is required 19
operate continuously with periodic hbrication and driven machine s such that load can be regarded
2 fairly constant with jerk and impact. Design the chain drive by calculating leading dimensions,
‘munber of teeth onthe sprocket and specify the breaking strength of the chain Assume a factor of
safety of 13,
Worm
EXERCISES
A double threaded worm drive is required for power transmission between two shafts having their
‘axes at right angles 1 each other. The worm bas 1482" involue teeth. The centre distance is approxi-
smxtely 200 sum. I the axial pitch of the worm is 30 mm 2nd lecd angle is 25°, find 1. lead: 2 pitch
‘circle diameters of worm and worm gear: 3. els angle ofthe Worm: and 4. efficiency ofthe dave st
the cocflcient of fiction is 0.05, (ns. 69 man: 45 man : 385 mum: 67° ; 87.49%
The werm fis place. One can ao see the Two CUBIC werm bearing Bracks and The
big gear.
A double thzeaded worn dive hasan axial pitch of 25 man and. pitch cizcle diameter of 7 mm. The
‘torque on the worm gear shaf is 1400'N-m. The pitch circle diameter of the wom gear is 250m and
‘he tooth pressure angle is 25° Find : 1. tangential force on the worm gear. 2. torque on the worm
shaft 3 separating force on the worm. 4. velocity ratio, and 5. eiciency ofthe deve. if the coefficient
‘of fiction Derween the Worm thread and gear teeth is 0.04
(Ams, 11.2 KN; 88.97 Nm; $220. 82,
7‘A doutle threaded worm drive has an axial pitch of 25 mm anda pitch circle diameter of 70 mm. The
torque om the woum gear shaft is 1400'N-ma. The pitch circle diameter of the worm gears 250 mam and
the tooth pressure angle is 25°, Find: 1 tangential force oa the worm gear, 2. torque on the worm.
shaft 3. separating force onthe worm, 4. velcctysatio, and. efficiency ofthe drive, ifthe coefficient
of friction between the worm thread and gear teeth is 0.04
[Ams 11.2 KN ; 88.97 N-m ; £220 N; 82.9%6]
Design a speedreducer unit of worm and worm wheel for an input of 1 KW with transmission ratio
of 25. The speed of the wom is 1690 rpm. The worm is made of hardened steel and wheel of
phosphor bronze for which the material combination factor is 0.7 Nuun. The static stress for the
‘wheel matcialis 56MPa. The worm is made of double start and the centre distance between the axes
of the worm and whee! is 120 mm. The tooth form isto be 141° involute. Check the design for
strength, wear and heat dissipation.
Design worm and gear speed reduces to transuuit22 KW a a speed of 1440 p.m. The desied velocity
ratio is24: 1. Aneificieacy of atleast 85% is desired. Assume that the worms made of hardened steel
and the gear of phosphor broaze.