TABLE J3.2
Design Strength of Fasteners
Tensile Strength
Shear Strength in
Bearing-type Connections
Desctiption of Fasteners
Resistance
Facior@
Nominat
Strength, ksi
Resistance
Factor ¢
Nominal
Strength, ksi
‘A307 bolts
45 {al
24 Ibe]
‘A325 bolts, when threads |
are not excluded from
shear planes
2016)
43 [o]
‘A325 bolts, when threads |
are excluded from shear
planes:
2010)
60 Ie]
‘AAQ0 bolts, when threads
are not excluded from
shear planes
113 [0]
60 fe)
“AAS0 bolts, when threads
are excluded from shear
planes:
ors
113 [0]
o7s
Bel
‘Threaded parts meeting
the requirements of Sect.
AS, when threads are not
‘excluded from shear planos
75K [a,c]
0.405,
Threaded parts meeting
‘the requirements of Sect.
‘43, when threads are
excluded from shear planes
075%, [a.c]
0.80F; fa.c]
‘4502, Gr.1, hotdriven
rivets.
45a)
2516)
‘A502, Gr.2 & 3, hot-diven
rivets.
60 [a]
2316)
[a] Stati loading ony.
[b] Threads pemited in snear planes.
[G] The nor tensile stength cf the ttreaded potion ofan upset rod, based upon the cross-sectional
teat is major ted diameter, Apshal be larger than the nominal body rea ofthe rod before
Upseting tines Fj
[i] For A325 and A480 bats subjcttotensle fatigue loading, see Appendix K3.
[e] Wien bearing-ype connections used to splice lenson members nave a fastener pattem whose
lengih, measured paralelto the Ine of ferce, exceeds 50 in, tabuated values shal be reduced by
2D percentTABI
LE J3.3
Nominal Hole Dimensions
Hole Dimensions
gon | standard | oversize Short siot Long stot
Diameter, (Dia.) (Dia.) (Width x Length) Width x Length)
% %e 5 axe ax 104
% ™s te hex ta 19 180
% ‘se 6 ex ig x 17@
% Se | the ‘Shan tN px Zin
1 Me 1% 1M « 1546. 1Mex2%e
2% a+ Ne +5 (d+ Vis) x (d+ %4) (d+%e) x(25xd)
TABLE J3.4
Minimum Edge Distance, in.
(Center of Standard Hole! to Edge of Connected Part)
Nominal Rivet or
‘At Rolled Edges of Plates,
‘Shapes of Bars, or
Bott Diameter (in) At Sheared Edges Gas Cut Edges fc]
Te %
1% i
% 1
% 1218) 18
1 13416) M4
1% 2 1%
1% 24 Ye
Over 1% 1% Diameter 1% x Diameter
[a] Lesser edge distances are pemitadto be used provided Equations rom.J3 10, as appropiate, are
‘satisfied.
[b] For oversized orsictes holes, see Table J23.
[el Al edge distances inthis coluin are permitted tobe reduced-n. when the holes aa point were
‘stess does not axce0d 25 percet ofthe maximum design strength nthe element
Id] These are permited tobe 1Yein at the ends ofleeam comection angles and shear end plates.