Documentos de Académico
Documentos de Profesional
Documentos de Cultura
Control Engineers
1. What are the process Variables?
2. Define all the process Variable and state their unit of measurement. ?
3. What are the primary elements used for flow measurement?
4. What are the different types of orifice plates and state their uses?
5. How do you identify an orifice in the pipe line?
6. Why is the orifice tab provided?
7.What is Bernoulli's theorem and where it is applicable?
7. How do you identify the H. P. side or inlet of an orifice plate in line?
8. How do you calibrate a D. P. transmitter?
9. What is the seal liquid used for filling impulse lines on crude and viscous liquid ?
10. How do you carry out piping for a Different pressure flow transmitter on liquids, Gas and
steam services Why ?
11. Draw and explain any flow control loop ?
12. An operator tells you that flow indication is more, How would you start checking?
13. How do you do a zero check on a D.P. transmitter ?
14. How would you do Glycol filling or fill seal liquids in seal pots 7 Draw and explain.
15. How do you calculate new factor from new range using old factor and old range?
16. How will you vent air in the D.P. cell? What if seal pots are used?
17. Why flow is measured in square root?
18. What is absolute pressure?
41. What will happen if the displacer has a hole in it while in line?
42. What is the used of Suppression and elevation?
43. How will you commission D.P. transmitter in field in pressurized vessel.
44. How will you check zero of a level D.P. transmitter while is line?
45. Explain the working of an Enraf level gauge?
46. What are the different methods of temperature measurement? Explain
47. What is Pt 100 mean?
48. What is two wire and three wire R.T.D. system?
49. Draw a potentiometer temp. Measuring circuits and explain its?
50. What is the constant voltage unit?
51. Explain the working of a balancing motor.
52. What is burnout feature ? Explain
53. Why are Thermowells used ?
54. What type of sensing element would you use to measure very low temperature ?
55. What are skin temperature thermocouples ?
56. What is the specialty of thermocouples lead wires ?
57. What is the difference the a wheatstone bridge and a potentiometer ?
58. Explain the application of proportional integral and derivative action?
59. Where is on off control used?
60. What is reset-wind up?
61. Why is reset called integral and Rate derivative ?
62. Explain tuning of controllers.
63. Explain the working of an electronic P.I.D. controller.